MODEL NO 298.586191 » owner's responsibility » maintenance + operation | « trouble shooting » replacement parts ‘Publication No. 1967-45560-205 E73) GAME FISHER' OUTBOARD MOTOR 3.0 H.P.
TABLE oF CONTENTS SPECIFICATIONS OWNER'S RESPONSIBILITY | . MAINTENANCE LUBRICATION GEAR HOUSING MUFFLER INSPECTION. . PROLONGED STORAGE OPERATIONS NEW. AUTOMATIC CLUTCH | : BOAT MOUNTING 0... STEERING ADJUSTMENT ve 2-CYCLE ENGINE FUEL MIXTURE + STARTING PROCEDURES STOPPING. PROCEDURES FLOODING CARBURETOR ADJUSTMENTS PROPELLER SHEAR. PIN | IGNITION SYSTEM REMOVING ‘MOTOR, FROM", BOAT | SALT WATER OPERATIONS [SPN TROUBLE SHOOTING CHECK LIST REPLACEMENT PARTS. ,, i... ORDERING PROCEDURES .
IMPORTANT Owner's Responsibility and Copycatting Safety Check List BE SURE TO READ AND DO THE FOLLOWING BEFORE OPERATING. YOUR: OUTBOARD MOTOR SAFETY CHECK LIST 1. Learn and observe: the boating laws of the U.S. Coat: Guard, stat, octal authoritarians, 2. 1.5. Coast Guard {equations roars tha following: a. Provide an approved lilo west, type 1, 2 6 impersonate Flotation Device for each peso in boat. {Encouraged passengers 10 wear them.
MAINTENANCE 2. 2 LUBRICATION. GEAR HOUSING The Gear Housing has been prefabricated at the factory; however, the grease love! sharia be checked as follows using SAE 90 out: board motor grease. (See Figure 2), £13 Prior to initial operating. (2 Afr first tour (4) hours of use, 13} Recheck slier every fifty (50) hours funnily me. Replace with new lubricant ot the dnd of your Outboard motor season.
OPERATION WRONG BOW UP 5. BOAT MOUNTING A. Mount the motor 0A the cent of the bail canto (teen). (See Figure 41. SHAG Bow DOWN CAUTION Hand tighten ransomer bracket snd clamp stud Fondles simultaneous, Do not use a wench or any other device that would course Damage to brackets, Occasionally check 1 be sure lamp stud handles on transom mounting bracket are tight. (Sue Figure 5h, b. To obtain the best performance Tom bur Outboard, the following boat if manse was creations are recommended: (See Fido 4).
“OPERATION 8. CYCLE ENGINE FUEL MIXTURE Use 33000 grade of regular gasoline, {Sea mixing table boffo) : CAUTION Always use BIA certified TC-W off. in the SOY ratio. Failures to $0 10 may result in.
(OPERATION WARNING in case of an Emergency, the. sine an be stopped by moving the Choke Lever to Full Hake Position, 1 the motor will not be operated fora period of teems, removed from the boat, tilted Gp, we recommend the following. practice ‘to prevent spillage from tha carburetor threat and bow! and to prevent gem formations in the carburetor during Garage; i) T. Low fuel shutoff vows and air | | EWES vent screw at fuel filler cap, PROPELLER 2.
OPERATION 14, FLYWHEEL MAGNETO IGNITION SYSTEM WITH TRANSISTORIZED ELECTRONIC MONITOR a. The magneto ignition system consists of the following component parch: Flywheel, Tran militarized Electronic ignition and ignition Colt, B. lamest the following if engine falls or iy hard to start: Be 11) Spark plug as alien #8 necessary, sure spark plug gap setting is 025" 0.6mm. (2) Gasoline fuel supply snd fuse shut. off valve should be tea, © 13} Carburetor being starved of fuel, ©.
TROUBLE SHOOTING CHECK LIST ¥ Ses) ESE fay .
YT JET OUTBOARD MOTOR 3.0 H.P. MODEL NO. 298.586191 ERIE] | MANUAL For quick service or repair, take your Outboard Motor to any Sears Service Unit throughout the U8. and Canada. Each Service Unit is staffed by trained technicians, using Sears approved parts and repair procedures 10 ensure that we meet our pledge to service what we sell.