Instructions / Assembly

17
Evo, Inc., 20560 SW 115th Ave., Tualatin, OR 97062 USA
Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]
WARNING
Installing LP Tank To Grill
Refer to the diagram at the right and complete the fol-
lowing steps:
1. Be sure both grill burner valves are in the Off position.
2. Make sure the gas tank valve handwheel is in the closed
position. Turn clockwise ( left to right ) to a full stop.
3. Remove the protective cap from the gas tank valve.
4. Hold regulator in one hand and position the plastic cou-
pling nut on the tank valve outlet threads using care to
engage the center of the coupling nut to the center of the
tank valve outlet. When completing this procedure, take
care to not cross-thread the connection.
5. Turn the coupling nut clockwise (left to right) and tighten
to a full stop.
In the connection process, the regulator will seal on
the back-check feature in the tank valve resulting in a
slight resistance. The connection requires about one-
half to three-quarters additional turn to complete the
connection. Tighten by hand only - do not use tools.
If you cannot make the connection, disconnect the
regulator and repeat steps 4 and 5.
Connecting Regulator To Tank Valve
Never store LP gas tank indoors. When grill is stored
indoors, shut tank valve off and disconnect tank from
grill and remove to an outdoor location. Tank must
be stored outdoors in well-ventilated area, away from
and out of the reach of children.
1. Remove right-side leg support to gain access to LP tank.
For instructions on removing leg support, refer to page 10.
2. Loosen coupling nut located on regulator and tank valve
by turning counterclockwise using hands only - do not use
tools. Next loosen thumb screws securing tank to lower
rack and remove tank. Install safety cap over tank valve
coupling.
3. Reinstall leg support.
Removal & Storage Of LP Gas Tank
NEVER store tank in enclosed area. Safety relief valve on
tank could activate releasing gas and causing a fi re. All
spare tanks must have safety caps installed in tank outlet.
Spare tanks should never be stored near the grill.
Regulator
Coupling Nut
Handwheel
Cap & Strap
Valve
Outlet
Lower Rack
Remove Tank By
Tilting and Lifting
Outward From Right
Side