Operator's Manual ® 11/4- 21/2" Length COIL UTILITY NAILER Model No. 351.182140 CAUTION: • • • • • Read and follow all Safety Rules and Operating Instructions before First Use of this Product. Keep this manual with tool. Sears, Roebuck and Co., Hoffman www.sears.com/craftsman 21662.00 Draft (01/12/04) Estates, IL 60179 U.S.A.
Warranty ......................................... 2 Safety Rules ...................................... 2 Operation ...................................... Maintenance ..................................... 3-6 6 Troubleshooting ................................... Parts Illustration and List .......................... 7 8-9 EspaSol ......................................
° DESCRIPTION The Craftsman Coil Utility Nailer drives full head nails from 1_/4"to 2W' long. Magazine will hold a coil of 400 wire collated nails. Safety feature disables tool unless contact trip is pressed against workpiece. Sequential trigger switch allows selection of rapid-fire or single-fire mode. Contact trip can be adjusted for setting nail depth. Plastic protector on the end of contact trip prevents marring of workpiece. Air deflector can be adjusted to any direction.
° The nail holder must be set to the length of the nails being used. Twist the spindle of the nail holder and position nail holder up or down so that the edge of the nail holder is aligned with the correct size indicator on the inside of the magazine. Twist spindle to lock nail holder in place (see Figure 3). Nail Heads Must be Positioned in This Slot CAUTION: Failure to adjust nail holder height may result in damage to advance mechanism. ....
• • The tool is equipped with to rapid-fire or single-fire switch is set to single-fire second fastener until the pulled again. CONTACT a rotating switch that can be set mode (see Figure 7). When the mode, the tool will not drive a trigger is fully released and When the switch is rotated to rapid-fire drive fasteners continuously.
COLD WEATHER OPERATION CAUTION: Do not store in cold environment. Frost or ice could form inside tool affecting operation and damaging tool. Use a cold temperature lubricant, such as ethylene glycol, when operating tool in freezing temperatures. Refer to Figure 11. LUBRICATION Lubricate tool daily with quality air tool oil. If no air line lubricator is used, place five or six drops of oil into air inlet cap (Figure 11, Key No. 27) of tool everyday.
SYMPTOM POSSIBLE CAUSE(S) CORRECTIVE ACTION Trigger cap leaks air 1. O-ring damaged 2. O-rings damaged 1. Check and replace damaged O-ring (Fig. 11, No. 30) 2. Check and replace damaged O-rings (Fig. 11, Nos. 30, 32, 34, 37, 56 and 105) Cap leaks air 1. Cap bolts loose 2. Damaged cap gasket 1. Tighten bolts (Fig. 11, No. 5) 2. Check and replace damaged gasket (Fig. 11, No. 9) Nose leaks air 1. Damaged nose O-ring 2. Damaged bumper 3. Nose bolts loose 1.
Model 351.182140 Figure 11 - Replacement Parts Illustration ./" // For Coil Utility Nailer 18 0 _ 19 27 23 26 \ 25 _1Ol 44 4o! 45 99 "101 102 88 / 84 / 89 98
KEY NO. PART NO. DESCRIPTION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 STD870512 21587.00 21588.00 21589.00 STD870525 STD852005 21590.00 01210.00 21591.00 21592.00 21593.00 16249.00 21594.00 21595.00 21596.00 21597.00 07476.00 21598.00 04360.00 21599.00 08775.00 21600.00 21601.00 21602.00 N/A 07426.00 21044.00 21603.00 21604.00 16767.00 21605.00 06136.00 21606.00 04327.00 21607.00 21608.
lth - 272" de Iongitud CLAVADORA DE CARRETE DE USO PRACTICO • Modelo No. 351 •182140 • permanentes rigidas, impreso o estampado • ............................................. y Lista de Partes ............................
• Verifique con frecuencia el funcionamiento del disparo por contacto. Nunca utilice la herramienta si el disparo por con- LINEA Consulte tacto, el gatillo o los resortes no funcionan, faltan o estan daffados. No altere ni extraiga el disparo por contacto, el gatiIio o los resortes. Nunca utilice una herramienta que tenga una fuga de aire, partes da_adas o que falten, o que necesite ser reparada.
Conector macho \ Conector hembra Figura 1 - Linea de Abastecimiento de Aire Sujetador de Clavos CARGA Consulte las Figuras 2 a la 6 (paginas ADVERTENClA: Desconecte to de aire. No cargue la herramienta Figura 3 - Ajuste del Sujetador de Clavos a la Longitud los Clavos 12 y 13). la herramienta del abastecimien- hasta que este listo para • usarla. No oprima el gatillo o presione el disparo pot contacto mientras carga la herramienta.
Cierre primero con cuidado la tapa del dep6sito. Luego cierre la puerta y asegLirela en su posici6n con el pestillo. Aseg@ese que la lengQeta en la puerta sostenga la tapa del dep6sito en su posici6n (vease la Figura 6). Figura 7 - Presione y Gire el Interruptor para Seleccionar el Modo de Operacion Figura 6 - Cierre la Tapa del Deposito y la Puerta OPERACION Consulte OPERACION DE CLAVADO las Figuras 7 a la 10 (paginas • 13 y 14).
AJUSTE El disparo DEL DISPARO por contacto POR CONTACTO puede ajustarse OPERAClON hacia arriba EN CLIMAS PRECAUClON: o hacia FRIOS No Io almacene en un ambiente frfo. La escar- abajo para variar la profundidad del sujetador en la pieza de trabajo. Para ajustarlo, gire la perilla de control de profundidad cha o el hielo puede formarse en el interior de la herramienta afectando la operaci6n y ocasionando dahos a la unidad.
StNTOMA CAUSA(S) POSIBLE(S) MEDIDAS CORRECTIVAS Se fuga aire por la tapa del gatillo 1. Anillo O daflado 2. Anillos O daflados 1. Revise y cambie los anillos O dafiados (Fig. 11, No. 30) 2. Revise y cambie los anillos O dafiados (Fig. 11, Nos. 30, 32, 34, 37, 56 y 105) Se fuga aire por la tapa 1. Los pemos de la tapa estdm sueltos 2. Empaquetadura de la tapa dafiada 1. Apriete los pernos (Fig. 11, No. 5) 2. Revise y cambie la empaquetadura Se fuga aire por la oreja 1.
iiiiiiiiiiiiiiiij:_ iiiiiiiiiiiiiiiii:i iiiiiiiiiiiiiiiill iiiiiiiiiiiiiiiill Your Home For repair-in your home-of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! iiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiii!:_ iiiiiiiiiiiiiiiii:i For the replacement parts, accessories and owner's manuals that you need to do-it-yourself.
