Pressu re Wash ers VERSA 100 VERSA 100C PN 09043X PN 09043D VERSA 200C PN 09041E PN 09041C (S.S.
LIMITED WARRANTY At DELCO® CLEANING SYSTEMS, we distribute top quality industrial / commercial / personal pressure washers that are designed for heavy-duty use, maximum reliability, durability, and long life. Our pressure washers are built for all duty applications and steady use due to higher quality levels. The manufacturer of this product agrees to repair or replace designated parts that prove defective within the warranty period of one (1) year listed in the chart.
LIMITED WARRANTY (cont) Parts / Components High Pressure Pumps Warranty Period and Details Five (5) year limited manufactuer warranty on pump workmanship and defects in material. Lifetime on forged brass manifold. Warranty does not apply to failures on other pump parts due to: • Freight damage • Freeze damage • Damage caused by parts or accessories not obtained from / or approved by Delco • Normal wear of moving parts or components affected by moving parts.
Table of Contents Operator Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 6 Introduction and Machine Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Machine Operation Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OPERATOR SAFETY INSTRUCTIONS WARNING AVERTISSEMENT ADVERTENCIA DANGER means: Severe bodily injury or death can occur to you or other personnel if the DANGER statements found on your machine or in your Owner's Manual are ignored or are not adhered to. Read and observe all DANGER statements found in your Owner's Manual and on your machine.
DANGER: Filling a machine with fuel in an explosive or poorly-ventilated area can cause an explosion. Only fill the fuel tank in an open area. Do not fill the tank near open flames or while the unit is running. Do not smoke while filling the tank. Do not over-fill the tank. Wipe up any spills. Tighten the cap on the tank when finished. Use kerosene, or #1 or #2 diesel as a fuel only. Do not use K-1 kerosene.
CAUTION: Maintenance and repairs performed by unauthorized personnel will void your warranty. Servicing of this unit must always be referred to an authorized Delco distributor. CAUTION: Electrical damage can occur if the machine is exposed to direct and/or over spray. Always point the wand toward the object being cleaned. CAUTION: Using an extension cord with your pressure washer will result in a voltage drop and loss of power. Use of an extension cord is not recommended.
OPERATING INSTRUCTIONS . NOTE: Following delivery of your Delco pressure washer, inspect the unit for shipping damage and follow these directions: 1. Read all DANGER, WARNING, and CAUTION labels. Read the Owner's Manual that came with your machine before attempting to operate the pressure washer. 2. Fill the fuel tank with kerosene, or #1 or #2 diesel. Do not use K-1 kerosene. 3. Locate the unit in a convenient location. 4. Securely fasten the pressure hose connections. 5.
OPERATING INSTRUCTIONS - Cont'd 19. Point the wand towards the object to be cleaned and proceed with cleaning. 20. For chemically enhanced cleaning follow this procedure: 1. Open the metering valve. 2. Turn the control switch to position one (I) "cold water wash". While pointing the wand toward the floor, squeeze the trigger on the gun and allow air to purge from the system. Check the system for leaks. 3. Dial the metering valve to the desired chemical concentration. 4.
MAINTENANCE - Cont'd. 5. If the oil is below the notch, add SAE 30 weight, non-detergent oil. 6. Put the dipstick back into the hole. 7. Turn the plug clockwise until it stops. NOTE: Change the oil after the first 50 hours of use and then after every 500 hours of use. SAE 30 weight oil must be used. Freeze-Up Prevention To prevent freeze-up follow these instructions: 1. Drain the float tank. 2. Remove the spray nozzle from the wand. 3. Mix antifreeze concentrate and water in a large container.
HOW TO CORRECT PROBLEMS IN THE MACHINE Problem Cause Action The motor will not start Power cord may not be connected. Switch may not be turned "ON". Ground fault circuit interrupter did not reset. The power cord may be connected to a dead outlet. May have a defective motor, GFCI, or switch. The thermal overload switch tripped. Connect the power cord. Turn switch to "ON". Reset the ground fault circuit interrupter. Contact a licensed electrician.
