Operator's Manual
Maintenance
49
Battery
Check the electrolyte level in the battery every 25
hours. Always keep the battery clean and fully
charged. Use a paper towel to clean the battery case.
If the battery terminals are corroded, clean them with
a solution of four parts water and one part baking
soda. Apply a light coating of grease to the battery
terminals to prevent corrosion.
Voltage: 12 v
Checking Electrolyte Level
1. Open covers to see into the cells. The electrolyte
must be up to the lower part of the tube
(Fig. 41). Do not allow the electrolyte to get
below the plates. (Fig. 41).
2. If the electrolyte is low, add the required amount
of distilled water; refer to Adding Water to the
Battery, page 49.
1
2
3
1262
Figure 41
1. Filler
caps
2.
Lower part of tube
3. Plates
Adding Water to the Battery
The best time to add distilled water to the battery is
just before you operate the machine. This lets the
water mix thoroughly with the electrolyte solution.
1. Clean the top of the battery with a paper towel.
2. Lift off the filler caps (Fig. 41).
3. Slowly pour distilled water into each battery cell
until the level is up to the lower part of the tube
(Fig. 41).
IMPORTANT: Do not overfill the battery
because electr
olyte (sulfuric acid) can cause
sever
e corr
osion and damage to the chassis.
4. Press the filler caps onto the battery.
5. Position drain tube away from belts and other
parts to prevent corrosion.
Charging the Battery
IMPORTANT: Always keep the battery fully
charged (1.260 specific gravity). This is
especially important to prevent battery
damage when the temperature is below 32°F
(0°C).
1. Check the electrolyte level; refer to Checking
Electrolyte Level, page 49.
2. Remove the filler caps from the battery and
connect a 3 to 4 amp battery charger to the
battery posts. Charge the battery at a rate of 4
amperes or less for 4 hours (12 volts). Do not
overcharge the battery. Install the filler caps after
the battery is fully charged.
POTENTIAL HAZARD
• Charging the battery pr
oduces gasses.
WHAT CAN HAPPEN
• Battery gasses can explode.
HOW TO AV
OID THE HAZARD
• Keep cigarettes, sparks and flames away
from battery.