Monocrystalline Solar Module LGXXXS2C(W)-G4
Table of Contents CONTENTS 1 . Safety 3 2. Before & After Installation 4 3. Electrical Installation 5 4. Mechanical Installation 6 5. Product Specifications 8 6 . 9 Disclaimer of Liability / Disposal 7. Transporting and Storage 9 8. Appendix 10 Revisions Table Date Version 2016.01.06 1.
Safety The instructions related to safety and use indicated in the this installation manual are intended for the prevention of unexpected danger, damage, or failure. Non-compliance with the instructions may cause product damage, product failure, and/or serious bodily injury or death. ① Do not contact electrically active parts of the panel, such as terminals, without appropriate safety gear. Contact may result in lethal spark or electric shock. ② Do not use or install if the module is broken or torn.
Before & After Installation Before Installation Please carefully read this manual before installation. • Contact with electrically active parts of the panels, such as terminals, may result in burns, sparks and lethal shock whether the panel is connected or disconnected. • Panels produce voltage even when not connected to an electrical circuit or load. • Solar module installation and maintenance must be performed by qualified and authorized installer.
Electrical Installation Electrical Connections • Shock hazard may occur near the solar modules electrical connections. • Modules may be connected in series and/or parallel to achieve the desired electrical output as long as it is within the guidelines on the product specification sheet. • Please use only the same type of modules in a combined source circuit. • Do not disconnect the module under when it is operating. Shock hazard may occur near the solar modules connection means.
Electrical Installation • One M4 stainless steel bolt, one nut, one spring washer, two flat washers, one cup washer, one star washer and 12 AWG Cu wires are recommended per mounting hole. • Where common grounding hardware (nut, bolts, washers) is used to attach a listed grounding device, the attachment must be made in conformance with the grounding device manufacturer’s instructions. • There is an earth hole on the edge of the module frame.
Mechanical Installation • The module is considered to be in compliance with UL1703 only when the module in mounted in the manner specified by the mounting instructions below. • The solar module may be mounted by using the following methods: (*Torque:8~12Nm ) • LG modules (Fire performance : Type 2) shall be mounted with racking and mounting products certified and listed for system fire class rating in accordance with UL1703 edition 2014 and UL2703 edition 2014.
Product Specifications - Electrical and Mechanical Properties (Rated electrical characteristics are within 10 percent) Standard Test Condition(STC) : Irradiation 1,000W/m2, Cell temp. 25℃, 1.5AM Note : Length Width Height V mm mm mm kg 36.2 8.30 1000 *MC4 1960 1000 46 20.3 LG305S2C(W)-G4 Yes 305 3% 45.0 9.09 36.4 8.39 1000 MC4 1960 1000 46 20.3 LG310S2C(W)-G4 Yes 310 3% 45.2 9.15 36.6 8.48 1000 MC4 1960 1000 46 20.3 LG315S2C(W)-G4 Yes 315 3% 45.4 9.22 36.
Disclaimer of Liability / Disposal Disclaimer of Liability •By beginning the installation process the installer represents the he/she has read and completely understands this Installation Manual. He/She further represents if he/she had any questions regarding this installation manual he/she would have contacted LG with any questions or concerns.
Appendix_Mechanical Installation Fig.1 Mounting Type ① : 270mm(10.6 in) ② : 370mm (14.6 in) Fig.2 Clamping Type Front : 4300Pa(90psf) Rear : 4300Pa(90psf) A : 250mm(9.8 in) B : 400mm(15.7 in) Fig.3 Clamping Type Front : 4300Pa(90psf) Rear : 4300Pa(90psf) Fig.4 Clamping Type A B A B B A A : 250mm(9.8 in) B : 400mm(15.7 in) A : 120mm (4.7 in) Front : 1800Pa(37.5psf) Rear : 1800Pa(37.5psf) B : 250mm (9.
LG Electronics U.S.A Inc. 1000 Sylvan Ave, Englewood Cliffs, NJ 07632 Contact : lg.solar@lge.com http://www.lgsolarusa.com This document is subject to change without notice. LG, LG logo and Life's Good are trademarks of LG Electronics, Inc. worldwide. Trademarks and intellectual properties of LG Electronics, Inc. are protected by international copyright laws.
