OWNERS MANUAL MODEL NO. 919.156730 919.156830 CRAFTSMAN PERMANENTLY LUBRICATED AIR COMPRESSOR Record in the spaces provided° (1) The model number which can be found on the label on the back of the shroud° (2) The code number which can be found on the foil label on the back of the air tank.
TABLE OF CONTENTS WARRANTY SAFETY Page 3 ........................................................ GUIDEUNES WARNING CHART SPECIFICATION GLOSSARY GENERAL CHART ....................................... 5 5 INFORMATION .................................................. OF OPERATION INSTRUCTIONS 6 ................................. 6 ............................................. 7 Tools Needed for Assembly .........................................
FULL ONE YEAR WARRANTY AIR COMPRESSORS If this air compressor fails due to a defect in material or workmanship within one year from the date of purchase, RETURN IT TO THE NEAREST SEARS SERVICE CENTER/DEPARTMENT THROUGHOUT THE UNITED STATES AND SEARS WILL REPAIR iT, FREE OF CHARGE. if this air compressor is used for commercial or rental purposes, the warranty will apply for ninety days from the date of purchase.
WHAT TO LOOK FOR WHAT COULD HAPPEN HOW TO PREVENT IT Air Tank Modifications to the air compressor can cause the air tank to rupture or explode, Do not adjust, remove or tamper with the safety valve or pressure switch If safety valve or pressure switch replacement is necessary, a part with the same rating must be used, Never use a motor with a higher horsepower rating than the one supplied, Never replace the air tank with a different model or a larger tank Compressed Air Changing the air tank will cau
SPECIFICATION CHART Model No. Horsepower Displacement CFM Bore Stroke Voltage-Single Phase Minimum Branch Circuit Requirement **Fuse Type Air Tank Capacity Approximate Cut-in Pressure Approximate Cut-out Pressure SCFM @ 40 psig SCFM @ 90 psig 919:156730 3 11_8 2%" 1.35" 120/240 "15 amps "Fusetron .... Type T*** 15 gaL 80 I00 8.5 70 919.156830 3 11.8 23/8 1..35" 120/240 15 *amps Fusetron" Type T*** 15 gaL A..SM.E.
GENERAL INFORiViATION You have purchased an air compressor unit consisting of a 1 cylinder; single-stage air' compressor pump, an air tank, air hose, wheels, handles, and associated controts_ You will also find an air chuck. brushes, sandblasters, or inflatingtires and plastic toys, spraying weed killers, insecticides, etc.. This model is not equipped with a pressure regulator:.
ASSEMBLY INSTRUCTIONS Tools Needed for Assembly • pipe thread sealant (not included) • a %s" socket or open end wrench for attaching the wheels, wheel plates and hose adapter • a 7/1_"open end wrench for attaching the air pressure gauge • an adjustable wrench for attaching the shut-off valve • a %" open end wrench to tighten handle screws, Installing Wheels, Wheel Plates, Handles, Rubber Foot Strip 2.
Grounding instructions Outlet Plug IMPROPER GROUNDING CAN RESULT IN ELECTRICAL SHOCK_ IN THE EVENT OF A SHORT CIRCUIT, GROUNDING REDUCES THE RISK OF SHOCK BY PROVIDING AN ESCAPE WIRE FOR THE ELECTRIC CURRENT.
4oTurntheOFF/AUTO leverto"AUTO"andallowtank pressure tobuild°Motorwillstopwhentankpressure reaches"cut-out"pressure, 5, Opentheshut-offvalve° WATER WILL CONDENSE IN THE AIR TANK. IF NOT DRAINED, WATER WILL CORRODE AND WEAKEN THE AIR TANK CAUSING A RISK OF AIR TANK RUPTURE. 6.Alwaysoperatetheaircompressor in well-ventilated areas; free of gasoline or other solvent vapors. Do not operate the compressor near the spray area.
STORAGE Before you store the air compressor, make sure you do the following: 2. Protect the electrical cord and air hose from damage (such as being stepped on or run over) Wind them loosely around the compressor handle,, 1, Review the "Maintenance" section on the preceeding pages and perform maintenance as necessary.
TROUBLESHOOTING GUIDE (Continued) PROBLEM CAUSE CORRECTION Air leak from Safety Valve,, Possible defect in Safety Valve. Operate safety valve manually by pulling on ring, if valve still leaks, it should be replaced Knocking Noise, Defective Check Valve. Remove and clean or replace, Compressor is not supplying enough air to operate accessories Prolonged excessive use of air. Decrease amount of air usage, Compressor is not Iarge enough for air requirement Check the accessory air requirement.
AiR COMPRESSOR DIAGRAM SEE PAGE 14AND 15 FOR COMPRESSOR/MOTOR PARTS BREAKDOWN. 44 ] 45 46 83940 31 3O 28 .
PARTS LHST KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 3O 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 PART NUMBER LA-2256 LA-2255 LA-1779 CAC-1140 LA-2089 LA-2178 CAC-1121 SS-655-ZN CAC-1080 LA-2252 CAC-4317 CAC-1099 SSF=505 CAC-1098 TA-4186 TA,o4187 STD541437 CAC-4313 CAC-6O LA-1811-1 SUDL-6-1 LA_1978 CAC-1087 H-2099 CAC-4284 CAC-4290 SSP-7813 CAC-333-1 SSN-8001 SSP-7821 CAC-1120 CAC-1155 C-GA-345 DESCRIPTION Not used Model No.
COMPRESSOR PUMP DIAGRAM 6O 61 __ ..
PARTS LIST KEY NO.
OWNERS MANUAL SERVICE MODEL NO. 919.156730 919.