Blaze Drop-In Single Side Burner Manual
Table Of Contents
- USE & CARE GUIDE
- ATTENTION:
- INSTALLER: PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER.
- I. Burner Specifications 4
- II. General Safety and Installation Warnings 5-8
- i. Location of Appliance 8-10
- III. Electrical Safety and Installation Warnings 11-12
- IV. Gas Safety and Installation Warnings 12-13
- i. Checking for Gas Leaks 14-16
- ii. Unpacking Unit 16
- V. Gas Connections 17
- i. Natural Gas Requirements 17
- ii. Liquid Propane Gas and Tank Requirements 17-18
- iii. Transporting and Storing LP Gas 18-19
- VI. Installing the Appliance in a BBQ Island 20
- i. Outdoor Kitchen Ventilation 21-23
- ii. Building BBQ Specifications + Instruction Diagrams 23-24
- VII. First Time Operation 25
- i. Lighting the Appliance 25-26
- ii. Manually Lighting the Appliance 26
- iii. Flame Adjustment 26-27
- VIII. Cleaning your Appliance 27-28
- NOTE: ALWAYS have equipment measured by Contractor before beginning any project.
- Single Side Burner Cut Out
- Do not attempt to heat unopened containers on the burner as pressure may build up and cause the container to explode.
- Never use charcoal or any other solid fuel in the appliance.
- Never cook without the drip pan in place.
- Never operate this appliance while under the influence of alcohol or drugs.
- Location of Appliance
- Gas Safety and Installation Warnings
- IMPORTANT: Never connect the appliance to an unregulated gas supply.
- If there are local codes that apply to outdoor burners, you will have to conform to them. Installation must conform with local codes or in the absence of local codes, to the National Fuel Gas Code, ANSI Z223.1/NFPA 54 and Natural Gas Installation Code...
- Leak Testing
- NEVER USE AN OPEN FLAME TO CHECK FOR LEAKS.
- Natural Gas Requirements
- Liquid Propane (LP) Gas and Tank Requirements
- Installing the Appliance in a BBQ Island
- FIRST TIME OPERATION
- Cleaning Your Appliance
- Fuel Conversion
- Blaze Outdoor Products, Warranty Registration, 6620 Greenwell Springs Rd.
- Baton Rouge, LA 70805
BLAZE Instructional Book
Page | 8
Do not attempt to heat unopened containers on the burner as pressure may build up and
cause the container to explode.
Never use charcoal or any other solid fuel in the appliance.
Never cook without the drip pan in place.
Never operate this appliance while under the influence of alcohol or drugs.
Location of Appliance
Most importantly, this is an outdoor appliance. Ensure your appliance is positioned safely away from
anything that can catch fire. Under no circumstance is this appliance to be used indoors. This includes
garages or any other enclosed area. This outdoor cooking gas appliance is not approved to be installed in
or on any recreational vehicles and /or boats. BLAZE burners are for single family/residential use only.
When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths
and keeping any gas supply lines as short as possible.
Do not store combustible materials,
gasoline or flammable liquids or vapors around the appliance.
This BLAZE burner must be located outdoors only. As with any gas appliance, harmful carbon
monoxide is produced during the combustion process that should not be allowed to accumulate in a
confined space.
Please note since hot air rises above the BLAZE burner while in operation, covered
locations should be avoided. Do not locate the BLAZE burner where an overhang or awning may cover
it.
FOR YOUR SAFETY
NOTE: Check with City and Fire department for Local Building Codes. A Permit may be
required for outdoor kitchen construction.