SDS

ManualsBrandsUSG Ceilings ManualsBuilding materialsLuna ClimaPlus 2 ft. x 2 ft. Lay-in Ceiling Tile (12-Pack)

SAFETY DATA SHEET

1. Identification

Product identifier Eclipse™ Acoustical Ceiling Panels

Other means of identification

SDS number

41263320001

Additional Products

Eclipse™ HRC, Eclipse™ Illusion, Eclipse™ Pedestals™, Luna™, Luna™ Pedestals™, Mars™

(including Planks and Logix), Mars™ Healthcare, Mars™ High NRC (including Planks and Logix),

Mars™ HRC (including Planks), Mars™ High CAC, Millennia®, Millennia® High-NRC, and

Millennia® Illusion

Synonyms

Ceiling Tiles, Mineral Fiber Ceiling Panels/Tiles

Recommended use

Interior use.

Recommended restrictions

Use in accordance with manufacturer's recommendations.

Manufacturer/Importer/Supplier/Distributor information

Company name

USG Interiors, LLC

Address

550 West Adams Street

Chicago, Illinois 60661-3637

Telephone

1-800-874-4968

Website

www.usg.com

Emergency phone number

1-800-507-8899

2. Hazard(s) identification

Not classified.

Physical hazards

Not classified.

Health hazards

Not classified.

OSHA defined hazards

Label elements

None.

Hazard symbol

Signal word

None.

Hazard statement

None.

Precautionary statement

Prevention

Observe good industrial hygiene practices.

Response

Get medical attention/advice if you feel unwell.

Storage

Store as indicated in Section 7.

Disposal

Dispose of in accordance with local, state, and federal regulations.

Hazard(s) not otherwise

classified (HNOC)

None known.

3. Composition/information on ingredients

Mixtures

N/A ≥ 80Slag wool fiber

CAS number %Chemical name

1332-58-7 < 10Kaolin

9005-25-8 < 5Starch

Trade Secret < 4Styrene-based acrylate

polymer

21645-51-2 < 2Aluminum hydroxide

471-34-1 < 2Calcium carbonate

Eclipse™ Acoustical Ceiling Panels SDS US

917541 Version #: 01 Revision date: - Issue date: 19-December-2014

1 / 8

Summary of content (8 pages)

PAGE 1
SAFETY DATA SHEET 1.
PAGE 2
Calcium sulfate dihydrate (alternative CAS 10101-41-4) 13397-24-5 <2 Continuous filament glass fiber 65997-17-3 <2 Limestone 1317-65-3 <2 Composition comments All concentrations are in percent by weight unless ingredient is a gas. Raw materials and/or coatings in this product contain small amounts of titanium dioxide, which has been classified as possibly carcinogenic to humans by the International Agency for Research on Cancer (IARC).
PAGE 3
8. Exposure controls/personal protection Occupational exposure limits U.S. - OSHA Components Type Value Form Slag wool fiber (CAS N/A) TWA 5 mg/m3 15 mg/m3 Fiber, respirable (diameter ≤ 3.5 µm and length ≥ 10 µm) Fiber, total US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) Components Type Value Form Calcium carbonate (CAS 471-34-1) PEL 5 mg/m3 Respirable fraction. Calcium sulfate dihydrate (alternative CAS 10101-41-4) (CAS 13397-24-5) PEL 15 mg/m3 5 mg/m3 Total dust.
PAGE 4
US. NIOSH: Pocket Guide to Chemical Hazards Components Type Value Form Slag wool fiber (CAS N/A) TWA 3 fibers/cm3 Starch (CAS 9005-25-8) TWA 5 mg/m3 5 mg/m3 10 mg/m3 Fiber, respirable (diameter ≤ 3.5 µm and length ≥ 10 µm) Fiber, total Respirable. Total Biological limit values No biological exposure limits noted for the ingredient(s). Appropriate engineering controls Provide sufficient ventilation for operations causing dust formation.
PAGE 5
Relative density 0.24 - 0.35 (H2O=1) Solubility(ies) Solubility (water) Very low solubility in water. Partition coefficient (n-octanol/water) Not applicable. Auto-ignition temperature Not applicable. Decomposition temperature Not applicable. Viscosity Not applicable. Other information Bulk density 15 - 22 lb/ft³ VOC (Weight %) 0 % (see Section 16 for further detail) 10.
PAGE 6
Aspiration hazard Due to the physical form of the product it is not an aspiration hazard. Chronic effects No other specific acute or chronic health impact noted. 12. Ecological information Ecotoxicity Not expected to be harmful to aquatic organisms. Persistence and degradability No data is available on the degradability of this product. Bioaccumulative potential Bioaccumulation is not expected. Mobility in soil No data available. Other adverse effects None expected. 13.
PAGE 7
US state regulations US. Massachusetts RTK - Substance List Calcium carbonate (CAS 471-34-1) Calcium sulfate dihydrate (alternative CAS 10101-41-4) (CAS 13397-24-5) Kaolin (CAS 1332-58-7) Limestone (CAS 1317-65-3) Starch (CAS 9005-25-8) US. New Jersey Worker and Community Right-to-Know Act Calcium carbonate (CAS 471-34-1) Calcium sulfate dihydrate (alternative CAS 10101-41-4) (CAS 13397-24-5) Kaolin (CAS 1332-58-7) Limestone (CAS 1317-65-3) US.
PAGE 8
Further information Slag Wool Fiber: Large morbidity and mortality studies of both European and North American mineral wool manufacturing workers have been conducted. These studies have found no significant association of non-malignant (i.e. fibrosis) or malignant (i.e., lung cancer or mesothelioma) lung disease and exposures to slag wool fibers and have not established a causal relationship between exposure and non-malignant or malignant diseases.