OPERATION AND PARTS MANUAL MODEL GA-6HE/GA-6HEA Portable Generators (HONDA GASOLINE ENGINE) Revision #1 (09/30/05) THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
PAGE 2 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING MULTIQUIP CORPORATE OFFICE 18910 Wilmington Ave. Carson, CA 90746 Email: mq@multiquip.com Internet: www.multiquip.com PARTS DEPARTMENT 800-427-1244 310-537-3700 MAYCO PARTS 800-306-2926 310-537-3700 SERVICE DEPARTMENT 800-421-1244 310-537-3700 TECHNICAL ASSISTANCE 800-478-1244 WARRANTY DEPARTMENT 800-421-1244, EXT. 279 310-537-3700, EXT.
TABLE OF CONTENTS Multiquip GA-6HE/GA-6HEA AC Portable Generators HONDA GX340K1EDE2 ENGINE Here's How To Get Help ............................................ 3 Table Of Contents ..................................................... 4 Parts Ordering Procedures ....................................... 5 Safety Message Alert Symbols .............................. 6-7 Rules for Safe Operation ..................................... 8-10 Operation and Safet Decals ....................................
PARTS ORDERING PROCEDURES When ordering parts, please supply the following information: ❒ ❒ ❒ ❒ ❒ ❒ ❒ Dealer account number Dealer name and address Shipping address (if different than billing address) Return fax number Applicable model number Quantity, part number and description of each part Specify preferred method of shipment: ✓ FedEx or UPS Ground ✓ FedEx or UPS Second Day or Third Day Note: Unless otherwise indicated by customer, all orders are treated as “Standard Orders”, and will ✓ FedEx or UPS Nex
GA-6HE/GA-6HEA — SAFETY MESSAGE ALERT SYMBOLS FOR YOUR SAFETY AND THE SAFETY OF OTHERS! HAZARD SYMBOLS Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others.
GA-6HE/GA-6HEA — SAFETY MESSAGE ALERT SYMBOLS CAUTION Rotating Parts Hazards NEVER operate equipment with covers, or guards removed. Keep fingers, hands, hair and clothing away from all moving parts to prevent injury. CAUTION CAUTION Equipment Damage Hazards Other important messages are provided throughout this manual to help prevent damage to your portable generator, other property, or the surrounding environment.
GA-6HE/GA-6HEA — RULES FOR SAFE OPERATION DANGER Read this manual! Failure to follow instructions in this manual may lead to serious injury or even death! This equipment is to be operated by trained and qualified personnel only! This equipment is for industrial use only. The following safety guidelines should always be used when operating the GA-6HE/GA-6HEA Portable Generators: GENERAL SAFETY ■ DO NOT operate or service this equipment before reading this entire manual.
GA-6HE/GA-6HEA — RULES FOR SAFE OPERATION ■ ALWAYS be sure the operator is familiar with proper safety precautions and operation techniques before using generator. ■ NEVER leave the generators unattended, turn off engine when unattended. ■ Unauthorized equipment modifications will void all warranties. ■ ALWAYS ensure generators are on level ground before use. ■ DO NOT place hands or fingers inside generators engine compartment when engine is running.
GA-6HE/GA-6HEA — RULES FOR SAFE OPERATION DANGER -ELECTROCUTION HAZARDS During operation of this generation, there exists the possibility of electrocution, electrical shock or burn, which can cause severe bodily harm or even DEATH! Emergencies ■ ALWAYS know the location of the nearest fire extinguisher. ■ ALWAYS know the location of the nearest first aid kit. To avoid these hazards: NEVER use damaged or worn cables when connecting equipment to the generator.
GA-6HE/GA-6HEA — OPERATION AND SAFETY DECALS Machine Safety Decals The GA-6HE/GA-6HEA portable generators are equipped with a number of safety decals (Figure 1). These decals are provided for operator safety and maintenance information. The illustration below shows these decals as they appear on the machine. Should any of these decals become unreadable, replacements can be obtained from your dealer. Figure 1. Operation and Safety Decals GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — SPECIFICATIONS (GENERATOR) Table 1. Specifications (Generators) Model Type Excitation GA-6HE/ GA-6HEA Brushless Revolving Field Type Solid State, Statically Excited System AC Generator Speed Cooling System Fuel Capacity 60 Cycle AC Power Source 3,600 RPM Self-Ventilation 5 gallons (19 liters) Continuous Output 5.0 kW Stanby Output 6.0 kW Rated Voltage 120/240V Current Max/Continuous (120V) 50/41.6 amps Current Max/Continuous (240V) 25.0/20.
