MICROWAVE INSTALLATION MANUAL 30 Inch Microwave Drawer Model: KM-MD30-SS For any service-related Issues, please contact us: Phone Number: 718-576-6342 Email address: support@koolmore.
PRECAUTIONS TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY (a) Do not attempt to operate this oven with the door open since open door operation can result in harmful exposure to microwave energy. It is important not to defeat or tamper with the safety interlocks. (b) Do not place any object between the oven front face and the door or allows soil or cleaner residue to accumulate on sealing surfaces. (c) Do not operate the oven if it is damaged.
IMPORTANT SAFETY INSTRUCTIONS When using electrical appliances basic safety precautions should be followed, including the following: WARNING - To reduce the risk of burns, electric shock, fire, injury to persons or exposure to excessive microwave energy: 1. Read all instructions before using the appliance. 2. Read and follow the specific: " PRECAUTIONS TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY" found on page 2. 3. This appliance must be grounded. Connect only to properly grounded outlet.
THIS COULD RESULT IN VERY HOT LIQUID SUDDENLY BOILING OVER WHEN THE CONTAINER IS DISTURBED OR A UTENSIL IS INSERTED INTO THE LIQUID. To reduce the risk of injury to persons: 1) Do not overheat the liquid. 2) Stir the liquid both before and halfway through heating it. 3) Do not use straight-sided containers with narrow necks. 4) After heating, allow the container to stand in the microwave oven for a short time before removing the container.
1. A short power-supply cord is provided to reduce the risks resulting from becoming entangled in or tripping over a longer cord. 2. Longer cord sets or extension cords are available and may be used if care is exercised in their use. 3. If a long cord or extension cord is used: 1) The marked electrical rating of the cord set or extension cord should be at least as great as the electrical rating of the appliance. 2) The extension cord must be a grounding-type 3-wire cord.
UTENSILS CAUTION - Personal Injury Hazard Tightly-closed utensils could explode. Closed containers should be opened and plastic pouches should be pierced before cooking. See the instructions on "Materials you can use in microwave oven or to be avoided in microwave oven." There may be certain non-metallic utensils that are not safe to use for microwaving. If in doubt, you can test the utensil in question following the procedure below. Utensil Test: 1.
Materials you can use in microwave oven Utensils Remarks Plastic Microwave-safe only. Follow the manufacturer* instructions. Should be labeled "Microwave Safe". Some plastic containers soften, as the food inside gets hot. "Boiling bags" and tightly closed plastic bags should be slit, pierced or vented as directed by package. Microwave-safe only. Use to cover food during cooking to retain moisture. Do not allow plastic wrap to touch food. Microwave-safe only (meat and candy thermometers).
SETTING UP YOUR OVEN Names of Oven Parts and Accessories Remove the oven and all materials from the carton and oven cavity. Your oven comes with the following accessories: A B C D E F K J I H A) Control Patch B) Control Box C) Right Mounting Plate D) Cavity E) Handle F) Windows G) Door Frame H) Automatic putter I) Drawer J) Hinge Joint Board K) Left Mounting Plate G Defrosting Rack( Only be used in defrosting function and do not use for cooking.
CLEARANCES AND DIMENSIONS · Dimensions that are shown in Figure 1 must be used. Given dimensions provide minimum clearance. Locate electrical outlet in the shaded area in the upper left -hand corner of the cutout. See Figure 3 · Contact surface must be solid and level. Pay special attention to the floor on which the Microwave Drawer will sit. The floor of the opening should be constructed of plywood strong enough to support the weight of the oven (about 100 pounds).
6 Figure 2 Figures 1 and 2 contain many Microwave Drawer measurements for reference when planning the drawer's location .This Microwave Drawer can be installed below any electric or gas wall oven. *Can also be installed using an electrical outlet in an adjacent cabinet within the area where tire provided electrical cord can reach. 1/2 Power cord access hole in cabinet should be a minimum l " diameter hole and debarred of all sharp edges.
ANTI-TIP BLOCK ELECTRICAL OUTLET S u g g e s t e d e l e c t r ic a l o u t l e t l o c a t io n A n t i T ip blo c k 5'' (6'') 1 3 2' 4'' Figure 4 Figure 3 NORMAL INSTALLATION STEPS ANTI-TIP BLOCK INSTALLATION INSTRUCTIONS To reduce the risk of tipping of the drawer, the Anti-Tip block must be properly 13/16- installed located 14 inches above the floor on which the Microwave Drawer will sit. The 6-inch Anti-Tip block must be provided by the installer. See Figures 1 and 3.
