PRODUCT MANUAL Please read this user manual carefully before using or connecting your GRILL.
TABLE OF CONTENTS 2 PRODUCT MANUAL * 3 CONGRATULATIONS ON YOUR CHOICE * 4 GENERAL SAFETY AND INSTALLATION WARNINGS * 7 ELETRICAL SAFETY AND INSTALLATION WARNINGS * 8 GAS SAFETY AND INSTALLATION WARNINGS * 10 GAS CONNECTIONS * 12 HARDWARE PACK * 13 OPERATION - PROPANE GAS GRILLS * 17 CLEANING YOUR APPLIANCE * 18 WARRANTY REGISTRATION * 19 PARTS DIAGRAM * 21 PARTS LISTS * 22 HOW TO ORDER REPAIR PARTS * 23 TROUBLESHOOTING
CONGRATULATIONS ON YOUR CHOICE You have purchased a Grill with advanced design and proved quality. When it comes to BRAZILIAN FLAME Rotisserie Grills, the models 3 skewer and 5 skewer, smokeless, infrared, gas grills are synonymous of technology, a pratical and economic way to host and enjoy the best grilling experience at yout home. Within this Manual you will find the use instructions for safe use your rotisserie grill. READ ALL INSTRUCTIONS BEFORE USING OR CONNECTING THIS PRODUCT.
GENERAL SAFETY AND IN STALLAT ION WARN IN G S NOTE: This manual is the property of the owner. The manufacturer cannot be held responsible for damage or injury caused by improper use of this appliance. When using your grill appliance please read and follow these basic precauti ons: !IMPORTANT: SAVE THIS MANUAL FOR FUTURE REFERENCE. Improper installati on, adjustment, alterati on, service, or maintenance can cause property damage, injury or death.
FOR YOUR SAFETY 1. Do not store or use gasoline or o ther flammable vapors and liquids in the vicinity of this or any other appliance. 2. Do not store any propane/butane (G31 G30) cylinder (that is not connected for use) in the vicinity of this or any other appliance. 3. Hot surface, the gas grill will get hot during its using. Extreme caution when operating NOTE: Check with City and Fire department for Local Building Codes. A Permit may be required for outdoor Kitchen Construction.
be classified as indoor areas, particularly in terms of permanent (non closable) ventilation. Consult the AHJ (Authority Having Jurisdiction) or local contractor of any uncertainty. Please read all instructions before installing or operating your gas appliance to prevent injury and appliance damage. • All gas appliances will get hot during use. Use extreme caution when operating the appliance, especially when you open the glass door. • Do not touch hot surfaces.
• Always open the appliance hood carefully, using only the handle the hood may be hot. • Infants, children, or pets should not be left alone or unattended in an area where any appliance is in use. They should never be allowed to touch, sit or stand on any part of the appliance. • Do not store items of interest to children in cabinets above the appliance or in the appliance Children climbing on the appliance to reach these items could be seriously injured.
GAS SAFETY AND INSTALLAT ION WARNIN G S • Do not twist the gas supply hose. • Before each use, visually inspect the gas supply hose for cracks, cuts or excessive wear. Replace the hose if necessary. Check for gas leaks. • Gas Specifications: Be sure that the gas supplied to the appliance conforms to the model you purchased. This grill can not be use natural gas to operate; the grill requires liquid propane gas to operate. • Never connect the appliance to an unregulated gas supply line.
Checking for Gas Leaks Perform a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any part of the gas system is disconnected or replaced, perform a leak test. As a safety precaution, remember to always leak test your appliance outdoors in a well ventilated area. Never smoke or permit sources of ignition in t he area while doing a leak test.
GAS CO NNECTIONS UNPACKING UNIT: Your GRILL Appliance comes pre assembled and requires very litt le setup. We do however, we always recommend the use of professional help during the installati on of your unit as improper installati on may aff ect your warranty. Remove the unit from the box along with all accessories and check that no damage has occurred to the unit or any parts. Burners: Check the burner tubes and remove any obstructi ons that may be in the ports or holes.
If you smell gas or hear a hiss of gas escaping from the tank, get away from the tank and do not attempt to correct the problem yourself. Call the Fire Department immediately. If your appliance has no leak at the cylinder, then re check for loose connections and retest for leaks using the method detailed in the following pages with soapy solution. Do not subject your LP gas cylinder to excessive heat, and always store the cylinder in an upright position. Never store your LP cylinders indoors.
