Item #1006149746 Model #1834FM-23-328 ASSEMBLY INSTRUCTIONS GRAFTON 40 IN INFRARED ELECTRIC FIREPLACE IN HERITAGE OAK Questions, problems, missing parts? Before returning to the store, call Home Decorators Collection Customer Service 8 a.m. - 7 p.m., EST, Monday - Friday, 9 a.m. - 6 p.m., EST, Saturday 1-800-986-3460 HOMEDEPOT.COM/HOMEDECORATORS THANK YOU We appreciate the trust and confidence you have placed in Home Decorators Collection through the purchase of this fireplace console.
Table of Contents Table of Contents. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Safety Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Important Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Pre-Installation. .
Safety Information (continued) WARNING: □□ This appliance is hot when in use. To avoid burns, DO NOT let bare skin touch hot surfaces. Keep combustible material, such as furniture, pillows, bedding, papers, clothes and curtains at least 3 feet from this appliance and keep them away from the sides and rear. □□ Extreme caution is necessary when any heater is used by or near children or individuals with disabilities and whenever the fireplace is left operating and unattended. □□ DO NOT run cord under carpeting.
Safety Information (continued) Electrical Connection □□ A 15-Amp, 120-volt, 60 Hz circuit with a properly grounded outlet is required. Preferably, the fireplace will be on a dedicated circuit as other appliances on the same circuit may cause the circuit breaker to trip or the fuse to blow when the heater is in operation. The unit comes standard with 6-ft. three-wire cord, exiting from the rear of the fireplace. DO NOT exceed the current rating of the current tap.
Warranty This item is warrantied by the manufacturer to be free of material and manufacturing defects for the time period of one year from the purchase date. This is subject to the following limitations and conditions: This mantel must be installed and operated in accordance with the installation instructions that were provided with the product. Unauthorized repairs or alterations, accidents, willful abuse and misuse of the product will nullify this warranty.
Pre-Installation PLANNING INSTALLATION Before beginning assembly of product, make sure all parts are present. Compare parts with package contents list and hardware contents list. If any part is missing or damaged, do not attempt to assemble the product. Estimated Assembly Time: 35 minutes. Tools Required for Assembly (not included): Phillips screwdriver. TOOLS REQUIRED Phillips screwdriver (not included) HARDWARE INCLUDED NOTE: Hardware not shown to actual size.
Pre-Installation (continued) PACKAGE CONTENTS A D C B E F G H K J Part I L Description Quantity A Top 1 B Center Panel 1 C Upper Opening Plate 1 D Left Wall 1 E Right Wall 1 F Left Front Panel 1 G Right Front Panel 1 H Left Opening Plate 1 I Right Opening Plate 1 J Base 1 K Insert 1 L Remote control 1 7 HOMEDEPOT.COM/HOMEDECORATORS Please contact 1-800-986-3460 for further assistance.
Installation 1 Install opening plates □□ From behind the assembly, align the holes on left front panel (F) with the corresponding holes on left opening plate (H). Secure with two washers (HH) and two bolts (GG). □□ Repeat for right front panel (G). GG 2 HH GG HH H 1 I 1 F G 2 Screw connecting rod □□ Screw four connecting rods (EE) into the designated plastic bushings on the back of the left wall (D) and right wall (E). Fully tighten with a Phillips screwdriver.
Installation (continued) 3 Install L/R walls □□ Insert two wooden dowels (AA) into holes on left wall (D). Align the holes on left wall (D) with the corresponding holes on left front panel (F). Secure with two locknuts (FF). □□ Repeat for right wall (E). FF 2 FF D 1 F E AA 1 G 4 Install base □□ Insert four wooden dowels (AA) into holes on left outer side of base (J). Place assembly from Step 3 onto base (J), securing from underneath with three long screws (BB). □□ Repeat for right wall (E).
Installation (continued) 5 Install upper opening plate □□ Align the holes on center panel (B) with the corresponding holes on upper opening plate (C). Secure with three washers (HH) and three bolts (GG). GG HH C 1 2 GG HH B 6 Install center panel □□ Insert eight wooden dowels (AA) into the top holes on both left front panel (F), left opening plateand (H), right opening plate (I) and right front panel (G).
