User Manual

PROPANE CONVERSION INSTRUCTIONS
31-10994-1 03-17 GEA
P2B940
To adjust your range for use with propane gas, follow these
instructions:
1. Disconnect all electrical power, at the main circuit breaker or
fuse box.
2. Shut off the gas supply to the range by closing the manual
shut-off valve.
CONVERTING THE PRESSURE REGULATOR CONVERTING THE COOKTOP BURNERS
A. Remove the top grates, burner caps and burner heads.
B. Using a 7 mm or 9/32” nut driver, remove the top burner
RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHU
opening in the base.
&5HPRYHWKHSURSDQHRUL¿FHVIURPWKHER[SURYLGHG7KH
SURSDQHRUL¿FHVKDYHWKHOHWWHU³/´RQWKHWRS
To aid in identifying the proper location for the propane
RUL¿FHVGXULQJFRQYHUVLRQIURP1DWXUDO*DVWR3URSDQH
*DVFRORUFRGHVKDYHEHHQDGGHGWRWKHVLGHRUWRSRIWKH
RUL¿FH6HHWKHFKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZD
series of engraved marks (I, II, III . . .) located on the top.
Remove the warming drawer and panel behind drawer. The
pressure regulator is located in the lower, left hand rear corner
of the range as viewed from the front.
A. If this is your regulator:
1. Use an adjustable wrench to unscrew the hex-nut cap
from the pressure regulator.
2. Completely remove the protective plastic cap off the
threaded metal cap.
3. Turn the metal cap so the type of gas being converted to
is displayed and replace the protective plastic cover.
4. Screw the hex-nut cap back into the regulator.
(Do not over tighten)
B. If this is your regulator:
1. Use an adjustable wrench to unscrew the hex-nut cap
from the pressure regulator.
2. Turn the plastic cap 1/4 turn to disassemble.
3. Turn the plastic cap over and hook it into the slots.
Rotate cap 1/4 turn to reassemble. The type of gas to be
used should now be visible on the top of the cap.
4. Screw the hex-nut cap back onto the pressure regulator.
TOOLS REQUIRED:
• Adjustable wrench
• Socket wrench with
1/2” socket and extension
• 3KLOOLSVKHDGVFUHZGULYHU
• Flat bladed screwdriver
(blade approximately
3/32” across)
• 1XWGULYHUV´´
or 7mm
3UHVVXUH5HJXODWRU *DV9DOYH
PROPANE CONVERSION INSTRUCTIONS
PROPANE
NAT
Rotate cap counter-
clockwise to loosen
Cap assembly
Regulator style A
Rotate cap counter-
clockwise to loosen.
PROPANE
NAT
Regulator style B
WARNING
This conversion must be performed
E\DTXDOL¿HGLQVWDOOHURUJDVVXSSOLHULQDFFRUGDQFH
with the manufacturer’s instructions and all codes and
requirements of the authority having jurisdiction. Failure
WRIROORZ$//LQVWUXFWLRQVFRXOGUHVXOWLQVHULRXVLQMXU\RU
SURSHUW\GDPDJH7KHTXDOL¿HGDJHQF\SHUIRUPLQJWKLV
work assumes responsibility for the conversion.
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDO
WARNING
Do not operate the cooktop or oven
burners of this range when using propane (bottled) gas
EHIRUHFRQYHUWLQJWKHSUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHV
for propane gas use. Failure to do so could cause high
ÀDPHVDQGWR[LFIXPHVZKLFKFDQUHVXOWLQVHULRXVLQMXU\
7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRU
natural gas. To use propane gas, the regulator and burner
RUL¿FHVPXVWEHFRQYHUWHG
7KHSURSDQHRUL¿FHVIRUWKHFRRNWRSEXUQHUVDUHVKLSSHGRQ
the back of the range in the location shown.
',QVWDOOWKHSURSDQHRUL¿FHVLQWKHLUSUHFLVHORFDWLRQV
7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVSXGVDUHVHFXUHO\
screwed into the gas supply tubes.
(,QVWDOOWKHROGRUL¿FHVSXGVLQWRWKHPHWDOER[RUEUDFNHW
along with these instructions, and replace onto the back of the
range for possible future conversion.
3URSDQH&RQYHUVLRQ.LW
BURNER OUTPUT RATINGS: BTU/HR
Propane Gas 10” W.C.P.
BURNER
BTU
RATE
ORIFICE
SIZE (mm) COLOR MARKING
/) 15,000
/) 1$ 0.025” (0.63) Blue/Blue /
/) 1$ 0.025” (0.63) Blue/Blue /
/) 1$ 0.025” (0.63) Blue/Blue /
/)& 1$ 0.016” (0.35) 1RQH /
RF 18,000 0.047” (1.19) Red/Orange /
/5 5,000 0.026” (0.66) Red/Yellow /
RR 9,500 0.035” (0.89) Blue/Brown /
C 10,000
C1 1$ 0.035” (0.89) Blue/Brown /
C2 1$ 0.033” (0.84) %URZQ*UHHQ /
95
III
Denotes 0.95mm Orifice size opening
Denotes LP (Propane)
Multi-ring Round burner
Burner cap
Burner cap
Burner cap
Burner head
Burner head
Base
Base
2UL¿FH
located
through this
opening
Dual oval burner
Round Burner Cap
(Removable)
3HUPDQHQW
Oval Burner Caps
1RQ5HPRYDEOH
2UL¿FHV
located
through this
opening
2UL¿FH
located
through this
opening
LR
C2
C1
RR
LF
RF
Propane
Red/Yellow Blue/Brown
Propane
Blue/Brown
Propane
Blue/Blue
Propane
Red/Orange
Blue/Blue
Propane
Propane
Propane
Blue/Blue
None
Propane
LF3
LF1
LFC
LF2
Propane
Brown
/Green