Service Manual

Groundsmaster 360 Page 5 - 1 Electrical System
(Rev. A)
Chapter 5
Electrical System
Table of Contents
GENERAL INFORMATION 2.....................
Operator ’s Manual 2..........................
Electrical Drawings 2..........................
Toro Electronic Controller (TEC)
(4WD Machines) 2..........................
CAN- bus Communications (4WD Machines) 2...
Standard Control Module (SCM)
(2WD Machines) 3..........................
SPECIAL TOOLS 4.............................
TROUBLESHOOTING 6.........................
Diagnostic Light (4WD Machines) 6.............
Diagnostic Display (4WD Machines) 9...........
Standard Control Module Logic Chart
(2WD Machines) 14.........................
TEC Logic Chart (4WD Machines) 15............
Starting Problems 16..........................
General Run & Transport Problems 18...........
Cutting Deck Operating Problems 19............
4 Wheel Steer Operating Problems
(4WD Machines) 20.........................
ELECTRICAL SYSTEM QUICK CHECKS 21.......
Battery Test (Open Circuit Test) 21..............
Charging System Test 21......................
Glow Plug System Test 21.....................
Check Operation of Interlock Switches 22........
ADJUSTMENTS 23.............................
Traction Neutral Sensor 23.....................
Parking Brake Sensor 24......................
Steering Home Sensor (4WD Machines) 25......
COMPONENT TESTING 26......................
Ignition Switch (Serial Number Below
312000300) 27.............................
Ignition Switch (Serial Number Above
312000300) 28.............................
Indicator Lights 28............................
Hour Meter 29................................
Fuses (2WD Machines) 30.....................
Fuses (4WD Machines) 31.....................
Operator Cab Fuses (4WD Machines with
Operator Cab) 32...........................
PTO Switch 33...............................
Deck Lift Switch 34............................
Steering Selector Switch (4WD Machines) 35.....
Air Conditioning Switch (4WD Machines with
Operator Cab) 36...........................
Windshield Washer/Wiper Switch (4WD
Machines with Operator Cab) 37..............
Seat Switch 38...............................
Traction Neutral Sensor 39.....................
Parking Brake Sensor 41......................
Steering Home Sensor (4WD Machines) 42......
Standard Control Module (2WD Machines) 43....
Toro Electronic Controller (TEC)
(4WD Machines) 44.........................
Fusible Links 45..............................
PTO Solenoid Valve Coil 46
....................
Hydraulic
Solenoid Valve Coils 47...............
Main Power, Glow, Start (4WD Machines) and
Cab Power (4WD Machines with Operator
Cab) Relays 48.............................
Deck Lift Relay (2WD Machines) 49.............
High Temperature Warning Switch (Machines
without Operator Cab) 50....................
High Temperature Shutdown Switch (Machines
without Operator Cab) 51....................
Dual Temperature Switch (Machines with
Operator Cab) 52...........................
Oil Pressure Switch 53........................
Fuel Pump 54................................
Fuel Stop Solenoid 55.........................
Glow Controller (2WD Machines) 56.............
SERVICE AND REPAIRS 57.....................
PTO Solenoid Valve Coil 57....................
Hydraulic Manifold Solenoid Valve Coils 58.......
Battery Storage 59............................
Battery Care 59...............................
Battery Service 60............................
Electrical
System