anual ckmanual Excella® E-1 Open Air Shaker gEN) New Brunswick™ Excella® E-1 Open Air Shaker Operating manual
Copyright © 2014 Eppendorf AG, Germany. No part of this publication may be reproduced without the prior permission of the copyright owner. The company reserves the right to change information in this document without notice. Updates to information in this document reflect our commitment to continuing product development and improvement. Eppendorf® and the Eppendorf logo are registered trademarks of Eppendorf AG, Germany. New Brunswick™ and the New Brunswick™ logo are trademarks of Eppendorf AG, Germany.
Table of contents New Brunswick Excella® E-1 Open Air Shaker English (EN) Table of contents 1 Operating instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 1.1 Using this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 1.2 Danger symbols and danger levels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Table of contents New Brunswick Excella® E-1 Open Air Shaker English (EN) 11 Declaration of conformity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27 Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating instructions New Brunswick Excella® E-1 Open Air Shaker English (EN) 1 1.1 Operating instructions Using this manual Carefully read this operating manual before using the device for the first time. Also observe the operating manual enclosed with the accessories. The operating manual should be considered as part of the product and stored in a location that is easily accessible. When passing the device on to third parties, be sure to include this operating manual.
Operating instructions New Brunswick Excella® E-1 Open Air Shaker English (EN) 1.3 Symbols used Example Meaning You are requested to perform an action. 1. 2. Perform these actions in the sequence described. • List. References useful information.
Safety New Brunswick Excella® E-1 Open Air Shaker English (EN) 2 2.1 Safety User profile CAUTION! This equipment must be operated as described in this manual. If operational guidelines are not followed, equipment damage and personal injury can occur. Please read the entire Operating Manual before attempting to use this unit. Do not use this equipment in a hazardous atmosphere or with hazardous materials for which the equipment was not designed.
Safety New Brunswick Excella® E-1 Open Air Shaker English (EN)
Product description New Brunswick Excella® E-1 Open Air Shaker English (EN) 3 3.1 Product description Main illustration Abb. 3-1: Excella E-1 front and back view 2 1 Fig. 3-1: 3 4 5 Excella E-1 front and back view 1 Speed dial 4 Fuse holder 2 Electrical specification plate 5 Power connector 3 ON/OFF Switch 3.2 Overview The Excella E-1 is a portable benchtop shaker utilizing a UniCentric™ single eccentric counterbalanced drive to provide horizontal plane rotary motion in a 1.
Product description New Brunswick Excella® E-1 Open Air Shaker English (EN)
Installation New Brunswick Excella® E-1 Open Air Shaker English (EN) 4 4.1 Installation Inspection and unpacking Inspection of Boxes After you receive your order from Eppendorf, inspect the boxes carefully for any damage that may have occurred during shipping. Report any damage immediately to the carrier and to your local Eppendorf Sales Order Department. Packing List Verification Verify against your packing list that you have received the correct materials. 4.
Installation New Brunswick Excella® E-1 Open Air Shaker English (EN) 4.3 Installing a platform A platform must be installed on the shaker prior to use. 1. Loosen the four knobs on the SPILL COVER that is bolted to the bearing housing. Abb. 4-1: Platform installation (top view) 1 2 3 Fig. 4-1: Platform installation (top view) 1 Knobs (4) 3 Speed dial 2 Spill cover 2. Aligning the four slots in the platform with the four holes in the SPILL COVER, place the platform on the SPILL COVER. 3.
Installation New Brunswick Excella® E-1 Open Air Shaker English (EN) NOTICE! Damage to shaker Do not over fill flasks. 1. Clamps are installed by securing the base of the clamp to the platform with the correct type and number of screws. Eppendorf flask clamps are used on a variety of shaker platforms. Flat head screws of different lengths and thread pitch are used to secure the clamp.
Installation New Brunswick Excella® E-1 Open Air Shaker English (EN)
Operation New Brunswick Excella® E-1 Open Air Shaker English (EN) 5 5.1 Operation Starting the E-1 WARNING! Make sure the speed dial is set to 0 % before turning on the power. 1. Verify that the SPEED DIAL is set to 0 %. The shaker is turned on or off by the ON/OFF POWER SWITCH located on the rear panel of the unit, not by the 0% setting of the SPEED DIAL. The 0% setting is the minimum speed at which the shaker operates. We recommend starting and stopping the shaker at this speed. 2.
