Product Manual

ManualsBrandsGasmate ManualsCooking Appliances2 Ring Cast Iron Outdoor Stove Burner

Ideal for camping

Suitable for cooking at home where larger pots and a

higher heat output is required – Convenient for cooking

sauces, crabs, lobster or any shell fish

Made from high quality cast iron with brass controls

Outlet: ¼” BSP thread

Hose and Regulator included

Propane use only

Gas certified to Australian Standards

RB2

RB3

RB4

Gasmate

is a registered trademark of: Sitro Group Australia Pty Ltd www.gasmate.com.au

Aber Living, N.Z www.gasmate.co.nz

NOTE: ONLY USE ON A NON-COMBUSTIBLE SURFACE

CAST IRON RING BURNERS

Model No. RB2, RB3 and RB4

Important: Retain these instructions for future use

03455 09/18

Summary of content (8 pages)

PAGE 1
CAST IRON RING BURNERS Model No. RB2, RB3 and RB4 Ideal for camping Suitable for cooking at home where larger pots and a higher heat output is required – Convenient for cooking sauces, crabs, lobster or any shell fish Made from high quality cast iron with brass controls Outlet: ¼” BSP thread Hose and Regulator included Propane use only Gas certified to Australian Standards RB2 RB4 RB3 NOTE: ONLY USE ON A NON-COMBUSTIBLE SURFACE Gasmate® is a registered trademark of: Sitro Group Australia Pty Ltd www.
PAGE 2
GENERAL INFORMATION After the assembly has been secured, turn on the gas and check for leaks by brushing a soap and water solution overall connections. Gas Installation Codes • A ppliance must be used in accordance with the installation requirements of your gas supply authority, or the appropriate installation code issued by Standards Australia AS 5601. DO NOT USE this appliance if it is leaking, damaged or does not operate properly.
PAGE 3
Product Details Never Store your Gas Cylinder Indoors RB2 If you store your appliance indoors, ALWAYS disconnect the gas cylinder first and store the cylinder safely outside. Cylinders must be stored outdoors in a well ventilated area out of reach of children, and must not be stored in a building, garage or any other enclosed area. Gas Type Propane Inj. Size (mm) 0.7 1.10 Gas Cons. (MJ/h) 5.5 13 Gas connection is 1/4” BSP Gas Pressure 2.
PAGE 4
RING BURNER COMPONENTS (Image as guide only) 1. Hose and Regulator assembly 2. Gas valve 1 • RB2 - screws on top • RB3 - screws from underside • RB4 - screws from underside 3. Burner • RB2 - 2 rings • RB3 - 3 rings • RB4 - 4 rings 4. Trivets - to stand cooking pot on Note: Remove any transit protection material before using the burner.
PAGE 5
GENERAL ASSEMBLY CARE & MAINTENANCE Connecting & Disconnecting to Gas Source As with all appliances, proper care and maintenance will keep them in top operating condition and prolong their life. Your new gas appliance is no exception. By following these cleaning procedures on a timely basis, your appliance will be kept clean and working properly with minimum effort. Familiarise yourself with the general information and safety guidelines located at the front of this manual. Check 1.
PAGE 6
LIGHTING PROCEDURE Burner Operation & Ignition System Check RB2 1. Turn inner gas valve on. 2. Open gas valve and light immediately with long BBQ match following sequence in step 3. 1 Inner # 1 Outer # 4 3. Light the burners in order: 4 Without pot: RB2 Inner # 1 Outer # 4 RB3 Inner # 1 1st Middle # 2 Outer # 4 RB4 Inner # 1 1st Middle # 2 2nd Middle # 3 Outer # 4 All of these will need to be lit using a long BBQ match.
PAGE 7
OPERATING PROCEDURE The gas valve can be adjusted from “OFF to “HIGH” and this will affect the cooking time. Gas Valve “ON” Max. The gas lever is in a straight line with the gas valve to the venturi tube. Gas valve “OFF” Primary Air Disk Gas Valve “OFF” Gas Valve “ON” Gas Inlet The gas lever is at right angles to the gas valve and the venturi tube. Spillage Turn off the cylinder gas valve. Wait for the flame to go out. Using heat proof gloves: • Remove cooking pan. • Blow liquid from burner ports.
PAGE 8
SAFE APPLIANCE LOCATIONS This appliance shall only be used in an above ground open-air situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by wind and natural convection. Only use on a Non-combustible surface. Any enclosure in which the appliance is used shall comply with the following: An enclosure with walls on all sides, but at least one permanent opening at ground level and no overhead cover.