SKYFORT II SWING SET Model # 6113 rev. C Owner's Manual & Assembly Instructions MANUFACTURED BY: Backyard Discovery 3305 Airport Drive Pittsburg, KS 66762 800-856-4445 average 2 person assembly time assembly time may vary based on skill level For the most up to date assembly manual, to register your set, or to order replacement parts please visit www.backyarddiscovery.com SAVE THIS ASSEMBLY MANUAL FOR FUTURE REFERENCE IN THE EVENT THAT YOU NEED TO ORDER REPLACEMENT PARTS.
With Go Configure, we bring you 18 years of experience right to your doorstep. We service a wide array of indoor and outdoor recreation products that most consumers don’t have the time or ability to deliver & install themselves.
STOP PARE Missing A Part? CALL US BEFORE GOING BACK TO THE STORE! The store where you made your purchase does not stock parts for this item. If you have assembly questions or if you need parts, whether they are missing or damaged Call Toll-Free Help Line or visit www.EDFN\DUGGLVFRYHU\.
Owner’s Manual Play Set Dear Customer: Please read entire booklet completely before beginning the assembly process. Equipment is recommended for use by children 3 to 10 years of age. Structures are not intended for public use. The Company does not warranty any of its residential structures subjected to commercial use such as: Daycare, Preschool, Nursery School, Recreational Park, or any similar Commercial Application.
Owner’s Manual Play Set Rev01/12/18 5
Owner’s Manual Play Set Please refer to the Assembly section of the Assembly Manual for Maximum Fall Height Positioning Your Playcenter 1. The Playcenter is designed to be installed on a level surface by an Adult with an Adult helper. Place in a flat area of your yard to minimize ground preparation. 2. Choose a level location for the equipment. This can reduce the likelihood of the play set tipping over and loose-fill surfacing material washing away during heavy rains. 3.
Owner’s Manual Play Set The following chart explains the fall height in feet from which a life threatening head injury would not be expected Critical Heights in feet (m) of Tested Materials Material Uncompressed Depth Compressed Depth 6" (152mm) 9" (228mm) 12" (304mm) to 9" (228mm) Wood Chips 7' (2.13m) 10' (3.05m) 11' (3.35m) 10' (3.05m) Double-Shredded bark mulch 6' (1.83m) 10' (3.05m) 11' (3.35m) 7' (2.13m) Engineered Wood Fibers 6' (1.83m) 7' (2.13m) >12' (3.66m) 6' (1.83m) Fine Sand 5' (1.52m) 5' (1.
Owner’s Manual Play Set 18. Verify that any suspended climbing ropes, chain, or cable are secured at both ends and that they cannot be looped back on it. 19. Instruct children not to attach items to the playground equipment that are not specifically designed for use with the equipment, such as, but not limited to, jump ropes, clothesline, pet leashes, cables and chain as they may cause a strangulation hazard. 20. Instruct children to never wrap their legs around swing chain. 21.
Owner’s Manual Play Set Additional Maintenance: • Check the swing beam and hardware every two weeks due to wood expansion and contraction. It is particularly important that this procedure be followed at the beginning of each season. • Inspect wood parts monthly. The grain of the wood sometimes will lift in the dry season causing splinters to appear. Light sand may be necessary to maintain a safe playing environment.
Owner’s Manual Play Set APPENDIX A Information on Playground Surfacing Materials: The following information is from the United States Consumer Product Safety Commission’s Information Sheet for playground surfacing material; also see the following website for additional information: www.cpsc.gov/cpscpub/pubs/323.html. X3. SECTION 4 OF THE CONSUMER PRODUCT SAFETY COMMISSION’S OUTDOOR HOME PLAYGROUND SAFETY 9 HANDBOOK X3.
Play Set Assembly Manual FAQs: 1. Does the area for the playset need to be level? Yes. Backyard Discovery recommends the playset be positioned on a flat level area for maximum safety and durability. The stakes provided should be used to secure it firmly to the ground. 2. What size area is recommended for the playset? Backyard Discovery recommends at least a 6’ (six foot) perimeter around and above the playset for maximum safety. 3.
Tools Required for Installation: (These are the tools that are generally required for assembly of our outdoor products. These tools are not included with the outdoor product purchase.
