Operator's Manual
!
! !
4216 #,))0 4-8) 2()05 109 -+
Change front differential oil every 800 hours.
Position vehicle on a level surface, stop engine,
engage parking brake and remove key from ignition
switch.
Clean area around drain plug on side of
differential. Place drain pan under drain plug.
-+74)
4216 (-**)4)16-%0
-00',)'/ 307+
4%-1 307+
Remove drain plug and let oil flow into drain pan.
Reinstall and tighten plug when oil stops draining.
Clean area around fill/check plug on side of
differential.
Remove fill/check plug and add 10W30 oil until oil
is up to hole.
Re-install fill/check plug.
$" ! -+
Position the vehicle on a level surface, stop engine,
engage the parking brake and remove key from
ignition switch.
Remove drain plug (Fig. 51) from side of reservoir
and let hydraulic fluid flow into drain pan.
Remove hydraulic line and fitting connected to
strainer on side of reservoir.
Remove strainer and clean by back flushing with a
clean degreaser. Allow to air dry before reinstalling.
Reinstall strainer.
Reinstall hydraulic line and fitting to strainer.
Reinstall and tighten drain plug.
Fill reservoir with approximately 7.5 qt. of Dexron IIl
ATF. Refer to Checking Hydraulic Fluid.
-+74)
9(4%70-' 564%-1)4
" ! -+
Check adjustment every 200 hours.
Loosen jam nut on link rod ball joint.
Rotate rod until gap between brake pedal and up
stop is .020-.080".
-+74)
-1/ 42( &%00 .2-16
Tighten jam nut after adjustment has been
attained.
-+74)
4%/) 3)(%0
076', 3)(%0
076', 3)(%0 73 5623