Technical manual
Table Of Contents
- ZW180_TO4GD-E-00
- INTRODUCTION
- SECTION AND GROUP CONTENTS
- SECTION 1 GENERAL
- SECTION 2 SYSTEM
- Group 1 Control System
- Group 2 ECM System
- Group 3 Hydraulic System
- Group 4 Electrical System
- Outline
- Main Circuit
- Electric Power Circuit
- Indicator Light Check Circuit
- Accessory Circuit
- Preheat Circuit
- Starting Circuit
- Charging Circuit
- Serge Voltage Prevention Circuit
- Engine Stop Circuit
- Lamplight Circuit
- Head Light Circuit
- Turn Signal Circuit
- Brake Light Circuit
- Hazard Light Circuit
- Horn Circuit
- Reverse Light/Buzzer Circuit
- Parking Brake Circuit
- Emergency Steering Check Circuit (Optional)
- SECTION 3 COMPONENT OPERATION
- Group 1 Pump Device
- Group 2 Control Valve
- Group 3 Hydraulic Fan Motor
- Group 4 Steering Pilot Valve
- Group 5 Steering Valve
- Group 6 Pilot Valve
- Outline (Standard Lever Type Pilot Valve for Front Attachment)
- Operation
- Electromagnetic Detent
- Outline (Joystick Type Pilot Valve for Front Attachment)
- Operation
- Electromagnetic Detent
- Outline (Two-Derectional Lever Type Pilot Valve for Additional Circuit) (Optional)
- Operation
- Outline (Joystick Type Pilot Valve for Additional Circuit) (Optional)
- Operation
- Group 7 Charging Block
- Group 8 Ride Control Valve
- Group 9 Drive Unit
- Group 10 Axle
- Group 11 Brake Valve
- Group 12 Others
- SERVICE MANUAL REVISION REQUEST FORM
GENERAL / Component Specifications
T1-3-8
RIDE CONTROL VALVE (OPTIONAL)
Type.......................................................... Pilot Pressure Operated Type
Overload Relief Set Pressure................... 39.2 MPa (400 kgf/cm
2
) @ 50 L/min (13 US gpm)
Charge Cut Pressure................................ 11.3 MPa (115 kgf/cm
2
)
RIDE CONTROL ACCUMULATOR (OPTIONAL)
Capacity.................................................... 4 L (244 in
3
)
Charging Pressure ................................... 2.9 MPa (30 kgf/cm
2
)
CHARGING BLOCK
Charging Pressure ................................... Cut In Pressure: 11.8 MPa (120 kgf/cm
2
)
Cut Out Pressure: 14.7 MPa (150 kgf/cm
2
)
Pilot Relief Valve Set Pressure................. 3.7 MPa (38 kgf/cm
2
) @ 40 L/min (10.6 US gpm)
SOLENOID VALVE (For Charging Block)
Function.................................................... • Main Pump Torque Control
• Parking Brake
SERVICE BRAKE ACCUMULATOR
Capacity.................................................... 1.4 L (85.4 in
3
)
Charging Pressure ................................... 4.4 MPa (45 kgf/cm
2
)
PILOT ACCUMULATOR
Capacity.................................................... 0.75 L (45.8 in
3
)
Charging Pressure ................................... 2.0 MPa (20 kgf/cm
2
)
PILOT SHUT OFF VALVE
Type.......................................................... Rotary Type
STEERING VALVE
Type.......................................................... Flow Amp Type
Over Load Relief Set Pressure ................ 32.3 MPa (330 kgf/cm
2
) @50 L/min (13 US gpm)