Problem Cause Action Oil is dripping. The oil seal is worn. The spray nozzle is not the correct size. Contact an authorized Delco service person. Install a new nozzle. The pressure is too high and is released at the unloader or pressure relief valve. The coils are limed. The spray nozzle is obstructed. Delime the coils. Clean the nozzle. The machine does not pick up the cleaning solution. The metering valve is leaking air. The screen on the chemical line is dirty.
Delco Versa 100-200/Versa 100C-200C Wiring Diagram Delco Versa 100-200 and Versa 100C-200C Electrode Check Schematic Versa 100/100C Owner's Manual Page 13
Delco Versa 100/ Versa 100C-200C Pump Drawing Page 14 Versa 100/100C Owner's Manual
Delco Versa 100 /100C-200C Pump Parts List Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 Part No. 192323 198296 197070 198092 192322 198091 196647 191615 193895 193900 197066 196644 199586 198209 191328 199580 192387 199581 192374 195101 197076 197627 199589 196646 Description Cover - Crankcase Seal - Oil Bearing Plug, Oil Screw - M6 x 14 Uni Soc Hd. Cap Cover - Crankcase Screw M6 x 10 Uni Hex Hd.
Page 16 Versa 100/100C Owner's Manual
Versa 100/100C Owner's Manual Page 17
Delco Versa 100C Unloader Valve Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 REF. Part No. 196762 198067 199600 196763 56857A 56610A Kit #59 195459 Description Only a kit item - see below* " " " " " " " " " " " " O ring 5.28 x 1.78 (see below*) Screw - adjustment Star washer O ring 13.95 x 2.62 (see below*) O ring ( in kit #59) Only a kit item - see below* Only a kit item - see below* O ring 20.35 x 1.
Delco Versa 100C 59420A Adjustable Unloader Valve 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 REF. 196762 198067 199600 196763 56857A 56610A Kit #59 195459 Only a kit item - see below* " " " " " " " " " " " " O ring 5.28 x 1.78 (see below*) Screw - adjustment Star washer O ring 13.95 x 2.62 (see below*) O ring ( in kit #59) Only a kit item - see below* Only a kit item - see below* O ring 20.35 x 1.
Delco Versa 100/100C (Painted Models) Machine Assembly Drawing Page 20 Versa 100/100C Owner's Manual
45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 # P/N 29645A 29644A x 61645A 194803 699202 170219 198072 170106 199067 191519 198560 195593 170906 930093 195589 77030A 52052A 77028A 68331A 85811A 980652 194208 194204 29576A 194219 85813A 199004 50429A 60140A 59958A 170875 170818 170940 170854 192501 170927 193944 68369A 195693 720271 722021 170066 170086 170034 170034 192116 192116 199081 193947 197051 196180 56255A 196180 196179 196155 52041A 77031A 74102A 72123A 74105A 198450 170910 66370A 170974 170974
Delco Versa 100/100C Painted Machine Assembly Parts List Versa 100C Versa 100 Ref.
Delco Versa 100/Versa 100C Burner Drawing & Parts List Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 A B C D E F 14 15 16 17 18 19 20 Part No.
Delco Versa 100C-200C Stainless Steel Machine Assembly Drawing Page 24 Versa 100/100C Owner's Manual
Delco Versa 100C-200C Stainless Steel Machine Assembly Parts List Ref.
Delco Versa 100C-200C Stainless Steel Parts List Ref. 129 130 131 132 134 135 136 137 138 140 141 142 143 144 145 146 147 148 149 150 Page 26 # P/N 170486 170252 195101 194402 56329A 170221 198433 80501A 170014 170850 170004 199027 57239A 197283 191773 191679 194117 29575A 77024A 77039B Description Plug, Pipe 1/4 Blk. Tee, Pipe 1/4 Galv. Key Hosebarb 5/8 x 3/8 (w/ 7/32" OR) Nipple 1/4 x 21/2 Sch. 40 Nipple, Pipe 1/2 x 4 Galv.
Delco Versa 100/100C-200C Fuel Filter Components (Optional filter shown) Versa 100/100C Owner's Manual Page 27
1111 E. Lake Francis Dr.