® >Ü /À>VÌÀ Owner's Manual with Assembly Instructions For Model K3034 Please read this manual and save it with your original sales receipt. Tools needed for assembly:Phillips Screwdriver, Hammer, and Slotted Screwdriver (all not included). Use only with a Power Wheels® 6 Volt (4.0 Amp/Hr.) Rechargeable Battery with Built-in Thermal Fuse and a Power Wheels® 6 Volt (4.0 Amp/Hr.) Charger (both included). Product features may vary from the picture above.
A TABLE OF CONTENTS A Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 B Warnings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 C Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WARNINGS AND CAUTIONS B ELECTRICAL HAZARD WARNING • Battery can fall out and injure a child if vehicle tips over. Always use battery retainer. • PREVENT FIRE - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system. - Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury.
PARTS C • If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return this product to the store. • Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded. • Some parts were placed under the seat for shipment. Unlock the seat lock fastener, using a slotted screwdriver to rotate the lock fastener 1/4 turn to the unlocked position . Lift the seat.
PARTS PICTURE Note: Some parts shown are assembled on both sides of the vehicle. D 2 9 6 7 14 3 1 8 10 15 12 16 4 11 13 5 17 1 2 3 4 5 6 Vehicle Steering Wheel Assembly 6 Volt (4.0 Amp/Hr.) Battery 6 Volt (4.0 Amp/Hr.) Charger Snap Bushing - 2 Seat K3034pr-0920 7 8 9 10 11 12 Battery Retainer Steering Column Cap #8 -18 x 7/8" Screw #8 x 3/4" Screw Hubcap - 2 Washer - 2 13 14 15 16 17 Wheel - 2 Wrench Steering Linkage Long Bushing - 2 .
BATTERY CHARGING E ELECTRICAL HAZARD WARNING • Battery can fall out and injure a child if vehicle tips over. Always use battery retainer. • PREVENT FIRE - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system. - Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury.
BATTERY CHARGING E IMPORTANT! The battery must be removed from your vehicle for the initial charge in order to complete assembly. You do not need to remove the battery from the vehicle to recharge it. Battery Retainer 2 • Using a Phillips screwdriver, loosen the screw in the battery retainer. Remove the battery retainer from the vehicle. • Remove the Power Wheels® 6 Volt (4.0 Amp/Hr.) battery from the battery compartment.
ASSEMBLY F WARNING Fork Children can be harmed by small parts, sharp edges and sharp points in the vehicle's unassembled state, or by electrical items. Care should be taken in unpacking and assembly of the vehicle. Children should not handle parts, including the battery, or help in assembly of the vehicle. Long Bushing Snap Bushing Center Axle Steering Linkage 3 Wheel 1 • Fit a long bushing, tapered end first, into the smaller indent in a wheel.
ASSEMBLY F Rectangular Opening Power Button Connector Steering Column Cap Motor Harness Connector 5 BOTTOM VIEW IMPORTANT! An electrical connection must be made for your vehicle to function properly. Please follow these instructions carefully. • Carefully stand the vehicle on end. • Reach inside the slot in the underside of the vehicle near the steering linkage and pull the power button connector out. • Fit the power button connector into the motor harness connector.
ASSEMBLY F Lock Fastener Wrench Seat Tab 9 • Fit the wrench into the hole in the top side of the vehicle, near the seating area. 8 Lock Fastener LOCKED Lock Fastener UNLOCKED Note: If you have already charged your Power Wheels® 6 Volt (4.0 Amp/Hr.) battery for at least 18 hours, you may want to re-install it into the battery compartment before assembling the seat to your vehicle. Please refer to the Battery Installation section beginning on page 12 for instructions.
DECORATION G Proper label application will help to keep the labels looking their best! When applying labels, keep the following guidelines in mind: • Wash your hands before applying the labels. • Before applying the labels, wipe the surface of the vehicle with a clean, dry cloth to remove any dust or oils. • Place the labels exactly as shown in the illustrations. • For best results, avoid repositioning a label once it has been applied to the vehicle.
BATTERY INSTALLATION H IMPORTANT! Use only a Power Wheels® 6 Volt (4.0 Amp/Hr.) leadacid rechargeable battery. Use of any other battery will damage your vehicle. Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels® 6 Volt (4.0 Amp/Hr.) charger before operating your vehicle for the first time. Charge the battery for at least 14 hours after each use of the vehicle. Never charge the battery longer than 30 hours.
BATTERY CARE AND DISPOSAL Care If a battery leak develops, avoid contact with the leaking acid and place the damaged battery in a plastic bag. See information below for proper disposal. If acid comes in contact with skin or eyes, flush with cool water for at least 15 minutes and call a physician. If acid is internally ingested, give water, milk of magnesia or egg whites immediately. Never give emetics or induce vomiting. Call a physician. • Charge a new battery for at least 18 hours before first use.
SAFE DRIVING RULES J RIDING HAZARD WARNING • Prevent Injuries and Deaths • Direct Adult Supervision Required • Never Ride at Night. • Keep Children Within Safe Riding Areas. These areas must be: - away from swimming pools and other bodies of water to prevent drownings - generally level to prevent tipovers - away from steps, cars, steep inclines, roads and alleys. • Riding Rules Make sure children know and follow these rules for safe driving and riding. - Always sit on the seat. - Always wear shoes.
VEHICLE OPERATION K IMPORTANT! Use this vehicle ONLY outdoors. Most interior flooring can be damaged by riding this vehicle indoors. Fisher-Price® will not be responsible for damage to the floor if the vehicle is used indoors. Steering Wheel PRESS Power Button 2 mph Footrest • Seat your child on the vehicle, with both hands on the steering wheel and both feet on the footrests. • Press the power button on the steering wheel. The vehicle moves forward at a maximum of 2 mph.
PROBLEMS AND SOLUTIONS GUIDE N IMPORTANT! If you experience a problem with your vehicle, first check the Problems and Solutions Guide below. If you still experience a problem, please contact Power Wheels® Consumer Relations, toll-free at 1-800-348-0751 between 9 AM and 7 PM (EST) Monday through Friday and 11 AM-5 PM (EST) Saturday. Or, contact your local Power Wheels® authorized service center. For the location nearest you, please visit us on-line at www.powerwheels.com, or call 1-800-348-0751.
PROBLEMS AND SOLUTIONS GUIDE N PROBLEM POSSIBLE CAUSE Vehicle was running but suddenly stopped Loose wire or loose connectors Check all wires and connectors. Make sure the motor harness connector is plugged into the battery connector, and that there are no loose wires around the motors. Tripped thermal fuse Each Power Wheels® 6 Volt (4.0 Amp/Hr.) battery has a built-in thermal fuse.
PROBLEMS AND SOLUTIONS GUIDE N PROBLEM POSSIBLE CAUSE Vehicle runs sluggishly Undercharged battery SOLUTION Charge the battery. A new battery should have been charged for at least 18 hours before using the vehicle for the first time. After firsttime use, recharge the battery for at least 14 hours after each use. Never charge the battery longer than 30 hours. Check all connectors. Make sure the charger connector is plugged into the battery, and that the charger is plugged into the wall.
K3034pr-0920 19
Before first-time use, you must charge the battery 18 hours! Charge the battery immediately after each use. Charge the battery once a month, even if the vehicle is not used or stored. Do not return your vehicle to the store! We're a toll-free phone call away, and we can help. If you are missing parts or need assistance, please call: 1-800-348-0751 Or contact your local independently owned and operated Power Wheels® Authorized Service Center. For the location nearest you, visit us on-line at www.
