SDS

ManualsBrandsRYOBI ManualsDrillsONE+ HP 18V Brushless Cordless 1 in. SDS-Plus Rotary Hammer Drill with 4.0 Ah Lithium-Ion HIGH PERFORMANCE Battery

Page 1 of 6

Technical Data Sheet

Ryobi Lithium-Ion Battery Pack

Battery Voltage: 18V

Battery Capacity: 4Ah / 72Wh

SECTION 1: PRODUCT AND COMPANY IDENTIFICATION

Product Name: Lithium-Ion Battery — Rechargeable Model Number: PBP004

Issue Date: October 2020

Techtronic Industries Power Equipment Company Phone Number: 1-800-525-2579

P.O. Box 1288

Anderson, SC 29622 Emergency Contact Number:

Chemtrec (United States only): 1-800-424-9300

(International): +1-703-741-5970

SECTION 2: HAZARDS IDENTIFICATION

Refer to battery cell SDS for more information.

No exposure to hazards during routine handling of product.

WARNING:

• To reduce the risk of injury, user must read operator’s manual.

• Risk of fire and burns.

• Donotopen,crush,heatabove50˚C,incinerate,orshortterminals.

• Follow manufacturer’s instructions.

• Use only with charger listed in operator’s manual.

• Remove battery from tool when storing, changing attachments, or making adjustments.

• To reduce the risk of explosion and possible injury, do not place battery near fire or heat.

• Do not crush, drop, or damage battery pack.

• Do not use a battery pack that has been dropped or received a sharp blow. A damaged battery is subject to explosion.

Properly dispose of a dropped or damaged battery immediately.

• Under extreme usage or temperature conditions, battery leakage may occur. If fluid comes in contact with your skin,

wash immediately with soap and water. If fluid gets into your eyes, flush them with clean water for at least 10 minutes,

then seek immediate medical attention. Following this rule will reduce the risk of serious personal injury.

• Battery cells and battery pack assembly will burn if incinerated.

SECTION 3: COMPOSITION/INFORMATION OF INGREDIENTS

Refer to battery cell SDS for more information.

998000413

10-9-20 (REV:01)

Summary of content (20 pages)

