Operating instructions

TROUBLESHOOTING
Collectramatic
®
Fryers – 8000 Series Control – OF49C & OF59C – A&W Food Services of Canada Inc. 27
www.winstonind.com
800-234-5286
TROUBLE FAULT CODE
ALL FRYERS
Power lamp fails to light .......................................................................................... 1, [CS]
Power lamp dim ............................................................................................................ 1, [CS]
Heat ON lamp not on when heating ................................................................ [CS]
Display reads “Lo” or “Heat”, heat on lamp is off, and ........................ 14
fryer is not heating up
No heat (all lamps out) ............................................................................................. 1, [CS]
Heats slowly .................................................................................................................... [CS]
Cooking oil smoking excessively ....................................................................... 2, 3, [CS]
Cooking oil foaming excessively ........................................................................ 3
Cooking oil boils over ................................................................................................ 4, 5, 6, 7
Cooking oil has burnt or bad taste ................................................................... 8, 9, [CS]
Cooking oil breaking down too quickly .......................................................... 8, 9, 10 [CS]
Cooking oil leak around collector gasket ..................................................... 11, 12
Controls not responding correctly ..................................................................... [CS], 13
Hi Limit light is lit .......................................................................................................... [CS], 13
[CS] Call for service (see page 28)
FAULT CODE CORRECTION
1. Open power line (check circuit breaker) ........................... Adjust or [CS]
2. Cooking oil level below top heater .................................... Adjust, See page 13
3. Cooking oil badly broken down ......................................... Clean or Replace
See pages 18-19
4. Cracklings left in or allowed to overfill .............................. Clean,
See pages 18-19
5. Never stir in collector after warm-up ................................. See pages 17
6. Heat plate left out of collector (if using long collector)...... Replace
7. Improper warm-up (solid cooking oil in collector) ............. Adjust
See pages 14-15
8. Cracklings allowed to reach bottom heaters ..................... Clean,
See pages 18-19
9. Heater holder slipped - heaters touching.......................... Adjust or [CS]
10. Fryer not kept clean .......................................................... Clean,
See page 18-19
11. Pot groove for collector gasket dirty ................................. Clean,
See pages 18-19
12. Collector gasket dirty or damaged .................................... Clean or Replace
See pages 18-19
13. Maximum allowable temperature exceeded ..................... See page 7
14. Aqualert sensing is activated ................................................ See Aqualert section
on next page.
[CS]-Call for Service (see page 28)