Installation Guide
INSTALLATION INSTRUCTIONS
for Vinyl Patio Doors with Integral Nailing Fin (JII006)
5
Premium Doors Only
C'BTUFOUISPVHI
nailing n holes
XJUIYUSVTT
head screws. At
the head, screws
should be driven
GSPNUIF
DPSOFSTBOE
apart. For step-
down landings,
secure the sill in
the same manner
as the head. Fasten
the side jambs at
8" intervals.
SECURE PATIO DOOR
Note! Fastener heads
must be ush. Do
not dent nailing n.
Always use pre-
punched holes or pre-
drill with a 3/16" bit.
Builders Doors Only
B'BTUFOQBUJPEPPS
through nailing n
IPMFTGSPNUIF
corners and 12"
apart all the way
around the patio
door.
SHIM THE JAMBS
Note! Secure all shims with sealant.
'SPNUIFJOUFSJPS
shim the operating
panel side jamb 6"
from the corners
and at the strike
plate. Align shims
so that strike plate
screws (installed
later) will each
penetrate a shim.
6. Shim the stationary
panel side jamb 6"
from the corners
and at center.
4IJNUIFIFBE
jamb 6" from the corners of each panel.
8. Inspect the patio door for square, level, and plumb. Test for proper
operation (remove and reinstall if necessary).
Warning! To avoid injury, use at least two people to install.
1. For continuous
slab landings only,
remove nailing n
at sill.
"QQMZB
continuous bead of
sealant across the
sill pan back dam.
5JMUQBUJPEPPSJOUP
the rough opening.
Make sure the
back of the door
makes solid contact
with the sealant.
Adequately support
the door until fully
installed.
'BTUFOQBUJPEPPS
XJUIBHBMWBOJ[FE
roong nail between
BOEGSPNPOF
lower corner.
5
6
INSTALL PATIO DOOR
FLASH PATIO DOOR
Sealant
Strike
plate
6"
6"
Interior
12"
12"
Builders Patio Door
Premium Patio Door
8"
PREPARE FLASHING
$VUQJFDFTPG+&-%8&/TFMGBEIFTJWFýBTIJOHUPMFOHUI
as follows:
t0OFIFBEFSQJFDFMPOHFSUIBOUIFIFBEFS
t5XPTJEFQJFDFTGPSDPOUJOVPVTTMBCMBOEJOHTMPOHFSUIBOUIF
TJEFTPSGPSTUFQEPXOMBOEJOHTUIFIFJHIUPGUIFTUFQ
t'PSTUFQEPXOMBOEJOHTPOMZPOFTJMMQJFDFMPOHFSUIBOUIFTJMM
and 1" narrower than the height of the step
SPRAY ADHESIVE/PRIMER
2. Apply spray adhesive
QFSNBOVGBDUVSFST
instructions
(protect door from
overspray) to nailing
n, sheathing,
and building wrap
around the patio
door as shown.
S
p
r
a
y
A
d
h
e
s
i
v
e
6"