GA-6HE/GA-6HEA — SPECIFICATIONS (ENGINE) Table 2. Specifications (Engine) Engine Model HONDA GX340K1EDE2 Type Air-cooled 4 stroke, Single Cylinder, OHV, Horizontal Shaft Gasoline Engine Bore X Stroke 2.90 in. X 2.30 in. (73 mm x 58 mm.) Displacement 23.70 cu-in (389 cm3) Max Output 11.0 H.P./3600 R.P.M. Fuel Lube Oil Capacity 1.16 quar ts (1.
GA-6HE/GA-6HEA — DIMENSIONS Figure 2. Dimensions PAGE 14 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — GENERAL INFORMATION WARNING Before connecting this generators to any building’s electrical system, a licensed electrician must install an isolation (transfer) switch. Serious injury or death may result without this transfer switch.
GA-6HE/GA-6HEA — LOAD APPLICATION Single Phase Load — 60 Hz Always be sure to check the nameplate on the generators and equipment to insure the wattage, amperage and frequency requirements are satisfactorily supplied by the generators for operating the equipment. Generally, the wattage listed on the nameplate of the equipment is its rated output.
GA-6HE/GA-6HEA — CONTROLS AND INDICATORS Figure 3A. Generator Components 1. 2. 3. 4. Lifting Bail Eye – Attach a rope or chain to this lifting eye when lifting of the generator is required. Never stand underneath the generator while it is being lifted. Place lifting eye in down position when not in use. AC-Voltmeter – This voltmeter indicates (with a mark) the rated 60 Hz (single-phase) output voltage. In addition the voltmeter can also be used as a diagnostic tool.
GA-6HE/GA-6HEA — CONTROLS AND INDICATORS Figure 3B. Generator Components 13. Full Power Switch – The generator is provided with a full power switch. Figures 3C and 3D show simplified wiring diagrams of the dual voltage system.
GA-6HE/GA-6HEA — CONTROLS AND INDICATORS Figure 3E. Generator Components 14. Fuel Cock Lever – Turn this lever downward to start (down)the flow of fuel into the carburetor. Turn upward to stop (up) the flow of fuel. 20. Engine Oil Drain Plug – Remove this drain plug when draining of the oil from the engine crankcase is required. Fill with recommeded type oil as listed in Table 5. 15. Spark Plug – Provides spark to the ignition system. Set spark plug gap to 0.6 - 0.7 mm (0.028 - 0.
GA-6HE/GA-6HEA — GENERATOR REFUELING DANGER Adding fuel to the tank should be done only when the engine is stopped and has had an opportunity to cool down. In the event of a fuel spill, DO NOT attempt to start the engine until the fuel residue has been completely wiped up, and the area surrounding the engine is dry. If generators is placed in a truck bed with a plastic liner, REMOVE generators from truck bed and place on ground (Figure 4) to refuel.
GA-6HE/GA-6HEA — INSTALLATION Outdoor Installation Indoor Installation Install the generator/welder in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generators are on secure level ground so that it cannot slide or shift around. Also install the generators in a manner so that the exhaust will not be discharged in the direction of nearby homes. Exhaust gases from gasoline engines are extremely poisonous.
GA-6HE/GA-6HEA — INSTALLATION Connecting the Ground The nut and ground terminal on the generators should always be used to connect the generators to a suitable ground. The ground cable should be #8 size wire minimum. At the generator, connect the terminal of the ground cable between the lock washer and the nut (Figure 5) and tighten the nut fully. Connect the other end of the ground cable to a suitable earth ground (ground rod). Figure 5. Generator Grounding PAGE 22 — GA-6HE/GA-6HEA A.C.
GA-6HE/GA-6HEA — PRE-INSPECTION General Inspection Prior to Operation Extension Cable Ground Power Tools When electric power is to be provided to various tools or loads at some distance from the generators, extension cords are normally used. Cables should be sized to allow for distance in length and amperage so that the voltage drop between the generators and point of use (load) is held to a minimum. Use the cable selection chart (Table 4) as a guide for selecting proper cable size.
