INSTALLATION, OPERATION & MAINTENANCE MANUAL Reach-In Refrigerators and Freezers IMPORTANT Please read this manual completely before attempting to install or operate this equipment.
Installation, Operation & Maintenance Manual TABLE OF CONTENTS SPECIFICATIONS.............................................................................................................................................................................. 3 SAFETY INSTRUCTIONS.................................................................................................................................................................. 5 INTRODUCTION.............................................................
REACH-IN REFRIGERATORS AND FREEZERS SPECIFICATIONS SOLID DOOR REFRIGERATORS MODEL # V/Hz/Ph AMPS STORAGE SHELF CAPACITY CAPACITY HP BTU CHARGE SHIP WEIGHT Cu-ft Sq-ft AR23 115/60/1 6 23 AR49 115/60/1 9 49 NEMA PLUG Oz Lbs 14.0 3/8 3200 12.0 350 5-15P 28.1 1/2 5800 18.7 518 5-15P HP BTU CHARGE SHIP WEIGHT NEMA PLUG Oz Lbs SOLID DOOR FREEZERS MODEL # V/Hz/Ph AMPS STORAGE SHELF CAPACITY CAPACITY Cu-ft Sq-ft AF23 115/60/1 11 23 14.0 6/8 2325 14.
Installation, Operation & Maintenance Manual REGISTRATION The installation date and appliance model must be documented by the end purchaser. . Also, refer to the Warranty section for additional details on registering the appliance.
REACH-IN REFRIGERATORS AND FREEZERS SAFETY INSTRUCTIONS General Safety WARNING Arctic Air accepts no responsibility for any situation resulting from work carried out in an unprofessional manner, or from the incorrect interpretation or application of regulations. General Installation WARNING Incorrect installation or any modifications made to the appliance may damage property or result in injury or death.
Installation, Operation & Maintenance Manual INTRODUCTION This manual covers the Reach-In Refrigerators and Freezers. Please read this manual completely before attempting to install or operate this equipment. • Confirm that all flooring is structurally strong enough to support the weight of a fully loaded unit; a fully loaded unit can weigh as much as 1500 pounds. Consult with a structural engineer for confirmation if there is any reason to doubt the floor strength.
REACH-IN REFRIGERATORS AND FREEZERS INSTALLATION Location Electrical connection All units are intended for indoor use only. A fully loaded unit can weigh as much as 1500 pounds. Choose a location with a level floor strong enough to support the total weight of a fully loaded unit. Reinforce the floor if necessary. Refer to the amperage data provided in the SPECIFICATIONS, the serial tag, the local electrical code and/or the National Electrical Code.
Installation, Operation & Maintenance Manual OPERATION Refrigeration Cycles Refrigerators The evaporator fans run continuously during the refrigeration cycles to maintain the factory set internal temperature range at 34°F to 38°F. The door switch turns on the lights when the door is opened. 1. 2. Every 6 hours, the unit turns off and the controller displays the defrost symbol this allows the evaporator coil to clear the ice.
REACH-IN REFRIGERATORS AND FREEZERS Functions Display the Set Point: Alarm Codes CAUSE OUTPUTS P1 Room probe failure Compressor output according to par Con and COF P2 Evaporator probe failure Defrost end is timed P3 Condenser probe failure Outputs unchanged HA Maximum temperature alarm Outputs unchanged The set point value is displayed and the Compressor LED starts blinking. LA Minimum temperature alarm Outputs unchanged dA Door open Compressor and fans restart 2.
Installation, Operation & Maintenance Manual MAINTENANCE DANGER Turn off the power switch and disconnect the unit from the power source whenever performing service/ maintenance functions and/or cleaning the refrigerated area. Refrigerators and Freezers Clean the interior and exterior using soap and warm water. If this is not sufficient, use ammonia and water or a nonabrasive liquid cleaner. When cleaning the exterior, always rub with the stainless steel grain to avoid marring the finish.
REACH-IN REFRIGERATORS AND FREEZERS Gasket Maintenance Open the Top Shroud Gaskets require regular cleaning to prevent mold and mildew buildup and to maintain the gasket elasticity. Clean gaskets with warm soapy water. Avoid full strength cleaning products on gaskets, this can cause the gaskets to become brittle and prevent proper sealing. Never use sharp tools or knives, which could tear the gasket and/or rip the bellows, to scrape or clean the gasket.
Installation, Operation & Maintenance Manual 5. Maintain the door/hinge assembly at about 100°, and slide it up to the top hinge pin. Confirm proper alignment, and then fasten the bottom hinge. 6. The door must swing closed by itself with no restriction, confirm that the door swings freely. 7. Restore power to the unit and confirm that the interior light turns on and off as the door opens and closes and that the evaporator fan is running. 8.
REACH-IN REFRIGERATORS AND FREEZERS WIRING DIAGRAMS Model: AR23 Models: AR49 13
Installation, Operation & Maintenance Manual Model: AF23 Models: AF49 14
REACH-IN REFRIGERATORS AND FREEZERS Model: AR23 15
Installation, Operation & Maintenance Manual Model: 16 AR49
REACH-IN REFRIGERATORS AND FREEZERS Model: AF23 17
Installation, Operation & Maintenance Manual Model: 18 AF49
REACH-IN REFRIGERATORS AND FREEZERS ARCTIC AIR WARRANTY One year parts & labor warranty Arctic Air warrants to the original purchaser, all of its new equipment to be free from defects in material or workmanship, under normal use and maintenance service, for a period of one (1) year from the date of original purchase or 15 months after shipment date from the manufacturer, whichever occurs first.
Broich Enterprises, Inc. / Arctic Air 6440 City West Parkway Eden Prairie, MN 55344 Phone: 952-941-2270 Fax: 952-941-3066 Website: www.arcticairco.
