Use and Care Manual

3
The instructions that you are about to read, are required by
Underwriters Laboratories to be published in your manual.
These instructions are very important for your safety and
QCA would like to encourage you to read and apply all
instructions. Thank you.
IMPORTANT SAFETY INSTRUCTIONS
When installing and using this electrical equipment,
remember to always observe safety precautions, including
the following:
1. READ AND FOLLOW ALL INSTRUCTIONS.
2. WARNING-RISK OF CHILD DROWNING.
Extreme caution must be exercised to prevent
unauthorized access by children. To avoid accidents,
ensure that children cannot use a spa or hot tub unless
they are supervised at all times.
3. DANGER – To reduce the risk of injury to persons, do
not remove suction fittings.
4. A pressure wire connector is provided on the inside and
outside of the control box within the unit to permit
connection of a minimum No. 8 AWG (8.4mm
2
) solid
copper bonding conductor between this point and any
metal equipment, metal enclosures of electrical
equipment, metal water pipe, or conduit within 5 feet
(1.5m
2
) of the unit as needed to comply with local
requirements.
5. (All permanently installed units must have a GFCI)
This appliance must have a neutrally protected ground-
fault circuit-interrupter. Before each use and with the
unit operating, push the test button. The unit should
stop operating and the reset button should appear. Push
the reset button. The unit should now operate
normally. If the interrupter does not perform in this
manner, a ground current is flowing indicating the
possibility of an electric shock. Disconnect the power
until the fault has been identified and corrected.
6. Install spa in location that will provide drainage of
water away from the spa and away from electrical
components.
7. RISK OF ELECTRIC SHOCK. Install at least 5 feet
(1.5m) from all metal surfaces. (A spa may be installed
within 5 feet of metal surfaces if each metal surface is
permanently connected by a minimum No. 8 AWG
(8.4mm
2
) solid copper conductor attached to the
wire connector on the terminal box that is provided for
this purpose.)
8. DANGER–RISK OF ELECTRICAL SHOCK. Do
not permit any electrical appliance, such as a light,
telephone, radio, or television, within 5 feet (1.5m) of
the spa or hot tub.
9. To reduce the risk of injury:
a. The water in a spa or hot tub should never exceed
104°F (40°C). Water temperatures between 100°F
(38°C) and 104°C (40°F) are considered safe for a
healthy adult. Lower water temperatures are
recommended for extended use (exceeding 10-15
minutes) and for young children.
b. Since excessive water temperatures have a high
potential for causing fetal damage during the early
months of pregnancy. Pregnant or possibly pregnant
women should limit spa or hot tub water temperatures
to 100°F (38°C).
c. Before entering a spa or hot tub, the user should
measure the water temperature with an accurate
thermometer since the tolerance of water temperature-
regulating devices may vary as much as +/-5°F (3°C).
d. The use of alcohol, drugs, or medication before or
during spa or hot tub use may lead to unconsciousness
with the possibility of drowning.
e. Persons suffering from obesity or with a medical
history of heart disease, low or high blood pressure,
circulatory system problems or diabetes should
consult a physician before using a spa or hot tub.
f. Persons using medication should consult a physician
before using a spa or hot tub since some medications
may induce drowsiness while other medications may
affect heart rate, blood pressure, and circulation.
g. The electrical supply for this product must include a
suitably rated switch or circuit breaker to open all
ungrounded supply conductors to comply with section
422-20 of the National Electrical Code, ANSI/NFPA
70-1987. The disconnecting means must be readily
accessible to the tub occupant but installed at least 5
feet (1.5m) from the tub water. For units used in
other than single-family dwellings, a clearly labeled
emergency switch shall be provided as part of the
installation. The switch shall be readily accessible to
the occupants and shall be installed at least 5 feet
(1.52 m) away, adjacent to, and within sight of the
unit.
Just a quick note,
For your own security...Prolonged immersion in water
that is warmer than normal body temperature can result
in a dangerous condition known as HYPERTHERMIA.
The causes, symptoms, and effects of hyperthermia may be
described as follows: Hyperthermia occurs when the
internal temperature of the body reaches a level several
degrees above the normal temperature of 98.6°F. The
symptoms of hyperthermia include dizziness, fainting,
drowsiness, lethargy, and an increase in the internal
temperature of the body. The effects of hyperthermia
include (1) unawareness of impending hazard, (2) failure
to perceive heat, (3) failure to recognize the need to exit
the spa, (4) physical inability to exit the spa, (5) fetal
damage in pregnant women, and (6) unconsciousness
resulting in a danger of drowning. WARNING - the use of
alcohol, drugs, or medication can greatly increase the risk
of fatal hyperthermia in hot tubs and spas, and an
increase in the internal temperature of the body. The
effects of hyperthermia include (1) unawareness of
impending hazard, (2) failure to perceive heat, (3) failure
to recognize the need to exit the spa, (4) physical inability
to exit the spa, (5) fetal damage in pregnant women, and
(6 unconsciousness resulting in a danger of drowning.
WARNING - the use of alcohol, drugs, or medication can
greatly increase the risk of fatal hyperthermia in hot tubs
and spas.) Unconsciousness resulting in a danger of
drowning. WARNING - the use of alcohol, drugs, or
medication can greatly increase the risk of fatal
hyperthermia in hot tubs and spas.
SAVE THESE INSTRUCTIONS
ETL INSTRUCTIONS