GA-6HE/GA-6HEA — PRE-INSPECTION (ENGINE) CAUTION NEVER operate the generators in a confined area or enclosed area structure that does not provide ample free flow of air. Figure 8. Engine Oil Dipstick (Oil Level) ALWAYS wear approved eye and hearing protection before operating the generator. Before Starting 1. Read safety instructions at the beginning of manual. 2. Clean the generator, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3.
GA-6HE/GA-6HEA — INITIAL START-UP (ENGINE) CAUTION DO NOT attempt to operate this generator until the Safety, General Information and Inspection sections of this manual have been read and thoroughly understood. This section is intended to assist the operator with the initial start-up of the portable generator. It is extremely important that this section be read carefully before attempting to use the generator in the field. Before Starting the Engine 1.
GA-6HE/GA-6HEA — INITIAL START-UP/GENERATOR OPERATION 7. If the engine has started, slowly return the choke lever (Figure 12 ) to the “OPEN” position. If the engine has not started repeat steps 1 through 6. 2. Place the full power switch (Figure 19) in the 120V position (up). 8. Before the generators is placed into operation, run the engine for 3-5 minutes. Check for abnormal smells, fuel leaks, and noises that would associate with lose components. 9.
GA-6HE/GA-6HEA — GENERATOR OPERATION/SHUTDOWN 5. Read the voltmeter on the front panel of the generator (Figure 22) and verify that 240 VAC is present at the 240V twist-lock receptacle. Using an external voltmeter verify that 120V is present at the 120V twist-lock and GFCI duplex receptacles. Stopping the Engine 1. Place the main circuit breaker (Figure 23) in the OFF position. Figure 23. Main Circuit Breakers (Off) 2. Place the idle control switch (Figure 24) in the OFF position. Figure 24.
GA-6HE/GA-6HEA — PREPARATION FOR LONG TERM STORAGE Generator Storage For storage of the generating set for over 30 days, the following is required: ■ Drain the fuel tank completely, or add STA-BIL to the fuel. ■ Run the engine until the gasoline in the carburetor is completely consumed. ■ Completely drain the oil from the crankcase and refill with fresh oil. ■ Remove the spark plug, pour 2 or 3 cc of SAE 30 oil into the cylinder and crank slowly to distribute the oil.
GA-6HE/GA-6HEA — MAINTENANCE (ENGINE) Use Table 6 as a general maintenance guideline when servicing your engine. For more detail engine maintenance information, refer to the engine owner's manual supplied with your engine. Table 6. Engine Maintenance Schedule DESCRIPTION (3) OPERATION BEFORE CHECK X FIRST EVERY MONTH 3 MONTHS OR OR 10 HRS. 25 HRS. EVERY 6 MONTHS OR 50 HRS. EVERY YEAR OR 100 HRS. EVERY 2 YEARS OR 200 HRS.
GA-6HE/GA-6HEA — MAINTENANCE (ENGINE) Maintenance Perform the scheduled maintenance procedures as defined by Table 6 and below: DAILY ■ Thoroughly remove dirt and oil from the engine and control area. Clean or replace the air cleaner elements as necessary. Check and retighten all fasteners as necessary. Check the gearbox for oil leaks. Repair or replace as needed. WEEKLY ■ Remove the fuel filter cap and clean the inside of the fuel tank. ■ Remove or clean the filter at the bottom of the tank.
GA-6HE — MAINTENANCE (BATTERY) Battery This unit is of negative ground DO NOT connect in reverse. Always maintain battery fluid level between the specified marks. Battery life will be shortened, if the fluid level are not properly maintained. Add only distilled water when replenishment is necessary. DO NOT over fill. Check to see whether the battery cables are loose. Poor contact may result in poor starting or malfunctions. Always keep the terminals firmly tightened.
GA-6HE — WIRING DIAGRAM (GENERATOR) Figure 31. GA-6HE Generator Wiring Diagram PAGE 32 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HEA — WIRING DIAGRAM (GENERATOR) Figure 32. GA-6HEA Generator Wiring Diagram GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — TROUBLESHOOTING (ENGINE) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, please take a remedial action following the diagnosis based on the Engine Troubleshooting (Table 7) and Generator Troubleshooting (Table 8) information shown below and on the proceeding pages. If the problem cannot be remedied, please leave the unit just as it is and consult our company's business office or service plant. TABLE 7.