PAGE 1
Technical Data Sheet Ryobi Lithium-Ion Battery Pack Battery Voltage: 18V Battery Capacity: 4Ah / 72Wh SECTION 1: PRODUCT AND COMPANY IDENTIFICATION Product Name: Lithium-Ion Battery — Rechargeable Model Number: PBP004 Issue Date: October 2020 Techtronic Industries Power Equipment P.O.
PAGE 2
SECTION 4: FIRST AID MEASURES Refer to battery cell SDS for more information. No exposure to hazards during routine handling of product. WARNING: • To reduce the risk of injury, user must read operator’s manual. • Risk of fire and burns. • Do not open, crush, heat above 50˚C, incinerate, or short terminals. • Follow manufacturer’s instructions. • Use only with charger listed in operator’s manual. • Remove battery from tool when storing, changing attachments, or making adjustments.
PAGE 3
SECTION 6: ACCIDENTAL RELEASE MEASURES PERSONAL PRECAUTIONS: • Use standard industrial clothing in normal use. • If handling large containers of cells, wear steel‐-toed footwear. ENVIRONMENTAL PRECAUTIONS: No special precautions necessary. METHODS FOR CONTAINMENT: • Transport container outdoors. • Always consult and obey all international, federal, and local environmental laws.
PAGE 4
SECTION 10: STABILITY AND REACTIVITY Refer to battery cell SDS for more information. No exposure to hazards during routine handling of product. WARNING: • To reduce the risk of injury, user must read operator’s manual. • Risk of fire and burns. • Do not open, crush, heat above 50˚C, incinerate, or short terminals. • Follow manufacturer’s instructions. • Use only with charger listed in operator’s manual. • Remove battery from tool when storing, changing attachments, or making adjustments.
PAGE 5
SECTION 12: ECOLOGICAL INFORMATION ECOTOXICOLOGICAL INFORMATION: None in routine handling of product. TOXICITY: No data available PERSISTENCE AND DEGRADABILITY (BIOPERSISTENCY & BIODEGRADABILITY): None in routine handling of product. POTENTIAL OF BIOACCUMULATION: None in routine handling of product. MOBILITY IN SOIL: None in routine handling of product. OTHER ADVERSE EFFECTS: No data available DISPOSAL: Follow guidelines in Section 13.
PAGE 6
SECTION 14: TRANSPORTATION INFORMATION U.S. DOT Hazardous Material Regulations (Re: Ground Transport) Lithium-ion batteries under 101 watt hours or Lithium-ion batteries packed with equipment under 101 watt hours when packaged correctly are not subject to any regulations when traveling by ground in the continental U.S.
PAGE 7
MSDS Report Sample Description & Model Lithium-ion Cell
PAGE 8
Page 1 of 13 Material Safety Data Sheet Reference to ST/SG/AC.10/30/Rev.6 (GHS) Section 1 - Chemical Product and Company Identification Chemical product identification Sample Description: Lithium-ion Cell Recommended Uses: N/A Restrictions on use: N/A Section 2 - Hazards Identification Emergency overview: This product is an article which contains a chemical substance. Safety information is given for exposure to the article as sold.
PAGE 9
Page 2 of 13 Precautionary statement(s): Prevention: P201 Obtain special instructions before use. P202 Do not handle until all safety precautions have been read and understood. P280 Wear protective gloves, protective clothing, eye protection and face protection. P260 Do not breathe dust. P264 Wash skin and clothing thoroughly after handling. P270 Do not eat, drink or smoke when using this product. Response: P308 + P313 IF exposed or concerned: Get medical advice. P314 Get medical advice if you feel unwell.
PAGE 10
Page 3 of 13 P242 Use non-sparking tools. P243 Take action to prevent static discharges. P280 Wear protective gloves, protective clothing, eye protection and face protection. P261 Avoid breathing gas, mist, vapours and spray. P271 Use only outdoors or in a well-ventilated area. P201 Obtain special instructions before use. P202 Do not handle until all safety precautions have been read and understood. Response: P303 + P361 + P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing.
PAGE 11
Page 4 of 13 Prevention: P271 Use only outdoors or in a well-ventilated area. P260 Do not breathe dust. P264 Wash skin and clothing thoroughly after handling. P270 Do not eat, drink or smoke when using this product. P273 Avoid release to the environment. Response: P304 + P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing. P312 Call a POISON CENTER or doctor, if you feel unwell. Storage P403 + P233 Store in a well-ventilated place. Keep container tightly closed.
PAGE 12
Page 5 of 13 P501 Contents handling to approved waste treatment plants. Other hazards Physical and chemical hazards: See Section 10 Human health hazards: See Section 11 Environmental hazards: See Section 12 Section 3 - Composition/Information on Ingredients Chemical characterization: Mixture Chemical Composition CAS No.
PAGE 13
Page 6 of 13 After inhalation Remove victim to fresh area. Administer artificial respiration if breathing is difficult. Seek medical attention. After swallowing Do not induce vomiting. Get medical attention. Personal protective equipment for first-aid responders: No data available. Most important symptoms/effects, acute and delayed: No data available. Indication of immediate medical attention and special treatment needed: No data available.
PAGE 14
Page 7 of 13 Environmental precautions: Do not allow material to be released to the environment without proper governmental permits. Methods and materials for containment and cleaning up: All waste must refer to the United Nations, the national and local regulations for disposal. See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. See Section 13 for disposal information.
PAGE 15
Page 8 of 13 PEL-TWA 15mppcf 7782-42-5 TLV-TWA 2mg/m3 REL-TWA 2.5mg/m3 21324-40-3 N/A N/A N/A 96-49-1 N/A N/A N/A 616-38-6 N/A N/A N/A TLV-TWA 0.2mg/m3 REL-TWA 1mg/m3 PEL-TWA 0.1mg/m3 TLV-TWA 1mg/m3 REL-TWA 0.
PAGE 16
Page 9 of 13 Melting point/freezing point: Not available. Initial boiling point and boiling range: Not available. Flash Point: Not available. Evaporation rate: Not available. Flammability (solid, gas): Not available. Explosion Limits (vol% in air): Not available. Vapour pressure, kPa at 2o·c: Not available. Vapor density: Not available. Density/Relative density (water= 1 ): Not available. Solubility(ies): Not available. Partition coefficient: n-octanol/water: Not available.
PAGE 17
Page 10 of 13 7782-42-5 No data available. 21324-40-3 No data available. 96-49-1 LD50 Rat (oral): 10g/kg LD50 Rat (oral): 6400-12800mg/kg; 616-38-6 LC50 Rat (Inhalation: Vapours) ;::140 mg/L 7440-50-8 No data available. 7429-90-5 No data available. Skin corrosion/irritation: No data available. Serious eye damage/irritation: No data available. Respiratory or Skin sensitization: No data available. Germ Cell mutagenicity: No data available. Carcinogenicity: No data available.
PAGE 18
Page 11 of 13 Uncleaned packaging Recommendation: Disposal must be made according to official regulations. Section 14 - Transport Information UN Number IATA IMDG UN Proper shipping name IAT IMDG Transport hazard class(es) IATA IMDG Packing group IATA IMDG Packaging Sign IATA IMDG UN3480 UN3480 Lithium ion batteries LITHIUM ION BATTERIES 9 9 N/A N/A �lflh N/A Environmental hazards Marine pollutant: Special precautions for user No Not applicable.
PAGE 19
Page 12 of 13 high temperature and open flames. Lithium ion cells and batteries must be offered for transport at a state of charge (SoC) not exceeding 30% of their rated design capacity from 1 April 2016. Transport Fashion: By air, by sea. Section 15 - Regulatory Information Safety, health and environmental regulations/legislation specific for the substance or mixture GAS No.
PAGE 20
Page 13 of 13 NIOSH: (US National Institute for Occupational Safety and Health); OSHA: (US Occupational Safety and Health); T LV: (T hreshold Limit Value) TWA: (Time Weighted Average); ST EL: (Short Term Exposure Limit); PEL: (Permissible Exposure Level); REL: (Recommended Exposure Limit); PC-STEL: (Permissible concentration-time weighted average); PC-TWA: (Permissible concentration-short time exposure limit); LC50: (Lethal concentration, 50 percent kill); LD50: (Lethal dose, 50 percent kill); IARC: (Intern