Operator's Manual
Table Of Contents
- Contents
- Introduction
- Safety
- Safety and Instruction Decals
- Specifications
- Installing Rear Weights
- Before Operating
- Controls
- Operation
- Maintenance
- Recommended Maintenance Sche...
- Fluid Specifications/Change ...
- Service Interval Charts
- Daily Maintenance Checklist
- General Air Cleaner Maintena...
- Servicing the Air Cleaner
- Cleaning the Radiator and Sc...
- Changing the Engine Oil and ...
- Servicing the Fuel System
- Replacing the Fuel Pre Filter
- Bleeding Air from Injectors
- Alternator Belt
- Adjusting the Throttle
- Power Take-Off Belt
- Power Take-Off Clutch Adjust...
- Adjusting the Transmission f...
- Adjusting the Parking Brake ...
- Changing the Hydraulic Oil a...
- Adjusting the Service Brakes
- Changing Rear Axle Lubricant
- Changing the Bi-Directional ...
- Rear Wheel Toe-In
- Servicing the Battery
- Wiring Harness Service
- Fuses
- Storage
25
CHECK/SERVICE (DAILY)
1. Oil levels (Engine/Trans)
2. Coolant level
3. Tire pressure
4. Belts (Fan and power take off)
5. Fuel—Diesel only
6. Battery
7. Grease, lube points
8. Radiator screen
9. Air filter
10. Electrical clutch gap .017-.030
11.PTO Belt tension
12. Water separator
13. Fuel filter
Service Interval Charts
Fluid Specifications/Change Intervals
2 years
Type>0° C Type<0° C Capacity Change Intervals
Engine oil
Transmission
oil
Fuel
Coolant
SAE 30 CD SAE 10W-30 CD 50 hours filter 100 hours
filter 200 hours
filter 400 hours
*
Type F or FA
transmission
fluid
No. 1-D
50/50 mix Ethylene glycol anti-
freeze/water
No. 2-D
SAE 10W-30 SF, CC,
CD
7.6 l
32.2 l
5.7 l
3.7 l with filter
Filters Part No.
A. Air 98-9763
B. Fuel 98-7612
C. Fuel 98-9764
D. Transmission oil 23-2300
E. Engine oil 99-8384