GA-6HE/GA-6HEA — TROUBLESHOOTING (ENGINE) TABLE 7. ENGINE TROUBLESHOOTING (CONTINUED) SYMPTOM Insufficient power output "compression" and overheats Burns to much fuel Exhaust color is continiously "WHITE" Exhaust color is continiously "BLACK" POSSIBLE PROBLEM SOLUTION Malfunction in cooling fan? Check or replace cooling fan. Air in-take filter clogged? Clean or replace air in-take filter. Over accumulation of exhaust products? Clean and check valves. Check muffler, replace if necessary.
GA-6HE/GA-6HEA — TROUBLESHOOTING (GENERATOR) TABLE 8. GENERATOR TROUBLESHOOTING SYMPTOM Low voltage POSSIBLE PROBLEM SOLUTION Engine speed too low? Raise engine speed to rated RPM. AC voltmeter not working? Replace AC voltmeter. Control box internal wiring malfunction? Check control box wiring. Defective ignition coil? Check red and green ignition wires. Replace ignition wires if necessary. Rotor winding malfunction? Check or replace rotor. Stator winding malfunction? Check or replace stator.
NOTE PAGE GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — EXPLANATION OF CODE IN REMARKS COLUMN How to read the marks and remarks used in this parts book. NOTE The contents of this catalog are subject to change without notice. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serial number range (inclusive) where a particular part is used. Model Number-Where indicated, this shows that the corresponding part is utilized only with this specific model number or model number variant.
GA-6HE/GA-6HEA — SUGGESTED SPARE PARTS GA-6HE/GA-6HEA 1 TO 3 UNITS WITH HONDA GX340K1EDE2 ENGINE 1 to 3 Units Qty. P/N Description 1 ........A9924800014 ...........CAP FUEL TANK 1 ........A9924800004 ...........FILTER FUEL 2 ........3015419604 ..............RUBBER SUSPENSION 2 ........1665419004 ..............RUBBER SUSPENSION 3 ........9807955855 ..............SPARK PLUG 2 ........28462ZV7003 ...........ROPE, RECOIL 3 ........17211899000 ............ELEMENT AIR CLEANER 1 ........16952ZB4005 ...........
GA-6HE/GA-6HEA — NAMEPLATE AND DECALS. PAGE 40 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — NAMEPLATE AND DECALS. NAME PLATE ASSY. NO. PART NO. 1 A5561000003 2 87528898620 3 1980680004 4 A5511200102 4 A5511201302 5 87533ZC0630 6 7 0800628504 8 A5551000004 9 0820610404 10 35137 11 7900636004 12 8700611804 13 8700611904 14 0800689404 15 0800689504 16 0800696604 PART NAME QTY. REMARKS DECAL; MQ MULTIQUIP 6000 1 DECAL; CHOKE ......................................................... 1......... REPLACES P/N 0600500047 DECAL; FUEL COCK ..................................................
GA-6HE/GA-6HEA — GENERATOR ASSY. GENERATOR ASSY. PAGE 42 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — GENERATOR ASSY. GENERATOR ASSY. NO. PART NO. 1 7901002403 1-1 * 0601823213 1-2 * 0601822638 1-3 * 0071706304 2 7901017004 3 0801086104 4 0040010000 5 A5135000003 6 7901315502 7 7871315022 8 7875021523 9 7871331003 10 7901316004 11 0040008000 12 0041208000 13 7871329514 14 0601851760 15 0013608020 15A 0040008000 PART NAME QTY. REMARKS ROTOR ASSY. ...................................1 .................. INCLUDES ITEMS W/ * FIELD ASSY. .....................................1 ..................
GA-6HE — CONTROL BOX ASSY. CONTROL BOX ASSY. (GA-6HE) PAGE 44 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE — CONTROL BOX ASSY. CONTROL BOX ASSY. (GA-6HE) NO. PART NO. PART NAME QTY.
GA-6HEA — CONTROL BOX ASSY. CONTROL BOX ASSY. (GA-6HEA) PAGE 46 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HEA — CONTROL BOX ASSY. CONTROL BOX ASSY. (GA-6HEA) NO. PART NO. PART NAME QTY.
