Service Manual User guide

SECTION 7 - BASIC ELECTRICAL INFORMATION & SCHEMATICS
3121198 – JLG Lift – 7-15
Table 7-1. Connector Identification
CONNECTOR DESCRIPTION
X001 Ground Module, J1
X002 Ground Module, J2
X003 Ground Module, J3
X004 Ground Module, J4
X007 Ground Module, J7
X008 Ground Module, J8
X009 IGN Relay
X010 Power Module (Sevcon), P
X011 Main Harness power
X012 Drive Module
X013 Ground Module Supply
X014 Ground Control Pass-thru
X015 Transport Limit Pass-thru
X016 Lift Down Pass-thru
X017 Strobe/Alarm Pass-thru
X018 Tele Limit Pass-thru
X019 Boom Cable
X020 Jack Switches Pass-thru
X021 Valves Pass-thru
X022 Engine Pass-thru
X023 Ground Outriggers Sw
X024 Ground Swing Sw
X025 Ground Enable Sw
X026 Ground Key Sw
X027 Ground Hour Meter
X028 Ground Alarm
X029 Ground Analyzer Port
X030 Ground LED Board
X031 Ground Lift Sw
X032 Ground Jib Sw
X033 Ground Tele Sw
X034 Ground Level Sw
X035 Ground Choke Sw
X036 Ground Start Sw
X037 Ground EMG Stop
X038 Strobe Light
X039 Lift Down Valve Coil
X040 Transport Limit Sw
X041 Tele Limit Sw
X042 F/L Jack Limit Sw
X043 F/R Jack Limit Sw
X044 R/L Jack Limit Sw
X045 R/R Jack Limit Sw
X046 F/L Jack Valve Coil
X047 F/R Jack Valve Coil
X048 R/L Jack Valve Coil
X049 R/R Jack Valve Coil
X050 Motion Alarm
X051 Lift Hook Harness to X019
X052 Lift Hook Harness to X054
X053 Lift Hook Harness to Console X058
X054 Platform Harness to X019
X055 Platform Boom Connector
X056 Jib Down Valve Coil
X057 Platform Harness to console X058
X058 Platform Console Main
X059 Console Pass-Thru
X060 Platform Module
X061 Joystick
X062 EMG Stop
X063 Rotary Select Sw
X064 Choke Sw
X065 Start Sw
X066 Alarm
X067 Drive, L Forward
X068 Drive, R Forward
X069 Drive, L Reverse
X070 Drive, R Reverse
X071 Drive, Dump
X072 Drive, Left Prox Sw
X073 Drive, Right Prox Sw
X074 Drive Module, A
X075 Drive Module, B
X076 Drive Module, Analyzer
X077 Swing Left Coil
X078 Swing Right Coil
X079 Jib Up Coil
X080 Level Up Coil
X081 Level Down Coil
X082 Tele Out Coil
X083 Tele In Coil
X084 Lift Up Coil
X085 L/J Stow Coil
X086 L/J Set Coil
X087 Dump Valve Coil
X088 Starter Sol. Fuse
X089 Starter Sol.
X090 Engine Stop Relay
X091 Throttle Pull Relay
X092 Engine Oil Level Switch
X093 Engine Choke Pull Relay
X094 Engine Oil Pressure Switch
Table 7-1. Connector Identification
CONNECTOR DESCRIPTION