DRAWER INSTALLATION Figure 5 1. Place the drawer adjacent to the wall or cabinet opening.Plug the power supply cord into the electrical outlet. 2. Carefully guide the drawer into the prepared opening. Avoid pinching the cord between the oven and the wall. 3. Slide the drawer all the way until the mounting flange is flush with the face of the cabinet. See Figure 5. 4. Open the drawer. Using the 4 holes on the drawer as a template , pre drill the cabinet 4 S c r e ws using a 1/16" bit. See Figure 5. 5.
OPERATION Control Panel and Features (1) (2) (3) (4) (8) (9) (10) (5) (6) (3) (7) (8) (11) (12) 1 ) Open 7 ) Defrost Time 2 ) Setup 8 ) Number Keys 3 ) Auto Menu 9 ) Time Cook 4 ) Defrost Weight 10 ) Start/+30sec.
OPERATION 1. Clock Setting (1) Press "TIMER/CLOCK" button twice. “12:00” will flash. (2) Press number keys to set the clock,it should be within 1:00~12:59. (3) Press "START+30SEC." or "TIMER/CLOCK" to finish the setting. Note: In the process of clock setting, if the "STOP/CANCEL" button is pressed or if there is no operation within 1 minute, the oven will go back to former setting automatically. 2. Kitchen Timer (1) Press "TIMER/CLOCK" button once. “00:00” will display.
4. Add 30Sec (1) In waiting state, instant cooking at 100% power level with 30 seconds' cooking time can be started by pressing "START/+30SEC". Each press on the same button will increase cooking time by 30 seconds. (2) During microwave and defrost by time, "START/+30SEC." can be pressed to increase cooking time. Each press will increase 30 seconds. 5. Weight Defrost Function (1) Press "DEFROST WEIGHT" button. Screen displays the defrost icon. And "0.0 lbs" will light.
8. Sensor Reheat (1) In waiting state, press "Sensor Reheat" once,"Sr-1" will display. (2) Press "Sensor Reheat" repeatedly or press "1-4" to choose the menu. (3) Press "START+30SEC." to start cooking. PASTA Sr-1 PIZZA Sr-2 PLATE Sr-3 SOUP Sr-4 9. Sensor Cook (1) In waiting state, press "Sensor Cook" once,"Sc-1" will display. (2) Press "Sensor Cook" repeatedly or press "1-7" to choose the menu. (3) Press "START+30SEC." to start cooking.
11.MELT (1) In waiting state, press "MELT" once,"1 buTT" will display. (2) Press "MELT" repeatedly to choose the menu. (3) Press "1"or "2" to choose the correspond weight. (4) Press "START+30SEC." to start cooking. Menu Weight Display Choc Choc CHEE CHEE 12. SOFTEN (1) In waiting state, press "SOFTEN" once,"1 buTT" will display. (2) Press "SOFTEN" repeatedly to choose the menu. (3) Press "1"or "2" to choose the correspond weight. (4) Press "START+30SEC." to start cooking.
13.Multiple Cook (1) In waiting state, press "DEFROST WEIGHT" once,"0.0 lbs" will display. (2) Press numeber buttons to input the weight to be defrosted. The input weight should be between 0.1-6.0 lbs. (3) Press "TIME COOK" button once. “00:00” will display. (4) Press number keys to set the cook time,it should be within 00:01-99:99. (5) Press "POWER LEVEL" once,and then to confirm and then press "POWER LEVEL" repeatedly or press number key to set the power level. (6) Press "START+30SEC." to start cooking.
16. ECO MODE To enter eco mode when the oven door is closed,in waiting state, if there is not any operations in 1 minute. To cancel eco mode In eco mode, open the door or press any key to cancel it. 17. INQUIRING FUNCTION (1) In cooking state, press "TIMER/CLOCK" button to check the clock. The current time will display for 3 seconds at most.
MAINTENANCE Troubleshooting Check your problem by using the chart below and try the solutions for each problem. If the microwave oven still does not work properly, contact the nearest authorized service center. TROUBLE POSSIBLE CAUSE Oven will not start a. Electrical cord for oven is not plugged in. b. Door is open. c. Wrong operation is set. a. Plug into the outlet. b. Close the door and try again. c. Check instructions. Arcing or sparking a. Materials to be avoided in microwave oven were used. b.
WARRANTY LIMITED WARRANTY Koolmore Supply, Inc. extends a limited warranty to the original purchaser, guaranteeing that this Koolmore product is free from manufacturing defects in material or workmanship for one year from the date of purchase. Should you discover any such defect within the warranty period, Koolmore Supply, Inc.