Equipment Description Table of Contents Equipment Serialization. ooo icicle # Features and Controls ooh iii 4 Operational ©. oa & BLANCMANGE, © (corgi sans Conn coe 48 BE PPI £1 FOCAL Compliance Statement LL... LL. i5 Troutdeshooting/Specificalions LL... 16 WEIGHTY oe eae 17 Register Your Product To ensure prompt and complete warranty coverage, register your product online al www Craftsman preregistration.
Equipment Description Engine identification Cif Fill Candlestick. if Drain Lug Grounding Fastener Dual Gap Spark Arrested Muffler Exhaust Fuel Valve Chalk Lever Re coll Starter Air Cleaner Identification Label Air Cleaner — Filters engine intake air, Identification Label — Provides model and serial number of Choke Lover — Used when starting old engine, gar Engine Identification — Provides motel, type and code of engine, Cif Dean Plug — Drain angle oll hare. Fug! Cap ~~ Ads unpunished Tua) here.
Features and Controls Com para the illustrations with your generator to familiarize yourself with the locations of various controls and product Warnings, Fuel is flammable which could souse burs resting in death or serious injury. «Tyre Angie off and fat it cool at least 2 I H minutes before refueling, not 1 fuel above bottom Hip, ” = Aver add fuel to 8 hot or running generator El combustible ns inflammable, Io gue podiatry causer masquerades gus ascension x occasional graves o Ja musher.
Operation Operation Step 1: Safe Location Before starting the portable generator there are two actually important safety concerns regarding carbon monoxide poisoning and fire that must be addressed.
Operation Location tv Reduce the Risk of Fire WARNING! Exhaust heat/gases could ignite combustibles, structures or damage fuel tank Y causing @ Hire, resulting In death or seniors Injury. « Portable generator must be af feast from any structure, overhang, trees, shrubs, or vegetation over 12 in, (30.5 cm) in height, Exhaust J sb 5 (18m) fin, pt 515 41.5 m) min, Immense 3 {6.
Operation Step 2: Oi and Fuel 1. Move generator outdoors 10 a flat, level surface. 2. Clean area around off fill and remove off Hil cap/ dipstick. 3. Using ofl funnel (optional), slowly pour contends of provided oil bottle into off Till upswing to the full mark on dipstick, NOTICE Pause Yo peril ofl to sere. Wipe dipstick clean each them ail level Is checked. DO NOT overfill, 4, Replace and fully tighten oft fill cap/dipstick.
Operation Step 3: Generator Start Up Disconnect all electrical loads from the generator. Use the following start instructions: 1. Make sure unit is outdoors on @ ewe! surface. ROTE Fallows fo parade the unit on a level surface may cause the anti to shut down, 2. Tum the fuel valve to the on (1) position, Fuel Valve 3. Push choke lever to choke {IW} position. Choke Lever 5. Grasp recoil handle and pull Slavs whit resistance is fiat. Then pull rapid to start engine, &.
Operation 120 Volt AD, 20 Amp, BFC! Duplex Receptacles Use each receptacle to operate 120 Volt AC, single-phase, 60 Hz chimerical loads requiring up fo 2,400 Walls (2.4 &W) ab 20 Amps of current. Ground Fault Protection The duplex receptacles are equipped with Ground Fault Circlet Interrupter (RFC protection.
Operation Generator Capacity To make sure your generator can supply enough reaping walls and starting wails for the items you will power at the same time, follow these three simple steps: 1. Select the items you wilt power al the same time. See following fist for typical swelters.
Maintenance Maintenance Maintenance Schedule Follow the hourly or calendar intervals, whichever occurs first, Nero frequent service Is required wham operating in adverse conditions noted below, Fit Hone ® Change engine oll # Clean debris « Check engine ofl elev + Clean/Replace air filter’ Fume 100 Hours of every season = Change oil! = Changeability spark plug & Clean spark arrested + Service fuel valve + Service more often under dirty or dusty conditions, © Sew any authorized dealer Tir sir vine, General Re
Engine Maintenance Olt Recommendations We recommend the use of Briggs & Station Warranty Certified oils for heat performance. Other high-quality detergent oils are acceptable i classified for services SF or higher. Do not use special additives. See Common Service Parts. Liquidator temperatures determine the proper oil viscosity for the engine. Use the chard to select the best viscosity for the dour temperature range expected.
Maintenance Service Alr Filter 7 WARNING! Fuel and its vapors are extremely [i Flammable which souls cause bums or fire i resulting io death or serious injury. « Diy not start and run engine with air filler removed. Your engine will not run properly and may be damaged if yo yun i with a diy alr filter. Clean or replace more often if operating under dusty or dirty conditions, i. Unclasp latches that hold on the cover, Latches 2. Remove cover and foam alr filler 3.
Storage Storage If storing the unit for more than 30 days, use the following guidelines to prepare it for storage. tong Term Storage Instructions 1. Clean the generator as outlined in Cleaning. 2. Change engine ofl while engine Is still warm, drain off farm crankcase. Refill with recommended grade. See Changing Angle Ol 3. Treat or drain fused from generator as fuel can become stale when stored over 30 days.
Troubleshooting/Specifications Problem Gauss Correction 1. Une of the cigarillo breakers 1s open. 1. Reset circuit breaker. 2. Poor connection or defective cord sel i? Engine is rowing, bad no 80 cuppa is Co 2. Check and repair . available. 3. Connected device is bad, 3. Correct another device that is in good condition, A, GF tipped, 4, Reese CLOG Angle rns well at no-dad ut “begs | 1. Generator is overloaded. 1. See Generator Capacity. down” when loads are connected. 1.