SDS

ManualsBrandsSwisher ManualsGas Riding Lawn MowersZ2460CPKA-CA

SAFETY DATA SHEET

LEAD-ACID BATTERY FILLED WITH ACID

1. IDENTIFICATION

PRODUCT NAME: Lead/acid Battery, Wet, filled with acid / Wet cell battery / Flooded battery

Distributor: Interstate Batteries, Inc. EMERGENCY PHONE: 24 hours – (800) 255-3924; Chemtel

12770 Merit Drive INFORMATION PHONE: (800) 541-8419, Ext. 6672 or 6663

Dallas, Texas 75251

Recommended Use: Electric storage battery for starting a piston engine

SDS NUMBER: 1 REVISION NUMBER: 7

DATE OF PREPARATION/REVISION: 12/11/2017

2. HAZARDS IDENTIFICATON

NOTE: Under normal conditions of battery use, internal components will not present a health hazard. The following

information is provided for battery electrolyte (acid) and lead for exposure that may occur during container breakage or under

extreme heat conditions such as fire or rupture/explosion.

A. HAZARD CLASSIFICATION

PHYSICAL HAZARDS: Not Classified.

HEALTH HAZARDS

Acute toxicity Category 4 (inhalation)

Skin corrosion/irritation Category 1

Serious eye damage/eye irritation Category 1

Carcinogenicity Category 1B

Germ cell mutagenicity Category 2

Specific target organ toxicity – single exposure Category 1

Specific target organ toxicity – repeated exposure Category 1

ENVIRONMENTAL HAZARDS: Not Classified.

B. GHS LABEL ELEMENTS, INCLUDING PRECAUTIONARY STATEMENTS AND PICTOGRAMS :

SIGNAL WORD : DANGER.

HAZARD STATEMENTS

H332 Harmful if inhaled.

H314 Causes severe skin burns and eye damage.

Summary of content (9 pages)

PAGE 1
SAFETY DATA SHEET LEAD-ACID BATTERY FILLED WITH ACID 1. IDENTIFICATION PRODUCT NAME: Lead/acid Battery, Wet, filled with acid / Wet cell battery / Flooded battery Distributor: Interstate Batteries, Inc. EMERGENCY PHONE: 24 hours – (800) 255-3924; Chemtel 12770 Merit Drive INFORMATION PHONE: (800) 541-8419, Ext. 6672 or 6663 Dallas, Texas 75251 Recommended Use: Electric storage battery for starting a piston engine SDS NUMBER: 1 REVISION NUMBER: 7 DATE OF PREPARATION/REVISION: 12/11/2017 2.
PAGE 2
H318 Causes serious eye damage. H350 May cause cancer (inhalation). H341 Suspected of causing genetic defects. H370 Specific target organ toxicity – single exposure; Respiratory tract irritation H372 Causes damage to organs (Hematopoietic system, kidney, central nervous system, peripheral nervous system, cardiovascular system, immune system, respiratory). PRECAUTIONARY STATEMENTS: [Prevention] P261 Avoid breathing dust/fume/gas/mist/vapors/spray. P271 Use only outdoors or in a well-ventilated area.
PAGE 3
C. OTHER HAZARDS WHICH DO NOT RESULT IN CLASSIFICATION (e.g. Dust explosion hazards) NFPA/HMIS Rating for pure, undiluted sulfuric acid : Do not breathe dust/fume/gas/mist/vapors/spray. Health=3, Flammability=0, Instability=1 (0 = Insignificant 1 = Slight 2 = Moderate 3 = High 4 = Extreme) 3. COMPOSITION / INFORMATION ON INGREDIENTS Material % by Wt.
PAGE 4
an open container of food or liquid is. Also, particles of acid on a person’s hands can contaminate food, drink, or cigarettes that are handled, so hands should be thoroughly washed after touching a battery. Lead may be toxic to blood, kidneys, and the central nervous system (CNS). Repeated or prolonged exposure to lead can produce target organs damage. F.
PAGE 5
Protect from physical damage. B. CONDITIONS FOR SAFE STORAGE (INCLUDING ANY INCOMPATIBILITIES) Avoid contact with eyes. Store in a cool, dry, ventilated area away from sources of heat, moisture, incompatibilities, and direct sunlight. Have emergency equipment (for fires, spills, leaks, etc.) readily available. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION A. OCCUPATIONAL EXPOSURE LIMIT(S), BIOLOGICAL EXPOSURE STANDARD OSHA-PEL 0.05 mg/m3 (Lead), 1 mg/m3 (Sulfuric acid), 0.5 mg/m3 (Antimony) ACGIH-TLV TWA 0.
PAGE 6
G. FLASH POINT: Non-flammable. H. EVAPORATION RATE: Not applicable. I. FLAMMABILITY (SOLID, GAS): Not applicable. J. UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS : Non-flammable. K. VAPOR PRESSURE: 1.33 hPa (973℃) L. SOLUBILITY: Insoluble in water. M. VAPOR DENSITY: Not applicable N. SPECIFIC GRAVITY: 11.34 g/cm3 O. PARTITION COEFFICIENT OF n-OCTANOL/WATER: Not applicable. P. AUTO-IGNITION TEMPERATURE: Not applicable. Q. DECOMPOSITION TEMPERATURE: Not applicable. R. VISCOSITY: Not applicable S.
PAGE 7
Carcinogenicity: cat 1B ACGIH Group A2, IARC Group 1 (Mist containing sulfuric acid) * Note: Sulfuric acid mist is not expected under normal use of the product. ACGIH Group A3, IARC Group 2B (Lead), IARC Group 3 (Polypropylene) Germ cell mutagenicity: cat 2 Reproductive toxicity: Not available. STOST-single exposure: cat 1 Respiratory. STOST-repeated exposure: cat 1 Hematopoietic system, kidney, central nervous system, peripheral nervous system, cardiovascular system, immune system, respiratory.
PAGE 8
§173.159 Batteries, wet.
PAGE 9
airborne forms of any particle size) OSHA Specifically Regulated Substances (29 CFR 1910.1001-.1052) Not applicable. CANADA REGULATORY INFORMATION WHMIS Ingredient Disclosure List: Regulated NOTE: The regulatory information given above only indicates the principal regulations specifically applicable to the product described in the Safety Data Sheet. The user's attention is drawn to the possible existence of additional provisions which complete these regulations.