SEARS OWNER'S MANUAL MODEL NO. 583.35600 SERIAL NO. {owner write in No.) CAUTION: Read Rules for Safe Operation and Instructions Carefully SAVE THIS MANUAL FOR FUTURE REFERENCE 30,000 BTU PORTABLE HEATER Operation and Maintenance Instructions with Parts List Sears, Roebuck and Co.
CONTENTS INTRODUCTION... ., Ce 2 SAFETY RULES ae 2 WARRANTY Lo... 3 ASSEMBLY... ces 2 SAFETY COMPLIANCE 3 HOW TO USE YOUR HEATER 3 Electrical Information 3 Fuel Specifications . . 3 Ventilation Requirements 4 Operation . 4 To Start Heater 4 Using an Optical Thermostat Control... .. 4 Using the Safety Control Reset Button Stop Hester 5 Storage . LL... 5 TAKING CARE OF YOUR HEATER 5 Exterior 5 Air and Lint Filters 8 Fuel Tank § Fuel Filter... 8 Upper Shell Removal . 7 Electrical . 7 SPARK PIG Lo eee 7 Motor..
WARRANTY Far one year farm the date of purchase, Sears will repair any defect in material or workmanship in this portable heater at no charge. If the portable heater is used for commercial or rental purposes, this warranty applies for only thirty days from the date of purchase. Warranty service is available by simply returning the heater to the nearest Sears Service Center, This warranty gives you 0 the specific legal rights, and you may also have other rights which vary from state to state.
VENTILATION REQUIREMENTS a Only use heater in well ventilated areas. a Never use heater in living or sleeping areas. £ Never use heater in areas having flammable vapor or heavy dust in air. A Never use heater in an area when gasoline, paint thinner, or other flammable, vapor producing products are present. Winter Workshop Construction Sites When using this heater, at least three (3) square feet of fresh air, for each 100,000 BTU's is required. It is best to have cross-ventilation in the ares if possible.
Using The Safety Control Reset Button & Never handle, move, or attempt to service heater while it js plugged in, operating or hot. 1. 11 the heater does not start, or stops when it should not, wait 5-minutes for the safety control to cool. 2. Press the reset button, located at the rear of the heater, in. 3. If the heater does not start seconds, the reset button will pop out and the safety control will cut off all power to the heater. 4.
AIR AND LINT FILTERS 1. The intake air filter should be checked attn and cleaned whenever a dust film is seen on its outside surface. 2. Simply puff the filter out of the filter end cover, wash it in a mild detergent and water, then dry. Do not oil this filter. 3. Push the filter back into the end cover, Adjust the filter so there is no space showing between the filter and end cover. Intake Air Filter End Cover 4.
UPPER SHELL REMOVAL NOTE: Upper shell removal is necessary when access to internal parts of the heater is necessary 1. Remove the six (6) screws from the upper shell flanges which run along each side of the heater. . Grip the upper shell flange along one side of the heater, pull away from the heater to disengage it from the lower shell flange, and lift up. Disengage the opposite-side flanges and lift off the upper shell. wo La .
CLEANING THE FAN 1. Remove the upper shell, as described in this manual, and lift off the top fan shroud. 2. Wash the mounted fan with a damp cloth then dry carefully so as gotta bend the blades. If fan is very dirty, loosen the setscrew and slipstream olf of the motor shaft, Wash the fan in detergent and water, and then dry the fan carefully so as not to bend the blades. 3. Slip the fan onto the motor shaft. Fan hub should be flush with end of the motor shaft.
TROUBLESHOOTING YOUR HEATER TROUBLE POSSIBLE CAUSE POSSIBLE REMEDY PAGE Electrical Troubles Heater is plugged in but 1. Na power or low voltage at heater. 1a. Press reset button on safely control, 5 alarm dogs not start; 1b. Be sure outlet is delivering adequate voltage. 3 thermostat {if used} is set to te. Check condition of heater and extension 8 call for heat but motor does cord. Repair ar replace. not start, 1d. Be sure extension cord complies with a requirements as stated in this manual, 2.
TROUBLESHOOTING YOUR HEATER TROUBLE POSSIBLE CAUSE POSSIBLE REMEDY PAGE Heater burns, but puffs of 2. Fuel filter loose, dirty, or 3a. Remove and wash fuel filter in clean ‘uel, 6 smoke oan be seen; heater connection loose. 3b. Tighten connection between fuel line and a will not burn steady; heater burner. burns with odor; heater Sc. Replace fuel fine if necessary. smokes continuously 4. Dirty nozzle. 4. Blow compressed air through nozzle from outlet and.
REPAIR PARTS KEY z o © OUT BL 1 ** Available at your local hardware store. SEARS PORTABLE HEATER MODEL 583.
REPAIR PARTS SEARS ODE snottiness OWNER’S MANUAL PARTS AVAILABLE-NOT SHOWN 07942801 Trade name Decal 097008-01 Owner's Manual SERVICE OPTIONAL ACCESSORIES 583.408960 Pressure Gauge 583.401050 Wheel and Handle Kit MODEL NO. 583.356001 SEARS PORTABLE HEATER Should a need for repair parts or service occur, contact a Sears Service HOW TO ORDER Center. Be sure to provide all pertinent facts when you call or visit.