Basic Setup Dimensions Place the set on level ground, not less than 6 ft [2 m] from any structure or obstruction such as a fence, garage, house, overhanging branches, laundry lines, or electrical wires. 33'-11 1/8" [10.3] 21'-11 1/8" [6.7] 6'-0" [1.8] 16'-9 1/8" [5.1] 28'-9 1/8" [8.8] 6'-0" [1.8] Safe Play Zone 12'-4" [3.8] General Information:
Parts Identification Wood Components (NOT TO SCALE) (1) A50 - SWING BEAM - W4L04660 3 3/8"x5 1/4"x89 1/2" (86x134x2274) (1) B1 - TOWER LEG - W4L04562 3"x3"x89 1/2" (76x76x2274) (1) B2 - TOWER LEG - W4L04561 3"x3"x89 1/2" (76x76x2274) (1) (1) (1) (1) B4 - TOWER LEG - W4L04568 3"x3"x59" (76x76x1500) B5 - BACK LEFT CLUB HOUSE CORNER - W4L04612 3"x3"x53 7/8" (76x76x1370) (1) (1) B3 - TOWER LEG - W4L04564 3"x3"x59" (76x76x1500) B6 - FRONT LEFT CLUB HOUSE CORNER - W4L04615 3"x3"x53 7/8" (76x76x137
Parts Identification Wood Components (NOT TO SCALE) (1) E50 - END SUPPORT - W100949 1 3/8"x3 3/8"x44 1/8" (36x86x1120) (2) E51 - ANGLE BRACE - W100948 1 3/8"x3 3/8"x88 3/4" (36x86x2254) (2) E77 - LEFT UPRIGHT - W4L11769 1 3/8"x3 3/8"x64 3/8" (36x86x1634) (1) (1) (2) E74 - MONKEY BAR RAIL - W102918 1 3/8"x3 3/8"x77 1/8" (36x86x1959) E78 - RIGHT UPRIGHT - W4L11768 1 3/8"x3 3/8"x64 3/8" (36x86x1634) E79 - MONKEY BAR UPRIGHT - W100995 1 3/8"x3 3/8"x88 1/8" (36x86x2237) (1) F1 - TELESCOPE MOUNTING
Parts Identification Wood Components (NOT TO SCALE) G6 - FLOOR RAIL - W4L11777 1"x5 1/4"x60 1/2" (24x134x1537) (1) (2) G7 - BOTTOM FLOOR RAIL - W4L11775 1"x5 1/4"x80" (24x134x2032) G50 - GROUND BOARD - W100947 1"x5 1/4"x86 3/4" (24x134x2202) (1) (1) H1 - WALL RAIL - W4L04620 1"x3 3/8"x80" (24x86x2032) (1) H2 - WALL RAIL - W4L04622 1"x3 3/8"x80" (24x86x2032) H3 - PICNIC TABLE RAIL - W4L04578 1"x3 3/8"x67 1/4" (24x86x1708) (1) H4 - ROOF SUPPORT RAIL - W4L04623 1"x3 3/8"x67 1/4" (24x86x1709) (2)
Parts Identification Wood Components (NOT TO SCALE) (4) H12 - ROOF RAFTER - W4L04640 1"x3 3/8"x50 3/8" (24x86x1278) H13 - CLUB HOUSE WALL RAIL - W4L04624 1"x3 3/8"x50 1/4" (24x86x1277) (1) (1) (4) H14 - SWING BEAM MOUNT - W4L04628 1"x3 3/8"x50 1/4" (24x86x1277) H15 - PICNIC TABLE SEAT - W4L04600 1"x3 3/8"x35 3/8" (24x86x897) (1) H16 - PICNIC TABLE SEAT RAIL - W4L04597 1"x3 3/8"x32" (24x86x812) (1) H17 - PICNIC TABLE SEAT RAIL - W4L04599 1"x3 3/8"x32" (24x86x812) (1) H18 - CLUB HOUSE WALL RAIL