H ARDWARE PACK Items included with the Grill: Upon receiving the product, check out if all the items shown below are included: • Single skewers: • 3 Skewer Model = 2 units • 5 Skewer Model = 4 units • Triple skewer • 1 unit each model • Fat collecti ng tray • Gas hose with regulator: 1 unit • Adaptor to connect the valve • Drip Tray (for the upper tray models) • Power Cord • Instructi ons manual • Quick Installati on guide 12 PRODUCT MANUAL
O PERATION - P ROPAN E G AS G RILLS Before lighti ng the burners inspect the gas supply piping or hose. If there is evidence of cuts, wear, or abrasion, it must be replace d prior to use. Always keep your face and body as far away from the grill as possible when lighti ng.
LP Hose Connection 1. Connect the 3/8 Flare end of the Gas Hose with regulator. 2. To the 3/8 fl are end of the coupling on the unit using a ¾ open wrench. Do not apply pipe sealant (these are fl are fi ti ng ). 3. Connect the regulador to the LP Cylinder. Use a tool to ti ghten the regulador. Inside and Commercial Use 1. For commercial use and indoors it is necessary to use the adapter as shown below. !IMPORTANT: CERTIFIED BY ANSI Z83.11/CSA 1.8 2016.
Lighting the Appliance 1. Make sure the glass door are closed, than to ignite burners, starts with the upper burner, push the burner knob in and slowly rotate counter clockwise to the high positi on. 2. You will hear a loud click as the electronic lighter produces a spark. Listen for the sound of the gas igniti ng and look for a fl ame through the burner. If the burner does not light on the fi rst try, repeat immediately. (For rear burner, a slower turn of the knob is necessary.
Removing Skewers 1. Turn the skewers rotati on off , press the knob. 2. Open the glass door, right door handler. 3. Hold the skewer’s handle and lift it up unfi tti ng it from its holder. 4. Pull the skewer outside by displacing its ti p from the dragging axle. 5. When grilling is done, turn off the burners. NOTE: • The food must be evenly distributed on each one of the skewers, so that it can easily rotate.
Charging & Battery Live Your grill are equipped with Lithium-Ion batt eries. We have selected these batt eries to give you maximum batt ery life and long running ti mes. 1. Find the charger that comes with your grill. If you have lost yours, see instructi ons on page “How to Order Repair Parts”. Use only the charger provided with the appliance. Do not att empt to use this charger with any other product. Likewise, do not att empt to charge this appliance with any other charger. 2.
C LEANI NG YOUR AP P LIANC E Caution: To prevent injury, use care when cleaning a hot grill. NOTE: Do not use a commercial cleaner. Do not clean the grill while they are hot. NOTE: You should clean your appliance after each use to maintain the overall appearance over the life of your appliance . After the first use, it is normal for your appliance to become discolored in certain areas from the heat produced by the burners.
WARRA NTY REG ISTRAT ION If you have purchased our Grill you must register your product within 30 days of purchase to validate the warranty and maintain your original receipt to get parts for the appliance. You may register your appliance at brazilianflame.com by selecting Contact Us, and then selecting Register your Product. The warranty is for original owners only and cannot be transferred to new owners. You must retain your sales slip or invoice.
PART S DIAG RAM All repair part orders should be placed through your local BrazilianFlame® dealer. To locate a dealer in your area visit www.brazilianflame.com. To ensure prompt and accurate service, please provide the following information when placing a repair part order: Model Number, Serial Number, Part Name, Part Number, and Quantity of parts needed.
PA RT S DIAG RAM BG-05 SKEWER GAS MODEL PRODUCT MANUAL 21
PART S LIST Part Number Index No.
HOW TO ORD ER REPAI R PART S Parts Not Under Warranty Parts can be ordered through your Service Person, Dealer, or a Master Parts Distributor. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the service person/dealer. Warranty Parts Warranty parts will need a proof of purchase and can be ordered by your Service Person or Dealer. Proof of purchase is required for warranty parts. All parts listed in the Parts List have a Part Number.
TRO U BLESHOOTING Although the manufacturer has attempted to ensure that your grill will operate properly and satisfactorily, sometimes problems do arise. The following troubleshooting guide lists several possible problems and their probable cause and solution. Problem Cause Solution Burner will not light. Obstruction in gas line. For propane models, ensure gas valve on cylinder is OFF. Remove flexible hose and blow out any debris.
REC I PES Follow some instructions that describes how to prepare or make some foods in our special rotisserie grill. Type of Meat Time of Coooking Directions Sausages 25 minutes You can use the baskets grills. Temperature: 320°F Beef Ribs Whole Peace 1h 30 minutes Season the beef ribs with rock salt only. If you going Rump Cap Steak Parts 45 minutes Temperature: 350°F 35 minutes Cut the rump cap into steaks of 300g.
@brazilianflame Visit our website at www.brazilianflame.com +1 (833) 753-9374 | +1 (307) 316-0901 If you have a general question about our products, please e-mail us at ola@brazilianflame.com. If you have a service or repair question, please contact your dealer.
