INSTRUCTIONAL BOOK CARE & USE/INSTALLATION Propane/NG,, Model SIZ-32 Propane / NG Model SIZ-26 Propane/NG and Model SIZSB-2 Propane/NG DANGER - IF YOU SMELL GAS: WARNING I - Shut off the gas supply to the appliance at its I – Do not store or use gasoline or other source. flammable liquids or vapor in the vicinity of this 2 - Extinguish any open flames. or any other appliance 3 - Open grill hood to release any accumulation 2 – an LP cylinder not connected for use shall of gas vapor.
Safety and Installation Instructions When using your Summer Sizzler grill, please read and follow these basic precautions: GRILL INSTALLATION This gas grill must be installed in accordance with all local codes. If installation is planned in an area with no local codes, the gas grill must be installed in accord with the National Fuel Gas Code ANSI Z223.1 and storage and handling of liquefied petroleum gases, ANSI/NFPA 58 or CSA B149.1 natural gas and propane installation code.
Safety and Installation Instructions on of your Barbecue Locati Locatio Most importantly, this is an outdoor appliance. Ensure your barbecue is positioned safely away from anything that can catch fire. Under no circumstance is this barbecue to be used indoors. This includes garages or any other enclosed area. Clearance from Combustibles: Ensure your barbecue remains at a distance of at least 18” from any combustible material such as wood, gyprock, paper and plants.
Maintenance Access: When your barbecue is installed, you should be able to access the gas supply line including the gas piping or hose, gas regulator, gas cylinder and any shut off valves. Partial Enclosures: Many backyards have areas that are partially closed off, such as balconies and pergolas. In some cases, it is hard to decide whether these partially enclosed areas should be classified as indoor areas, particularly in terms of permanent (non-closable) ventilation.
Keep any electrical supply cord and fuel supply hose away from any heated surfaces and dripping grease. Do not twist the gas supply hose. Before each use, visually inspect the gas supply hose for cracks, cuts or excessive wear. Replace the hose if necessary. Never test the grill for gas leaks using a lighted match or any other open flame; see leak test procedures using soap/water solutions - included in following pages of this manual.
with the unit and set to 11" water column pressure. The gas valves used in the grills are preset at the factory for Natural Gas or Liquid Propane operation. Please contact your dealer and use a licensed contractor or installer to convert your grill to a different gas type. The self-contained LP system barbeque grill is design certified to be used with a standard 20 lb, 12 1/4" diameter, 18" high cylinder with right handed connection threads and this is the maximum size LP tank to be used.
Connection Slide the grill forward to gain access to the regulator and gas connection point in the rear. Connect a suitable natural gas flex connector to the grill regulator. Check the grill controls to ensure all control valves are in the full OFF position. Turn on the main gas supply and check all connections for leaks using soapy water as Described in the leak testing procedure section.
Apply the leak-testing solution by spraying it on joints of the gas delivery system. Blowing bubbles in the soap solution indicates that a leak is present. Stop a leak by tightening the loose joint or by replacing the faulty part with a replacement part recommended by the manufacturer. Do not attempt to repair the cylinder valve if it is damaged. The cylinder must be discarded to a proper LP tank location and then replaced. Turn all control knobs back to the full OFF position.
Liquid Propane (LP) Gas Requirements LP TANK REQUIREMENTS: a collar to protect the cylinder threads on the customer supplied tank. an arrangement for gas vapor withdrawal. a safety relief device having direct communication with the vapor space of the cylinder. a method of mounting. when not in use, the tank shut off valve should be turned off. Filling and Refilling LP Gas Cylinders: WARNING All purging and refilling of LP gas cylinders must be performed by qualified personnel in the LP gas industry.
Transporting and Storing LP Gas Transport only one cylinder at a time. Ensure the cylinder is secured in an upright position with the control valve turned off and the dust cap in place. Store cylinders outdoors and out of reach of children. Do not store cylinders in a building, garage, or any other enclosed area. Leak Testing All gas piping and connections must be tested for leaks after installation or service. All leaks must be corrected immediately.
Installing the Grill in a BBQ Island You will need a second person to help you avoid damaging the grill or your barbecue island. Before installing a grill in any island or cut out, make sure that the opening is not bigger than the outside frame of the grill unit. The grill should rest on the lip of the frame. Pay careful attention to the location of the gas line. It should be routed away from sources of heat and should make as few bends as possible.