Operation New Brunswick Excella® E-1 Open Air Shaker English (EN)
Troubleshooting New Brunswick Excella® E-1 Open Air Shaker English (EN) 6 6.1 Troubleshooting Troubleshooting guide If any problems occur with your shaker, do not attempt to perform any service on the shaker other than specified in this manual. Unauthorized servicing may void the warranty. Please contact your local Eppendorf Service Department. In any correspondence with Eppendorf, please refer to the Model Number and Serial Number of your shaker.
Troubleshooting New Brunswick Excella® E-1 Open Air Shaker English (EN)
Maintenance New Brunswick Excella® E-1 Open Air Shaker English (EN) 7 7.1 Maintenance Cleaning external surfaces WARNING! Always turn off the shaker and disconnect the power cord from the power supply before performing any maintenance on the shaker. A detachable main power cord has been provided with your unit. Only use the cord provided and do not replace cord with an inadequately rated cord.
Maintenance New Brunswick Excella® E-1 Open Air Shaker English (EN)
Technical data New Brunswick Excella® E-1 Open Air Shaker English (EN) 8 8.1 Technical data Specifications Shaking Speed 50 rpm – 400 rpm Motion 1.91 cm (¾ in) diameter circular orbit Drive UniCentric™ single eccentric counterbalanced ball bearing drive Operating ambient environment • 5 – 45 °C • 20 – 80 % humidity, non-condensing • Up to 2000 m Automatic restart • Shaker will automatically restart after undesired power interruption.
Technical data New Brunswick Excella® E-1 Open Air Shaker English (EN)
Ordering information New Brunswick Excella® E-1 Open Air Shaker English (EN) 9 9.1 Ordering information Parts and accessories When ordering replacement or accessory parts, or requesting service, please provide the Model Number and Serial Number of your shaker. This information is on the ELECTRICAL SPECIFICATION PLATE located on the rear of the shaker. 9.1.
Ordering information New Brunswick Excella® E-1 Open Air Shaker English (EN) Clamp type Part number 25 ml Erlenmeyer Clamp, stainless steel M1190-9004 50 ml Erlenmeyer Clamp, stainless steel M1190-9000 125 ml Erlenmeyer Clamp, stainless steel M1190-9001 250 ml Erlenmeyer Clamp, stainless steel M1190-9002 500 ml Erlenmeyer Clamp, stainless steel M1190-9003 9.1.
Transport, storage and disposal New Brunswick Excella® E-1 Open Air Shaker English (EN) 10 10.1 Transport, storage and disposal Disposal In case the product is to be disposed of, the relevant legal regulations are to be observed.
Transport, storage and disposal New Brunswick Excella® E-1 Open Air Shaker English (EN)
Declaration of conformity New Brunswick Excella® E-1 Open Air Shaker English (EN) 11 Declaration of conformity The E-1 shaker has been tested to the appropriate standards as attested in the following Declaration of Conformity.
Declaration of conformity New Brunswick Excella® E-1 Open Air Shaker English (EN) Declaration of Conformity The product named below fulfills the requirements of directives and standards listed. In the case of unauthorized modifications to the product or an unintended use this declaration becomes invalid. Product name: Excella® E1 including accessories Product type: Benchtop open air shaker Relevant directives / standards: 2006/95/EC: EN 61010-1, UL-61010-1, CAN/CSA-C22.2 No.
Index New Brunswick Excella® E-1 Open Air Shaker English (EN) Index T Trouble shooting guide......................................... 17 C Clamp installation..................................................12 U Cleaning ................................................................19 Using this manual ................................................... 5 Connecting to mains/power ..................................13 D Danger level ............................................................
Index New Brunswick Excella® E-1 Open Air Shaker English (EN)
Evaluate your manual Give us your feedback. www.eppendorf.com/manualfeedback Your local distributor: www.eppendorf.com/contact Eppendorf AG · 22331 Hamburg · Germany eppendorf@eppendorf.com · www.eppendorf.
