Service Manual

ManualsBrandsToro ManualsRiding EquipmentToro 74625

CHASSIS

3-18

Toro TimeCutter SS/MX/ZS Service Manual

Fig. 028 PICT-1053a

Lower Deck Lift Service

Lower Deck Lift Removal

1. Move deck HOC to the middle position.

2. Support under deck in current position, then move

the deck HOC to the lowest position.

3. Remove the (2) pins and (2) washers that attach the

lift links (D) to the deck lift (E).

4. Remove lift rod clip and washer (K) from deck

assembly. Remove front support rod (L) from deck

bracket (Fig. 030).

5. Slightly lift rear of the deck and slide it rearward

to fully release the rear lift arm (H) from the deck

hanger brackets (I) (Fig. 028).

Lower Deck Lift Installation

1. Install (2) pivot blocks (G) onto rear lift arm ends.

2. Install rear lift arm (H) assembly into frame

C-channel.

3. Properly locate pivot blocks (G) using the pivot block

locating hole on the main frame (V) and the pivot

block locating lug (X) that is cast into the pivot block

(LH side shown) (Fig. 029).

Fig. 029 PICT-1052

6. Remove the (2) bolts and (2) nuts that attach the (2)

pivot blocks (G) to the frame.

7. Rotate the rear lift arm (H) and disengage pivot

blocks (G) from the unit frame C-channel. Drop

the rear lift arm downward and remove it from in-

between the deck and unit frame.

4. Once aligned, install the (2) bolts and (2) nuts that

attach the pivot blocks (D) to main frame. Torque

bolts to specication – 17 ft-lbs. (23 Nm).

5. Slightly lift the rear of the deck and slide the deck

forward. Fully engage the rear lift arm (H) into the

deck hanger brackets (I) (Fig. 028 and Fig. 030).

6. Slide the lift links (D) onto the deck lift posts. Install

the (2) washers and (2) pins that secure the lift links

to the deck lift (E).

7. Install the front support rod (L) into the deck bracket

using clip and washer (K).

8. Lift deck upward and remove supports.

9. Cycle the deck through the HOC range and verify

proper function. Inspect the PTO deck belt for proper

routing and tension.

10. Level the deck as shown in this service manual. See

“Leveling the Mower Deck”, page 6-22 - 6-35.