Installation Guide

INSTALLATION INSTRUCTIONS
for Vinyl Patio Doors with Integral Nailing Fin (JII006)
3
6. For continuous
slab, cut across the
folding line.
'PMEUIFUISFFCBDL
sides up to make a
TJEFECPYBOE
for step-down
landings, fold the
front ap down.
t7FSJGZUIFXJEUIBOE
height of the patio
door are each 1/2"-
TNBMMFSUIBO
the rough opening
width/height.
Mulled units should
CFTNBMMFS
t7FSJGZUIFSPVHI
opening is square.
The (A) and (B)
measurements
should be the same.
Maximum allowable
deviation from
TRVBSFJT
2
INSPECT ROUGH OPENING
A
B
D
C
E
Verify Square, Level, & Plumb
t7FSJGZUIFSPVHIPQFOJOHJTMFWFMBOEQMVNC$5IFNBYJNVN
allowable deviation is 1/8".
t5IFSPVHIPQFOJOHTJMMNVTUOPUCFDSPXOFEPSTBHHFE%
t5IFFYUFSJPSGBDFPGUIFSPVHIPQFOJOHNVTUCFJOBTJOHMFQMBOF&
with less than 1/8" twist from corner to corner.
t.JOJNVNEPVCMFTUVETTIPVMECFVTFEBUBMMSPVHIPQFOJOHT
t5IFIFBEFSNVTUCFTVQQPSUFECZUSJNNFSTUVET
1. Cut a piece of sheet
material to the
length shown.
2. Lightly crease
folding lines 1/2" in
from the two short
sides and one long
side.
.FBTVSFUIF
distance from the
nailing n to the
interior edge of
the frame and add

5BLFUIJTEJTUBODF
from the back edge
and lightly crease a
folding line across
the sheet material.
'PSTUFQEPXO
landings, cut 1/2" in
at this line on both
sides of the sheet
material.
PREPARE SILL PAN
3
Frame
width

Folding Line
Length of rough opening sill plus 1"
1/2"
1/2"
Measure
frame
width
Interior
Continuous slab
Step-down
Fold sides and back up
Fold corner
forward
Fold front
ap down
REMOVE PACKAGING
Remove shipping materials such as corner covers, shipping blocks
or pads.
INSPECT YOUR PATIO DOOR
t$PTNFUJDEBNBHF
t1SPEVDUTRVBSFOFTTEJBHPOBMNFBTVSFNFOUTNVTUCFXJUIJO
EJGGFSFODF
t$PSSFDUQSPEVDUTJ[FDPMPSHSJEQBUUFSOIBOEJOHHMB[JOHFOFSHZ
efciency requirements, etc.)
1
REMOVE PACKAGING & INSPECT YOUR PATIO DOOR
t4QMJUTDSBDLTIPMFTNJTTJOHTFDUJPOTPSPUIFSEBNBHFUPUIFOBJMJOH
n longer than 6" and/or within 1/2" of patio door frame
t'PSTJEFCZTJEFNVMMFEVOJUTBESJQDBQUIBUFYUFOETUIFMFOHUIPGUIF
frame plus 1/8" overhang on each end is required
If any of the above conditions represent a concern, or if you expect
environmental conditions to exceed the patio door's performance
rating, do not install the patio door. Contact your dealer or distributor
for recommendations.