BUILDING BBQ SPECIFICATIONS ALL BBQ ISLANDS MUST BE MANUFACTURED FROM “ NON-COMBUSTIBLE NON-COMBUSTIBLE”” MATERIAL.
Installation Method for Propane Installation Method for Natural Gas Connection Method for Dual Side Burner When connecting your Side Burner to LP or NG No Regulator is required on the Side Burner.
BBQ SPECIFICATIONS NOTE: “ALWAYS ALWAYS”” have equipment measured by Contractor before building. NOTE: Check with City and Fire department for Local Building Codes.
ELECTRICAL PRECAUTIONS: Extension cords are available and may be used if care is exercised in their use. If an extension cord is used: � the marked electrical rating of the cord set or extension cord should be at least as great as the electrical rating of the appliance, and, � the cord should be arranged so that it will not touch hot surfaces or drape over the countertop or tabletop (where it can be pulled on by children or tripped over unintentionally).
GENERAL USE AND CARE: NOTE: The manufacturer cannot be held responsible for damage or injury caused by improper use of this appliance. � Be certain your appliance is properly installed and grounded by a qualified technician in accordance with applicable codes. To guarantee the electrical safety of this appliance, continuity must exist between the appliance and an effective grounding system. It is imperative that this basic safety requirement be met.
Safety and Installation Instructions UNIT INSTALLATION: Your Summer Sizzler Series Grill comes pre-assembled and requires very little setup. We do however; recommend the use of professional help during the installation of your unit as improper installation may affect your warranty. Remove the unit from the box along with all accessories and check that no damage has occurred to the unit or any parts. Burners: Check the burner tubes and remove any obstructions that may be in the ports or holes.
Lighting Instructions Caution: Never operate the grill unattended. Do not operate the rotisserie burner with the hood closed. Prior to using your grill, verify that all of the following is correct: � The burner tube is free of insects and insect nests, webs, etc. � Installation of the proper gas type and regulator settings. � The proper gas connection is complete. � Minimum clearances are maintained. � All packaging has been removed. � All parts and components are properly in place.
Lighting the Grill 1. Open the hood. 2. Keep your face as far away from the burners as possible. 3. Slowly rotate the burner knob counter-clockwise to the high position. 4. You will hear a loud click as the electronic lighter produces a spark. Listen for the sound of the gas igniting. If the burner does not light on the first try, repeat immediately. 5. If the burner does not light in 5 seconds then wait five minutes until the gas clears before attempting to light it again.
6. If the burner does not light after five seconds, turn the control knobs to the OFF position. 7. Wait five minutes until the gas clears before attempting to light it again. 8. If the burner does not light after several attempts, immediately close all gas valves and consult an authorized service technician. WARNING: “Flashback” may occur in or around the burner tubes. Flashback exhibits a characteristic “whooshing” sound.
Fats and juices that drip down can cause flare-ups. Since some flare-up does impart a distinctive and desirable flavor, taste and color to foods being grilled, they should be carefully and reasonably encouraged. Uncontrolled or excessive flare-ups, however, will damage your food. (When cooking foods with a high fat content, using indirect heat also greatly reduces flare-ups.) Fuel (Gas) Conversion Instructions for SUMMER SIZZLER Gas grills.
fragile! When unscrewing, be extremely gentle, for you could easily break the brass fitting and have to replace the valve). 8. Once the orifice is removed, replace it with the new change-out orifice, (repeat for all burners). When re-installing orifice, do not over tighten or you will strip the brass fitting. Little pressure is needed!!! 9. Replace burners and test for proper flame height. Flame should stand between ½” - 1” on LOW and 1.5” - 2” on HIGH.
Warranty Registration If you have purchased a Summer Sizzler Series Grill you must maintain your original receipt to get service on the grill. The warranty is for original owners only and cannot be transferred to new owners. You should retain your sales slip or invoice. All Natural and LP Gas grills must have a qualified installer complete the installation for the warranty to be in effect. The incorrect installation of the Summer Sizzler gas grill will void the warranty.
BBQ PARTS ITEM 1. 2. 3. 4. 5. 6 7. 8. 9 10. 11. 12. 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 PART NO.
SUMMER SIZZLER by SUMMERSET Instructional Book
Sizzler Side Burner – 2 Burner Thank you for your purchase of this great product by Summerset Outdoor Products. We know you will have many years of enjoyment using this grill and have many fun and memorable times around the barbecue. Family and fun is what this is all about and creating memories that will last a lifetime. Thank you and enjoy the barbecue. The team at Summerset Outdoor Products.