Parts Identification Wood Components (NOT TO SCALE) H27 - PICNIC TABLE SUPPORT - W4L04574 1"x3 3/8"x28 5/8" (24x86x728) (1) (1) H28 - FRONT WALL RAIL - W4L11774 1"x3 3/8"x60 1/2" (24x86x1537) (2) H29 - CROWS NEST WALL RAIL - W4L11783 1"x3 3/8"x30 5/8" (24x86x778) (2) H30 - CROWS NEST WALL RAIL - W4L11782 1"x3 3/8"x29 7/8" (24x86x758) (2) H31 - CROWS NEST WALL RAIL - W4L11781 1"x3 3/8"x38 7/8" (24x86x988) H72 - ROCKWALL RAIL - W4L04677 1"x3 3/8"x61 3/4" (24x86x1570) (2) (5) H77 - ATTACHMENT BOAR
Parts Identification Wood Components (NOT TO SCALE) (1) (2) (2) M2 - BOTTOM WALL RAIL - W4L04596 5/8"x3 3/8"x80" (16x86x2032) (1) M3 - BOTTOM WALL RAIL - W4L04579 5/8"x3 3/8"x60 1/2" (16x86x1537) M4 - CROWS NEST WALL RAIL - W4L11773 5/8"x3 3/8"x29 7/8" (16x86x758) (2) (1) M1 - TOP WALL RAIL - W4L04619 5/8"x3 3/8"x80" (16x86x2032) M5 - GABLE BOARD - W4L04641 5/8"x3 3/8"x59 1/2" (16x86x1510) M6 - CLUB HOUSE WALL BOARD - W4L04635 5/8"x3 3/8"x53 7/8" (16x86x1370) (2) M7 - GABLE BOARD - W4L04642 5/
Parts Identification Wood Components (NOT TO SCALE) M17 - FRONT WINDOW WALL BOARD - W4L04639 5/8"x3 3/8"x35" (16x86x889) (2) (1) (1) M18 - GABLE BOARD - W4L04652 5/8"x3 3/8"x32 3/8" (16x86x822) M19 - FRONT PORCH ROOF SUPPORT - W4L04658 5/8"x3 3/8"x30 5/8" (16x86x779) M21 - CLUB HOUSE WALL RAIL - W4L04613 5/8"x3 3/8"x30 1/4" (16x86x768) (3) (4) M22 - CLUB HOUSE WALL BOARD - W4L04633 5/8"x3 3/8"x29 7/8" (16x86x758) (2) M23 - CLUB HOUSE WALL BOARD - W4L04634 5/8"x3 1/8"x29 7/8" (16x80x758) (18) (2
Parts Identification Wood Components (NOT TO SCALE) M32 - CROWS NEST WALL RAIL - W4L04671 5/8"x3 3/8"x10" (16x86x254) (2) (2) M33 - FRONT WINDOW WALL BOARD - W4L04638 5/8"x3 3/8"x6 3/8" (16x86x162) (1) M61 - ATTACHMENT BOARD - W4L04681 5/8"x3 3/8"x22 7/8" (16x86x580) (1) (1) M70 - SLIDE BED SUPPORT - W100935 5/8"x3 3/8"x19 7/8" (16x86x505) (1) (2) M34 - WALL RAIL - W4L04611 5/8"x3 3/8"x6 3/8" (16x86x162) M73 - REAR SUPPORT - W4L11767 5/8"x3 3/8"x20 1/8" (16x86x512) (10) M74 - ROCK WALL BOARD
Parts Identification Wood Components (NOT TO SCALE) (2) N7 - GABLE TRIM - W4L04648 5/8"x2 3/8"x11 1/2" (16x60x292) N8 - FRONT PORCH GABLE TRIM - W4L04657 5/8"x2 3/8"x9 1/2" (16x60x241) (2) (4) (2) N9 - GABLE TRIM - W4L04649 5/8"x2 3/8"x6 1/2" (16x60x165) N10 - GABLE BOARD - W4L04645 5/8"x2 3/8"x27 5/8" (16x60x702) O1 - CROWS NEST WALL BOARD - W4L04672 5/8"x1 3/8"x32 1/2" (16x34x825) (18) (1) O2 - SAFETY BOARD - W4L04605 5/8"x1 3/8"x28 5/8" (16x34x726) SP50 - SWING BEAM SUPPORT - W103545 3 3/8"x