GA-6HE/GA-6HEA — MUFFLER ASSY. MUFFLER ASSY. PAGE 48 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — MUFFLER ASSY. MUFFLER ASSY. NO PART NO 1 7912310003 2 18320ZC2000 3 18325ZB4000 4 18329ZB4000 5 8355ZB4630 6 90183671003 7 0017106012 8 18333ZB4800 9 957000802000 11 0017108020 12 7905469004 13 0017108025 13A 020708000 14 0017108020 15 7905469004 16 0017106020 17 0017106012 PART NAME QTY. REMARKS MUFFLER 1 PROTECTOR ......................... 1 ......... REPLACES P/N 0602302001 PROTECTOR ......................... 1 ......... REPLACES P/N 0602302002 SEAL .....................................
GA-6HE/GA-6HEA — PIPE FRAME ASSY. PIPE FRAME ASSY. PAGE 50 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — PIPE FRAME ASSY. PIPE FRAME ASSY. NO. PART NO.
GA-6HE/GA-6HEA — BATTERY ASSY. BATTERY ASSY. PAGE 52 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
GA-6HE/GA-6HEA — BATTERY ASSY. BATTERY ASSY. NO. PART NO. 32 33 7905458103 34 A5344200004 35 0037806000 36 0040006000 37 0041206000 38 A5347000104 39 A5347000004 PART NAME QTY. REMARKS BATTERY ..................................... 1 ................PURCHASE LOCALLY BATTERY BAND 1 BATTER BOLT 2 WING NUT 2 SPRING NUT 2 WASHER, FLAT 2 BATTERY CABLE 1 BATTERY CABLE 1 GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. PAGE 54 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. NO. PART NO. 1 15721ZB4000 2 17211899000 3 17212ZB4003 4 17220ZB4003 5 17222ZC2000 6 17231899000 7 17235899000 8 17236899000 9 17252899000 10 17367413690 11 9405005000 12 9405006000 PART NAME TUBE BREATHER ELEMENT, AIR CLEANER SEPARATOR, AIR CLEANER HOUSING, AIR CLEANER STAY, AIR CLEANER COVER, AIR CLEANER CLIP A, AIR CLEANER WIRE CLIP B, AIR CLEANER WIRE SEAL, AIR CLEANER FILTER, DRAIN TUBE NUT, FLANGE (5MM) NUT, FLANGE (6MM) QTY.
HONDA GX340K1EDE2 ENGINE — CAMSHAFT ASSY. CAMSHAFT ASSY. PAGE 56 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CAMSHAFT ASSY. CAMSHAFT ASSY. NO. PART NO. 1 14100ZE3020 2 14410ZE3013 3 14431ZE2000 3 14431ZE2010 4 14441ZE2000 5 14451ZE1013 6 14568ZE1000 * 7 14711ZE3000 8 14721ZE3000 9 14751ZE2003 10 14771ZE2000 11 14773ZE2000 12 14775ZE2010 13 14781ZE2000 14 14791ZE2010 15 90012ZE0010 16 90206ZE1000 PART NAME QTY. REMARKS CAMSHAFT ASSY. ................................... 1 .............
HONDA GX340K1EDE2 ENGINE — CARBURETOR ASSY. CARBURETOR ASSY. PAGE 58 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CARBURETOR ASSY. CARBURETOR ASSY. NO. PART NO.
HONDA GX340K1EDE2 ENGINE — CONTROL ASSY. CONTROL ASSY. PAGE 60 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CONTROL ASSY. CONTROL ASSY. NO. PART NO. 1 16550ZE3700 3 16555ZE3000 4 16561ZE3000 5 16562ZE3700 9 16570ZE3700 19 * 16584883300 23 90013883000 24 90015ZE5010 93500050350A 30 * 9405006000 33 PART NAME QTY. REMARKS ARM, GOVERNOR 1 ROD, GOVERNOR 1 SPRING, GOVERNOR 1 SPRING, THROTTLE RETURN 1 CONTROL ASSY. ................................................ 1 ...
