Specification

ManualsBrandsFiberlock ManualsPaint5 gal. Serpimastic Off White High Temp Encapsulant Troleable

Page1of11



SDS Date: May, 2015

Safety Data Sheet

Per GHS Standard Format

SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION

Product Identifier

Product Name: SerpiMastic No. 2418 Trowelable and No. 2419 Sprayable

Recommended Use of Product: Interior/Exterior Bridging Encapsulant

Information on the Supplier of the Safety Data Sheet

Manufactured For: Emergency Telephone Numbers:

Fiberlock Technologies, Inc. CHEM TEL: (U.S.): 1-800-255-3924

150 Dascomb Road (Outside the U.S.): 813-248-0585

Andover, MA 01810

P: 800-342-3755 F: 978-475-6205

SECTION 2: HAZARDS IDENTIFICATION

Signal Word: WARNING



GHS Label Statements

Hazard Statements:

Harmful if inhaled.

Causes serious eye irritation.

May cause an allergic skin reaction.

Suspected of causing cancer.

GHS Classifications

This product is considered hazardous by The 2012 OSHA Hazard Communication Standard

(29 CFR 1910.1200)

Acute Toxicity-Inhalation (Vapors) Category 4

Acute Toxicity-Inhalation (Dust-mists) Category 2

Serious eye damage/eye irritation – Category 2

Skin sensitization – Category 1

Carcinogenicity – Category 2

PRECAUTIONARY STATEMENTS

Prevention: Obtain special instructions before use. Do not handle until all safety precautions have

been read and understood. Use personal protection (eye protection, gloves) during application. When

grinding/sanding dry films, wear respiratory protection.

Summary of content (11 pages)

PAGE 1
SDS Date: May, 2015 Safety Data Sheet Per GHS Standard Format SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product Identifier Product Name: SerpiMastic No. 2418 Trowelable and No. 2419 Sprayable Recommended Use of Product: Interior/Exterior Bridging Encapsulant Information on the Supplier of the Safety Data Sheet Manufactured For: Emergency Telephone Numbers: Fiberlock Technologies, Inc. CHEM TEL: (U.S.): 1-800-255-3924 150 Dascomb Road (Outside the U.S.
PAGE 2
Response: If on skin, wash with plenty of soap and water. If in eyes, rinse cautiously for several minutes. Remove contact lenses if present and easy to do. Continue rinsing. If inhaled, remove victim to fresh air. If exposed or concerned, get medical advice. Storage: Keep closures tight and containers upright to prevent leakage. KEEP FROM FREEZING. Product is non-combustible. Disposal: The coating and any contaminated diking material should be thoroughly air dried and collected into drums.
PAGE 3
Self-Protection of the First Aider Avoid contact with skin, eyes or clothing. Use personal protective equipment as required. Wear personal protective clothing (see section 8). Ensure that medical personnel are aware of the material(s) involved, take precautions to protect themselves and prevent spread of contamination. Avoid breathing vapors or mists. Most important symptoms and effects, both acute and delayed Most Important Symptoms and Effects Burning sensation. Coughing and/or wheezing.
PAGE 4
Methods and Material for Containment and Cleaning Up Methods for Containment: Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Immediately place absorbent material in a sealed water-filled metal container to avoid spontaneous combustion of absorbent material contaminated with this product. Pick up and transfer to properly labeled containers.
PAGE 5
Individual Protection Measures, such as Personal Protective Equipment Eye/Face Protection: If splashes are likely to occur, wear safety glasses with side shields (or goggles). None required for consumer use. Skin and body Protection: Wear protective gloves and protective clothing Respiratory Protection: No protective equipment is needed under normal use conditions. If exposure limits are exceeded or irritation is experienced, ventilation and evacuation may be required.
PAGE 6
SECTION 10: STABILITY AND REACTIVITY Reactivity No data available Conditions to Avoid Excessive heat Chemical Stability Stable under recommended storage conditions Incompatible Materials None known based on information supplied Possibility of Hazardous Reactions None under normal processing Hazardous Decomposition Products Carbon oxides Hazardous Polymerization Hazardous polymerization does not occur SECTION 11: TOXICOLOGICAL INFORMATION Information on Likely Routes of Exposure Product Information: Product
PAGE 7
Chlorothalonil 1897-45-6 Polyethylene glycol branched Nonylphenyl either 68412-54-4 Methylchloroisothiazolinone 26172-55-4 > 10 g/kg (Rabbit) = 310 mg/m3 (Rat) 1 h = 1780 µL/kg (Rabbit) = 481 mg/kg (Rat) > 1008 mg/kg (Rat) = 1.23 mg/L (Rat) 4 h Information on Toxicological Effects Symptoms: May cause redness and tearing of the eyes, coughing and/or wheezing, itching, rashes and hives.
PAGE 8
ATEmix (dermal) 21,608.00 mg/kg (ATE) ATEmix (inhalation-gas) 3,118.00 ppm (4hr) ATEmix (inhalation-vapor) 16.
PAGE 9
material is a hazardous waste. Consult the appropriate state, regional, or local regulations for additional requirements. Contaminated Packaging: Dispose of contents/containers in accordance with local regulations California Hazardous Waste Codes: 331 SECTION 14: TRANSPORT INFORMATION DOT Proper Shipping Name Hazard Class TDG Un-No. Proper Shipping Name Hazard Class Packing Group Description IATA Un-No. Proper Shipping Name Hazard Class Packing Group Description IMDG/IMO Un-No.
PAGE 10
US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. Chemical Name Chlorothalonil CAS No. 1897-45-6 SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden release of pressure hazard Reactive Hazard Weight - % 0.
PAGE 11
SECTION 16: OTHER INFORMATION NFPA Health Hazards 2 Flammability 0 Instability 0 Physical &Chemical Hazards - HMIS Health Hazards 2* Flammability 0 Physical Hazard 0 Personal Protection X Chromic Hazard Star Legend * = Chronic Health Hazard WARNING! If you scrape, sand or remove old paint, you may release lead dust. LEAD IS TOXIC. EXPOSURE TO LEAD DUST CAN CAUSE SERIOUS ILLNESS, SUCH AS BRAIN DAMAGE, ESPECIALLY IN CHILDREN. PREGNANT WOMEN SHOULD ALSO AVOID EXPOSURE.