Parts Identification Wood Components (NOT TO SCALE) (1) RP1 - LEFT PORCH PEAK ROOF PANEL - W2A02630 1 5/8"x10 1/2"x32 7/8" (42x268x834) (1) RP2 - LEFT PORCH ROOF PANEL - W2A02628 1 5/8"x15 5/8"x32 7/8" (42x396x834) (2) (1) RP3 - PEAK ROOF PANEL - W2A02626 1 5/8"x20 5/8"x59" (42x524x1499) RP4 - RIGHT PORCH PEAK ROOF PANEL - W2A02631 1 5/8"x10 1/2"x32 7/8" (42x268x834) (1) RP5 - RIGHT PORCH ROOF PANEL - W2A02629 1 5/8"x15 5/8"x32 7/8" (42x396x834) (4) (6) RP6 - ROOF PANEL - W2A02627 1 5/8"x15 5/8
Parts Identification Hardware (1) - BOLT WH 5/16X6 - H100023 (2) - BOLT WH 5/16x5 3/4 - H100032 (34) - BOLT WH 5/16x3 3/4 - H100019 (4) - BOLT WH 5/16x3 1/2 - H100018 (3) - BOLT WH 5/16x3 1/4 - H100017 (6) - BOLT WH 5/16x3 - H100016 (11) (10) (6) (28) (30) - BOLT WH 5/16x1/2 - H100115 (9) - BOLT WH 5/16x3/4 - H100222 (15) - BOLT WH 5/16x1 - H100008 (6) - BOLT WH 5/16x1 1/4 - H100009 (26) - BOLT WH 5/16x1 1/2 - H100010 - NUT BARREL WH 5/16x1 1/2 - H100006 - BOLT WH 5/16x2 3/4 - H10
Parts Identification (2) - SWING HANGER QUICK LINK 86 BOARD - H100098 Hardware - T-40 TORX WRENCH - A100041 (2) - T-30 TORX BIT - H100147 (4) (2) - T-40 TORX BIT - A100042 (2) (9) - T-30 TORX WRENCH - H100114 - BOLT HEX 3/8x5-1/2 - H100654 (2) - BOLT HEX 5/16x2-3/4 - H100047 (4) - BOLT HEX 5/16x2 - H100044 (11) (48) (2) - BOLT HEX 5/16x1 3/4 - H100043 (4) - BOLT HEX 5/16x1 1/4 - H100042 (2) - LAG SCREW WH 1/4x2 - H100146 (9) - LAG SCREW WH 1/4x1-1/2 - H100145 (2) - LAG SCREW HEX 5/
Parts Identification Hardware (58) - SCREW PFH 8x2 1/2 - H100090 (37) - SCREW PFH 8x2 1/4 - H100091 (88) - SCREW PFH 8x2 - H100111 (4) (326) (2) (206) - WASHER LOCK EXT 8x19 - H100030 (28) - WASHER LOCK EXT 12x19 - H100031 - WASHER LOCK EXT 6x15 - H100138 (22) - WASHER SPLIT 5/16 - H100095 - SCREW PFH 8x1-3/4" - H100089 (28) - WASHER LOCK INT 8x15 - H100108 (4) - WASHER SAFETY 17x30 - H100103 (9) - WASHER LOCK INT 10x18 - H100107 - SCREW PFH 8x1-1/2" - H100086 - SCREW PFH 8x1-1/4" -
Parts Identification Accessories (NOT TO SCALE) (2) DP - SWING SEAT GREEN - A100027 (1) DN - GLIDER SEAT DARK GREEN - A100025 (2) DJ - GLIDER ARM LIGHT GREEN - A100021 (1) DR - SLIDE RAIL 10' BOTTOM LEFT GREEN - A100030 (1) DT - SLIDE RAIL 10' TOP LEFT GREEN - A100032 (1) DS - SLIDE RAIL 10' BOTTOM RIGHT GREEN - A100031 (6) - GREEN HC ROCK #1 - A6P00036 (1) TR - SLIDE RAIL 10' TOP RIGHT GREEN - A100033 (6) - GREEN HC ROCK #2 - A6P00037 (1) DX - SLIDE BED 10' LIGHT GREEN - A100035 (8) EC - METAL R
