0,000W/240V GARAGE HEATER WITH CART OWNER’S MANUAL Model No.
TABLE OF CONTENTS Important Instructions……………………………………….3 Installation Instructions………………………. ……………5-7 Specifications and Wiring Diagram ……………………….8 Parts of the Heater……………………….…………..……...9 Operating Instructions……………………….………....…...10 Maintenance and Cleaning………………………………...11 Troubleshooting……………………………………………..12 Warranty……………………………….............……………..
IMPORTANT INSTRUCTIONS PLEASE READ ALL INSTRUCTIONS BEFORE USING THIS HEATER NOTE: There may be a trace of smoke or odor when unit is first operated. Don’t be alarmed. This indicates that a drop of oil fell on the heating coil during the manufacturing process. It will quickly evaporate and should not re-occur. Make sure that the room in which the appliance is located is well ventilated during this operation.
9) Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock or fire and potentially damage the heater. 10) To prevent a possible fire, do not block air intakes or exhaust in any manner. 11) A heater has hot and arcing or sparking parts inside. To reduce the risk of fire, do not use in areas where gasoline, paint, or flammable vapors and liquids are used or stored. 12) Use this heater only as described in this manual.
INSTALLATION INSTRUCTIONS WARNING: All wiring must be installed by a certified/licensed electrician. The heater must be grounded in accordance with applicable national and local building codes. WARNING: To reduce the risk of fire, do not store or use gasoline or other flammable vapors and liquids in the vicinity of the heater. All wiring procedures and connections should be in accordance with applicable national and local codes. NOTE: Compatible with a 240V Line Voltage Double Pole Wall Thermostat.
INSTALLATION INSTRUCTIONS: 1. Do not install closer than 1 foot (or 0.3 m) to any adjacent vertical surfaces or walls. 2. Keep at least 4.5 inches (0.12m) from the back wall (regardless of whether the wall mount bracket is used). 3. Insert the hand hold and tighten the screws. 4. Run the electrical power supply cable in flexible conduit and connect to the wiring compartment via the knock-out at the rear of the heater.
6. Make the connections properly with connectors which are suitable for the conductor size, including ground wires. After making the connections, arrange the pigtail leads of unit and power supply wires in the wiring compartment.
SPECIFICATIONS 10,000W/240V GARAGE HEATER WITH CART Model: DR-910M Voltage: 240 V Watts: 10,000 W Frequency: 60 Hz Recommended Heating Capacity: 1.25watts / ft³ (0.
PARTS OF THE HEATER A. B. C. Hand Hold Upper Housing Louver for air direction D. Lower Housing E. Tilt Adjustable Knob F. Wheel G. Control Panel H. ON/OFF Switch I.
OPERATING INSTRUCTIONS WARNING - The heater must be properly installed before it is used. HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH: Apply appropriate personal protective equipment (PPE) and follow safe electrical work practices. See NFPA 70. A circuit breaker must be installed and serviced only by qualified electrical personnel. Always use a properly rated voltage sensing device to confirm power is off. The switch on the heater is to start the Fan and Heater.
MAINTENANCE AND CLEANING No user maintenance on this heater should be undertaken except regular cleaning as described below. All other servicing or maintenance should be performed by qualified service personnel. Before any cleaning, make sure that: 1. Power supply is disconnected at the source. Switch off the circuit breaker. 2. Wait 60 minutes to ensure the heating element has cooled down. Your heater is now ready for cleaning. Regular Cleaning: 1.
TROUBLESHOOTING If your heater fails to operate, please follow these procedures: This heater is intended to be a cart-mounted heater. It has a thermal cut-off protection. If the thermal cut-off protection trips, switch off the power. Switch off the circuit breaker. The unit should reset automatically after 10 minutes. If the thermal cut-off protection trips again, consult a certified/licensed electrician to determine the reason for overheating.
How long is the warranty? This heater comes with a ONE-YEAR LIMITED COMPONENT WARRANTY. If your unit does not appear to be working properly, please contact our service center by calling 1-800-317-1688. Prior to your call, we encourage you to visit our service related website www.DrHeaterUSA.com for troubleshooting tips and service instructions if needed. Warranty Information Register your product at our website: heater Or visit DrHeaterUSA.
Dr. Heater USA 860 Mahler Road Burlingame, CA 94010 Tel: 1-800-317-1688 EMAIL:SERVICE@DRHEATERUSA.COM Dr Heater USA @Dr Heater USA Dr. Heater USA Dr.