Installation (continued) 7 Install center panel □□ As shown in the diagram, secure with four screws (CC). CC CC 8 Screw connecting rod □□ Screw seven connecting rods (EE) into the designated plastic bushings on the back of the top (A). Fully tighten with a Phillips screwdriver. EE A EE 11 HOMEDEPOT.COM/HOMEDECORATORS Please contact 1-800-986-3460 for further assistance.
Installation (continued) 9 Install top □□ Insert four wooden dowels (AA) into the top outer holes on both left wall (D), center panel (B) and right wall (E). Attach top (A), and secure with screwing seven locknuts (FF) by Phillips screwdriver. A AA 1 FF FF B D E 10 Position the insert NOTE: Before proceeding to the next step, with the help of another person, move the mantel close to the final desired location. DO NOT plug the insert (K) into power outlet yet.
Installation (continued) 11 Install insert □□ Secure the insert (K) to the base (J) with two short screws (DD) on the left side and on the right side of the insert (K). K J DD DD WARNING: You must install the tip restraint hardware to help prevent any accidents or damage to the unit. We strongly recommend attaching the tip restraint hardware to a wall stud and your unit. For all other wall types, please visit your local hardware store to obtain the proper hardware. □□ Assembly is now complete.
Operating Instructions Control Panel Remote Control To use the remote control, first remove the plastic tab by gently pulling it out of remote control (L). Power Button □□ Pressing the power button will turn ON or OFF the unit. □□ When the unit is in ON mode, the power icon indicator light will be shown green and turn ON the heating level and flame brightness effect with the last settings. □□ When the unit is in OFF mode, the power icon indicator light will be shown red.
Operating Instructions (continued) Temperature Mode □□ The temperature mode controls the heater’s thermostat setting. □□ Use Up arrow button or Down arrow button to scroll through the pre-set temperature setting. The temperature setting range is 65ºF (18ºC) to 90ºF (32ºC), HI (High) and OF (OFF). □□ Hold down the Up arrow button and Down arrow button for 5 seconds to toggle between 5°F (3°C) increments and 1°F (1°C) increments when setting the temperature.
Care and Maintenance □□ Make sure the unit is turned OFF and unplugged whenever you are cleaning the heater or fireplace. □□ Dust the fireplace regularly with a soft, non-lint producing cloth or household dusting product. □□ Clean the fireplace with a gentle non-abrasive household cleaner. Make sure to dry the fireplace immediately with a soft cloth or towel. □□ Tips for using touch-up pen (II): For scratches, stroke in direction of scratch. For worn areas, stroke in the direction of wood grain.
Troubleshooting Problem Possible cause Error E1 displayed on control panel. The overheat sensor has been engaged. Solution Unplug unit, wait 5-10 minutes, then the sensor will reset itself. Plug the unit back in and turn on the heater. If the problem persists, call customer service. NOTE: The other functions will work normally. Until the problem is solved, the error will only appear/sound when the heater button is pressed. Error E2 displayed on control panel.
Service Parts MODEL TYPE A K B C E G D F I H L J JJ LL Item #0000000000 GRAFTON 40 IN INFRARED ELECTRIC FIREPLACE IN HERITAGE OAK Model #1834FM-23-328 CC Screw (X 4) BB Long Screw (X 6) AA Wooden Dowel (X 24) HH Washer (X 7) DD Short Screw (X 4) F C F C F C F C F C S F C S S S Z S Z Z Z Z Z S F C F C S F C F C F C S S S S Z Z Z Z Z II Touch-up Pen (X 1) FF Locknut (X 11) GG Bolt (X 7) EE Connecting Rod (X 11) 1-800-986-3460 Part Description Part # 1834FM-23-
Questions, problems, missing parts? Before returning to the store, call Home Decorators Collection Customer Service 8 a.m. - 7 p.m., EST, Monday - Friday, 9 a.m. - 6 p.m., EST, Saturday 1-800-986-3460 HOMEDEPOT.COM/HOMEDECORATORS Retain this manual for future use.