Parts Identification Accessories (NOT TO SCALE) (4) EF - CHAIN GREEN 57" - A100047 (4) HW - CHAIN GREEN 44" - A100048 (2) (2) - HAND GRIP GREEN 816 C/C - A100134 - LADDER RUNG 629 GREEN - A100324 (8) FA - QUICK LINK - A100069 (6) - HAND GRIP METAL GREEN 381 c/c - A100118 (1) SS - "C" REVISION TAG - A100316 (1) - SWING BEAM EXTENSION BRACKET-LEFT - A100325 (1) - SWING BEAM EXTENSION BRACKET-RIGHT - A100326 (4) SWING HANGER - A4M00505 (2) - TRIANGLE PLATE 100° 5 HOLE - A100294 (2) - WINDOW 216
(1) E77 - LEFT UPRIGHT - W4L11769 1 3/8"x3 3/8"x64 3/8" (36x86x1634) (5) H76 - LADDER RUNG - W4L11770 1"x3 3/8"x18 1/8" (24x86x460) 5 FOOT LADDER ASSEMBLY STEP 1 (10) SCREW PFH 8x2 (10 PLCS) H76 E77 29 SCREW PFH 8x2 H100111
(1) E78 - RIGHT UPRIGHT - W4L11768 1 3/8"x3 3/8"x64 3/8" (36x86x1634) 5 FOOT LADDER ASSEMBLY STEP 2 (10) SCREW PFH 8x2 (10 PLCS) E78 30 SCREW PFH 8x2 H100111
(1) M73 - REAR SUPPORT - W4L11767 5/8"x3 3/8"x20 1/8" (16x86x512) (1) H77 - ATTACHMENT BOARD - W4L11766 1"x3 3/8"x20 1/8" (24x86x512) 5 FOOT LADDER ASSEMBLY STEP 3 (8) H77 M73 SCREW PFH 8x2 (8 PLCS) 31 SCREW PFH 8x2 H100111
(2) JV - HAND GRIP GREEN 816 C/C - A100134 5 FOOT LADDER ASSEMBLY STEP 4 (4) BOLT WH 5/16x3 1/2 H100018 (4) JV T-NUT 5/16 (4 PLCS) BOLT WH 5/16x3 1/2 (4 PLCS) 32 T-NUT 5/16 H100074
(4) M76 - ROCK WALL BOARD - W4L04830 5/8"x3 3/8"x22 7/8" (16x86x580) (4) M75 - ROCK WALL BOARD - W4L04829 5/8"x3 3/8"x22 7/8" (16x86x580) ROCK WALL ASSEMBLY STEP 1 (24) M75 M76 T-NUT 1/4 (24 PLCS) 33 T-NUT 1/4 H100072
(10) M74 - ROCK WALL BOARD - W4L04678 5/8"x3 3/8"x22 7/8" (16x86x580) (4) M76 - ROCK WALL BOARD - W4L04830 5/8"x3 3/8"x22 7/8" (16x86x580) (2) H72 - ROCKWALL RAIL - W4L04677 1"x3 3/8"x61 3/4" (24x86x1570) (4) M75 - ROCK WALL BOARD - W4L04829 5/8"x3 3/8"x22 7/8" (16x86x580) ROCK WALL ASSEMBLY STEP 2 H72 (72) SCREW PFH 8x1-1/2" H100086 M74 IMPORTANT! T-NUTS TO THE INSIDE M74 SCREW PFH 8x1-1/2" (72 PLCS) M75 M76 M74 M75 M74 RECOMMENDED BOARD PLACEMENT PATTERN M76 M74 M75 M74 M76 H72 M74 M75 M74
(1) Y3 - ROCK WALL END BOARD - W4L04682 5/8"x4"x22 7/8" (16x102x580) ROCK WALL ASSEMBLY STEP 3 Y3 SCREW PFH 8x1-1/2" (4 PLCS) (4) 5/8 35 SCREW PFH 8x1-1/2" H100086
1 1/2 in [37 mm] (1) M61 - ATTACHMENT BOARD - W4L04681 5/8"x3 3/8"x22 7/8" (16x86x580) ROCK WALL ASSEMBLY STEP 4 (4) M61 (2) T-NUT 5/16 (2 PLCS) HOLES CLOSER TO THE BOTTOM OF BOARD SCREW PFH 8x1-1/2" (4 PLCS) M61 IMPORTANT! T-NUTS TO THE INSIDE 36 SCREW PFH 8x1-1/2" H100086 T-NUT 5/16 H100074
(6) (6) - GREEN HC ROCK #1 - A6P00036 - GREEN HC ROCK #2 - A6P00037 ROCK WALL ASSEMBLY STEP 5 (24) BOLT PTH 1/4x3/4 H100063 (24) WASHER LOCK INT 8x15 H100108 BOLT PTH 1/4x3/4 (24 PLCS) WASHER LOCK INT 8x15 (24 PLCS) NOTE: ARROW ON BACK OF ROCK POINTS UP. RANDOMLY PLACE ALL 12 ROCKS ON ROCK WALL.
