Service Manual

Chapter 5
Electrical System
Table of Contents
WIRING SCHEMATICS . . . . . . . . . . . . . . . . . . . . . . 2 Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Engine Crank and Start Circuit . . . . . . . . . . . . . . 2 Injection Pump (ETR) Solenoid . . . . . . . . . . . . . 23
Engine Run Circuit . . . . . . . . . . . . . . . . . . . . . . . 3 Gauges and Indicator Lights . . . . . . . . . . . . . . . 24
Engine Run and Mowing Circuits . . . . . . . . . . . . 4 High Temperature Shut-Down Switch . . . . . . . . 25
SPECIAL TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Temperature Gauge Sender . . . . . . . . . . . . . . . 25
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . 7 Engine Oil Pressure Switch . . . . . . . . . . . . . . . . 26
Starting Problems . . . . . . . . . . . . . . . . . . . . . . . . 7 Fuel Gauge Sender . . . . . . . . . . . . . . . . . . . . . . 26
General Run and Transport Problems. . . . . . . . 10 4WD Solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Cutting Operation Problems . . . . . . . . . . . . . . . 12 Wing Switch. . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Verify Interlock Operation . . . . . . . . . . . . . . . . . 15 PTO Clutch and Wing Cutting Unit Clutch. . . . . 28
TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 REPAIRS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Ignition Key Switch . . . . . . . . . . . . . . . . . . . . . . 16 Battery Service . . . . . . . . . . . . . . . . . . . . . . . . . 29
Seat Switch, Relay and Time Delay Capacitor . 17 Fuses. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Traction (Neutral) Switch . . . . . . . . . . . . . . . . . . 18 Traction (Neutral) Switch Replacement . . . . . . . 31
Axle Hi/Low Switch . . . . . . . . . . . . . . . . . . . . . . 19 4WD Solenoid Coil Replacement . . . . . . . . . . . 32
PTO Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Axle Hi/Low Switch Replacment . . . . . . . . . . . . 32
Start, Cutting Unit, Wing Switch Replacement. . . . . . . . . . . . . . . . . 33
Time Delay and High Temp. Relays . . . . . . . 21
Glow Relay and Glow Plugs . . . . . . . . . . . . . . . 22
Groundsmaster
®
455-D Page 5 - 1 Table of Contents
Electrical System