OPD811 BIG DUMP CART CARRY-ALL COMBO SAFETY AND OPERATION INSTRUCTIONS CALL 702-331-5353 FOR PARTS AND SERVICE IMPORTANT: Read safety rules and instructions carefully before operating equipment.
Table of Contents Table of Contents PART I: General Safety Rules .................................................................................... 2 PART II: Familiar with the BIG DUMP .................................................................... 6 PART III: Operating the BIG DUMP ........................................................................ 7 PART IV: Maintaining the BIG DUMP ..................................................................... 9 PART V: Parts List....................
Part I: General Safety Rules PART I: General Safety Rules Improper installation and operation could cause personal injury, and/or equipment and property damage. Read and understand labels and the USER Manual before installing, operating, or adjusting. Safety Labels Found on Your Unit WARNING Read this Safety & Operating Instructions manual before using the BIG DUMP. Become familiar with the operation and service recommendations to ensure the best performance of your machine.
Part I: General Safety Rules Before using the BIG DUMP NOTICE A．Operators must be fully trained before using this machine. B． User Manual is read and understood. C．Machine is positioned on level ground; all guards are fitted and in good condition. D．Bucket and Carry-All is in good condition and secure. E． All fasteners are checked for tightness. F． DO NOT use other types of battery charger or batteries. G. DO NOT Carry “passengers” on your BIG DUMP. H. Exercise common sense at all times.
Part I: General Safety Rules Safety for Children and Pets WARNING Tragic accidents can occur if the operator is not alert to the presence of children and pets. Children are often attracted to the machine and the activity. Never assume that children will remain where you last saw them. Always follow these precautions: A. Keep children and pets at least 50 feet from the working area and ensure they are under the watchful care of a responsible adult. B.
Part I: General Safety Rules K. Stay alert for hidden hazards or traffic. L. Keep all nuts and bolts tight and keep the equipment in good operating condition. M. Be safety conscious and dress appropriately when operating. Always wear substantial footwear and a hard hat in relevant areas. N. Exercise extreme caution with the controls when working on steep or slippery surfaces. Especially, when people are near to the working area. A Note to All Users List of warnings and cautions cannot be all-inclusive.
Part II: Familiar with the BIG DUMP PART II: Familiar with the BIG DUMP It may be helpful to familiarize yourself with the controls and features of the BIG DUMP. If you have any question, please contact DK2POWER. TECHNICAL SPECIFICATIONS Power Load capacity Total Working time Charging time Power Capacity showing 48V/20AH/1000W Electric 1100 LBS 4-7 Hours 5-6hours Yes Speed Reverse Gear Front wheel 0-3 MPH YES 16*6.
Part III: Operating the BIG DUMP PART III: Operating the BIG DUMP It may be helpful to better familiarize yourself with the features of your machine before beginning the steps outlined in this chapter. WARNING A. Read and understand all instructions, safety precautions, and/or warnings listed in “PART I: General Safety Rules” before operating the machine. If any doubt or question arises about the correct or safe method of performing anything found in this manual, please contact DK2POWER. B.
Part III: Operating the BIG DUMP Dumping: 1. Stop the machine. 2. Set the parking brake 3. On the left handlebar press the switch up or down to raise and lower the bucket or the carry-all.
Part IV: Maintaining the BIG DUMP PART IV: Maintaining the BIG DUMP Regular maintenance is the way to ensure the best performance and long life of your machine. Please refer to this manual for maintenance procedures. WARNING 1. Before performing any maintenance procedure or inspection, stop the motor. 2. To prevent accidental movement of the machine, always turn the ON/OFF switch to OFF and disconnect the battery plug whenever the BIG DUMP is not in use. The control indicator light will turn off. 3.
Part V: Parts List 10
Part V: Parts List 13