HONDA GX340K1EDE2 ENGINE — CRANKCASE COVER ASSY. CRANKCASE COVER ASSY. PAGE 62 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CRANKCASE COVER ASSY. CRANKCASE COVER ASSY. NO. PART NO. PART NAME QTY. REMARKS 2 11300ZE3020 COVER ASSY., CRANKCASE (S-TYPE) ............ 1 ........ INCLUDES ITEMS W/ * 3 11381ZE3801 GASKET, CASE COVER 1 INCLUDES ITEMS W/% 4 15600ZG4003 CAP ASSY., OIL FILLER 1 5 15600735003 CAP ASSY., OIL FILLER 1 INCLUDES ITEMS W/% 6% 15625ZE1003 GASKET, OIL FILLER CAP 2 7 16510ZE3000 GOVERNOR ASSY. ............................................. 1 ........
HONDA GX340K1EDE2 ENGINE — CRANKSHAFT ASSY. CRANKSHAFT ASSY. PAGE 64 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CRANKSHAFT ASSY. CRANKSHAFT ASSY. NO. PART NO. 6 13310ZE3701 7 13351ZE3010 11 961006207000 PART NAME CRANKSHAFT (E-TYPE) WEIGHT, BALANCER BEARING, RADIAL BALL (6207) QTY. 1 1 1 REMARKS GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CYLINDER BARREL ASSY. CYLINDER BARREL ASSY. PAGE 66 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CYLINDER BARREL ASSY. CYLINDER BARREL ASSY. NO. PART NO. 1 12000ZE3817 2 15510ZE2043 3 16541ZE3010 4 31161ZE2000 5 90013883000 6 90131896650 7 90446KE1000 8 * 91201ZE3004 91203952771 9 * 10 91353671003 11 9405010000 12 9410912000 13 9425110000 14 957010601200 15 961006202000 * PART NAME QTY. REMARKS CYLINDER ASSY. (ALERT) ................................. 1 ........ INCLUDES ITEMS W/ * SWITCH ASSY.
HONDA GX340K1EDE2 ENGINE — CYLINDER HEAD ASSY. CYLINDER HEAD ASSY. PAGE 68 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — CYLINDER HEAD ASSY. CYLINDER HEAD ASSY. NO. PART NO. 1 12200ZF6W01 2 12204ZE2306 3 * 12205ZE2305 12216ZE2300 4 * 5 12251ZE3W00 6 12310ZE2020 8 12391ZE2020 10 90014ZE2000 11 90042ZE3700 12 92900080320E 13 90441ZE2010 14 9430112200 15 957011008000 16 9807955846 16 9807955855 PART NAME QTY. REMARKS CYLINDER HEAD ................................................ 1 ........ INCLUDES ITEMS W/ * GUIDE, VALVE (OS) (OPTIONAL) 1 GUIDE, EX.
HONDA GX340K1EDE2 ENGINE — FAN COVER ASSY. FAN COVER ASSY. PAGE 70 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — FAN COVER ASSY. FAN COVER ASSY. NO. PART NO. 2 19610ZE3700ZB 3 19631ZE3W00 6 81329567020 7 90013883000 8 90654SA4003 PART NAME COVER, FAN *NH1* (BLACK) SHROUD GROMMET, DRAIN HOLE BOLT, FLANGE (6X12) (CT200) CLIP, WIRE HARNESS (6MM) (WHITE) QTY. 1 1 1 6 2 REMARKS GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — FLYWHEEL ASSY. FLYWHEEL ASSY. PAGE 72 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — FLYWHEEL ASSY. FLYWHEEL ASSY. NO. PART NO. 1 19511ZE3000 6 31100ZE3712 8 90201ZE3V00 9 90741ZE2000 PART NAME FAN, COOLING FLYWHEEL, LAMP NUT, SPECIAL 16MM KEY, SPECIAL WOODRUFF (25X18) QTY. 1 1 1 1 REMARKS GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — IGNITION COIL ASSY. IGNITION COIL ASSY. PAGE 74 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — IGNITION COIL ASSY. IGNITION COIL ASSY. NO. PART NO. 1 30500ZE2023 2 30700ZE1013 3 31510ZE1811 4 31510ZE3003 6 31511ZE3000 7 31512ZE2000 10 36101ZE3800 11 36103ZE1000 12 90012888000 13 90013883000 15 90015883000 PART NAME COIL ASSY., IGNITION CAP ASSY., NOISE SUPPRESSOR COIL ASSY., LAMP (12V/25W) COIL ASSY., LAMP (12V/25W) CLAMP, WIRE GROMMET, WIRE WIRE, STOP SWITCH (470MM) HOLDER, STOP SWITCH WIRE BOLT, FLANGE (6X40) BOLT, FLANGE (6X12) (CT200) BOOT, FLANGE (6X28) QTY.
