Full Product Manual

ManualsBrandsFIMCO ManualsBattery Sprayers25 Gal. Deluxe Pistol Grip Tank Sprayer

Page 1

Model: LG-28-S (5301063)

(25 Gallon Lawn & Garden Spot Sprayers)

www.fimcoindustries.com

1000 FIMCO Lane, P.O. Box 1700, North Sioux City, SD 57049

Toll Free Phone: 800-831-0027 : Toll Free Fax: 800-494-0440

[5194800 (03/20)]

Technical Specifications

 25 Gal. Corrosion-Resistant

Polyethylene Tank

 12 Volt Diaphragm Pump,

2.4 g.p.m.—60 psi

 Deluxe Pistol Grip Handgun

 25’ Vertical Spray,

40’ Horizontal Spray

 15 Ft. Handgun Hose (3/8” I.D.)

Assembly Instructions

Your sprayer has been mostly assembled at the factory. The

only requirement will be for you to attach the wand clips and

hook up your battery leads to a fully charged 12 Volt battery.

 The drain plug assembly should already be attached to

the tank

Caution: When fully filled with water, this sprayer will

weigh approx. 240 lbs.. Consult the owner’s manual for

your vehicle to verify that you are within it’s load

carrying capacity.

***IMPORTANT REMINDER***

This sprayer comes with an On/Off (shut-off) valve located at the inlet location

of the tank, towards the underside. (See Detail A). You must make sure the

valve is in the “open” position before using your sprayer.

Detail A

OWNER’S MANUAL

BEFORE RETURNING THIS PRODUCT

FOR ANY REASON, PLEASE CALL

1-800-831-0027

MONDAY-FRIDAY, 8:00 AM TO 5:00 PM CST

If you should have a question or experience a problem with

your Fimco Industries Product: Visit our website @

www.fimcoindustries.com or call the Toll free number above. Our

technical support representatives will be happy to help you.

In most cases a customer service rep. can resolve

the problem over the phone.

To obtain prompt, efficient service, always remember to give the

following information....

• Correct Part Description and/or part number

• Model number and Serial Number

Part descriptions and numbers can be obtained from the

illustrated parts list section(s) of this manual.

General Information

Thank you for purchasing this product. The purpose of this

manual is to assist you in operating and maintaining your lawn

& garden Spot sprayer.

Retain a copy of your receipt for your

unit, as it will be required to validate

any warranty service.

Warranted against manufacturer or

workmanship defects from date of

purchase with copy of receipt:

Homeowner Usage: Sprayer-One Year and Pump-Two Years.

Commercial Usage: Sprayer and Pump-90 Days.

Summary of content (6 pages)

PAGE 1
OWNER’S MANUAL Model: LG-28-S (5301063) (25 Gallon Lawn & Garden Spot Sprayers) Technical Specifications      25 Gal. Corrosion-Resistant Polyethylene Tank 12 Volt Diaphragm Pump, 2.4 g.p.m.—60 psi Deluxe Pistol Grip Handgun 25’ Vertical Spray, 40’ Horizontal Spray 15 Ft. Handgun Hose (3/8” I.D.) General Information Thank you for purchasing this product. The purpose of this manual is to assist you in operating and maintaining your lawn & garden Spot sprayer.
PAGE 2
IMPORTANT: Remove tank lid and be sure the tank is clean and free of any foreign material. Rinse tank out of any tank residue before filling with water to test. Proper care and maintenance will prolong the life of your sprayer. Testing the Sprayer NOTE: It is important that you test your sprayer for leakage and proper spray patterns with plain water before chemical application is attempted.
PAGE 3
Pump Model: 5281371 2.4 GPM, 60 PSI Available Replacement Parts Replacement Pump: 5151087 Includes: 1/2” MNPT Port Kit Fitting #5168832 1/2” Hose Barb Port Kit Fitting #5168833 3/8” Hose Barb Port Kit Fitting #5168836 DO  Clean and rinse your pump after each use with Fimco Tank Neutralizer  Winterize your pump or sprayer by rinsing, draining and running RV Antifreeze through it before storing for the winter.  Use clean water for your spray mixture  Store inside a building when not in use.
PAGE 4
Checking the Pressure Switch: If your motor is not running and you’ve checked the following: for loose wiring connections, fuse, the switch on the lead wire was “ON” and made sure you were connected to a fully charged battery and everything is fine, but the motor won’t run, then it’s time to check to see if the pressure switch is bad.  Remove the cover off the 1” square box (pressure switch) on the head of the pump, the cover is held on by one phillips-head screw. This will expose the two red wires.
PAGE 5
Exploded View/Parts List: LG-28-S (5301063) Intake Assembly 5281145 Page 5
PAGE 6
Warranty LIMITED WARRANTY FOR NEW FIMCO, IND. EQUIPMENT WHO MAY USE THIS LIMITED WARRANTY. This limited warranty (the “Limited Warranty”) is provided by Fimco, Ind. to the original purchaser (“you”) of the Equipment (as defined below) from Fimco, Ind. or one of Fimco, Ind.’s authorized dealers. This Limited Warranty does not apply to any subsequent owner or other transferee of the Equipment.