HONDA GX340K1EDE2 ENGINE — PISTON ASSY. PISTON ASSY. PAGE 76 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — PISTON ASSY. PISTON ASSY. NO. PART NO. 1 13010ZE3003 1 13011ZE3003 1 13012ZE3003 1 13013ZE3003 2 13101ZE3W00 3 13111ZF6000 4 13200ZE3010 5 90001ZE8000 * 90601ZE3000 6 PART NAME QTY. REMARKS RING SET, PISTON (STD) 1 RING SET, PISTON (OS 0.25) (OPTIONAL) 1 RING SET, PISTON (OS O.50) (OPTIONAL) 1 RING SET, PISTON (0.75) (OPTIONAL) 1 PISTON (STD) 1 PIN, PISTON 1 ROD ASSY., CONNECTING (STD) ..................... 1 ........
HONDA GX340K1EDE2 ENGINE — RECOIL STARTER ASSY. RECOIL STARTER ASSY. PAGE 78 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — RECOIL STARTER ASSY. RECOIL STARTER ASSY. NO. PART NO. 1 28400ZE3W01ZB 2 28410ZE3W01ZB * 3 * 28421ZE3W01 4 * 28422ZE2W01 5 28441ZE2W01 * 6 * 28442ZE2W01 7 28443ZE2W01 * 8 * 28444ZE2W01 9 * 28445ZE2W01 10 28461ZE2W02 * 11 * 28462ZV7003 13 90004ZE2W01 * 90008ZE2003 14 PART NAME QTY. REMARKS STARTER ASSY., RECOIL *NH1* (BLACK) ........ 1 ........
HONDA GX340K1EDE2 ENGINE — STARTER MOTOR ASSY. STARTER MOTOR ASSY. PAGE 80 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — STARTER MOTOR ASSY. STARTER MOTOR ASSY. NO. PART NO. 1 31204ZA0003 * 31206ZE3003 2 * 3 31207ZE3003 * 4 31210ZE3013 5 31211ZE2003 * 31212ZE3003 6 * 7 31213ZE2003 * 31215ZE2003 8 * 9 31218ZE3003 * 31219ZE2003 10 * 11 % 31222ZE3791 * 31231ZE2003 12 * 14 31232ZE3003 * 15 31233ZE2003 * 90110ZE2003 16 # * 18 91601ZE2003 * 90007ZE2003 19 * 20 938920503208 * 9407006080 21 * 22 957010803508 PART NAME QTY. REMARKS CONTACTOR ASSY. 1 ARMATURE 1 CLUTCH, OVERRUNNING ......................1 ...
HONDA GX340K1EDE2 ENGINE — LABELS ASSY. LABELS ASSY. PAGE 82 — GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
HONDA GX340K1EDE2 ENGINE — LABELS ASSY. LABELS ASSY. NO. PART NO. 1 87521ZE3W01 4 87528898620 6 87533ZC0630 10 87594ZB4A00 PART NAME EMBLEM MARK, CHOKE MARK, AIR CLEANER MARK, OIL CAUTION QTY. 1 1 1 1 REMARKS GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
TERMS AND CONDITIONS OF SALE — PARTS Effective: October 1, 2002 PAYMENT TERMS 5. Parts must be in new and resalable condition, in the original Multiquip package (if any), and with Multiquip part numbers clearly marked. 6. The following items are not returnable: Terms of payment for parts are net 10 days. FREIGHT POLICY All parts orders will be shipped collect or prepaid with the charges added to the invoice. All shipments are F.O.B. point of origin.
NOTE PAGE GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV.
OPERATION AND PARTS MANUAL HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING MULTIQUIP CORPORATE OFFICE 18910 Wilmington Ave. Carson, CA 90746 Email: mq@multiquip.com Internet: www.multiquip.com PARTS DEPARTMENT 800-427-1244 310-537-3700 MAYCO PARTS 800-306-2926 310-537-3700 SERVICE DEPARTMENT 800-421-1244 310-537-3700 TECHNICAL ASSISTANCE 800-478-1244 WARRANTY DEPARTMENT 800-421-1244, EXT. 279 310-537-3700, EXT.