(2) E74 - MONKEY BAR RAIL - W102918 1 3/8"x3 3/8"x77 1/8" (36x86x1959) (4) TZ - L BRACKET 2.5x38x50x55 - A100340 (4) EC - METAL RUNG 559 GREEN - A100045 (2) QZ - TRIANGLE PLATE 100° 5 HOLE - A100294 MONKEY BAR ASSEMBLY STEP 1 (8) SCREW TAPPING 14x1-1/2 H100109 (6) T-NUT 5/16 H100074 (2) BOLT WH 5/16x2 H100012 (2) NUT LOCK 5/16 H100110 NUT LOCK 5/16 (2 PLCS) (6) WASHER FLAT 8x27 (2 PLCS) BOLT WH 5/16x1 1/2 H100010 L BRACKET 2.
(2) E79 - MONKEY BAR UPRIGHT - W100995 1 3/8"x3 3/8"x88 1/8" (36x86x2237) (4) EC - METAL RUNG 559 GREEN - A100045 (2) FX - HAND GRIP METAL GREEN 381 c/c - A100118 MONKEY BAR ASSEMBLY STEP 2 (8) HAND GRIP METAL GREEN 381 c/c (2 PLCS) LAG SCREW WH 5/16x1 1/2 (4 PLCS) METAL RUNG 559 GREEN (4 PLCS) SCREW TAPPING 14x1-1/2 (8 PLCS) 39 (4) SCREW TAPPING 14x1-1/2 H100109 LAG SCREW WH 5/16x1 1/2 H100026
(1) H82 - MONKEY BAR GROUND BOARD - W100994 1"x3 3/8"x70 3/8" (24x86x1786) (2) BOLT HEX 5/16x2-3/4 H100047 (2) H81 - MONKEY BAR BRACE - W100993 1"x3 3/8"x53 1/4" (24x86x1352) (4) MONKEY BAR ASSEMBLY STEP 3 BOLT WH 5/16x1 1/2 H100010 (4) NUT BARREL WH 5/16x7/8 H100005 (2) T-NUT 5/16 H100074 (8) (4) WASHER LOCK EXT 12x19 H100031 WASHER LOCK EXT 8x19 H100030 (2) (2) WASHER LOCK INT 8x15 H100108 WASHER FLAT 9x18 H100106 (4) T-NUT 5/16 (2 PLCS) WASHER FLAT 9x18 (2 PLCS) WASHER LOCK INT 8x15
MONKEY BAR ASSEMBLY STEP 4 (4) T-NUT 5/16 H100074 (4) BOLT WH 5/16x1 1/2 H100010 T-NUT 5/16 (4 PLCS) BOLT WH 5/16x1 1/2 (4 PLCS) 41
STEP 1 DX - SLIDE BED 10' LIGHT GREEN - A100035 M70 - SLIDE BED SUPPORT - W100935 5/8"x3 3/8"x19 7/8" (16x86x505) 10 FOOT SLIDE ASSEMBLY (3) BOLT WH 5/16x1/2 (3) WASHER LOCK EXT 12x19 TOP (3) NUT BARREL WH 5/16x5/8 DX - SLIDE BED 10' LIGHT GREEN (SEE SLIDE ASSEMBLY INSTALLATION STEP FOR DECK MOUNTING HOLE DRILLING LOCATIONS).
DS - SLIDE RAIL 10' BOTTOM RIGHT GREEN - A100031 TR - SLIDE RAIL 10' TOP RIGHT GREEN - A100033 DR - SLIDE RAIL 10' BOTTOM LEFT GREEN - A100030 DT - SLIDE RAIL 10' TOP LEFT GREEN - A100032 10 FOOT SLIDE ASSEMBLY STEP 2 Ɣ BUILD 2 SIDE RAILS, MAKING A LEFT AND RIGHT ASSEMBLY.
DW - SLIDE SUPPORT TUBE 21.34x2.77x505 - A100034 21.34 OD x 2.77 W x 505 10 FOOT SLIDE ASSEMBLY STEP 3 Ɣ PLACE (1) SLIDE RAIL ASSEMBLY ON A FLAT SURFACE AND BEGIN INSERTING SLIDE BED AT THE BOTTOM OF THE SLIDE RAIL (FIG. 1). HAVE A HELPER BEND THE SLIDE BED TOWARDS THE TOP OF THE SLIDE AND INSERT THE BED INTO THE SLIDE CAVITY. MAKE SURE SLIDE BED IS COMPLETELY DOWN IN THE SLIDE CAVITY. Ɣ INSERT THE (4) SLIDE SUPPORT TUBES INTO THEIR RESPECTIVE PILOT LOCATIONS (FIG. 2).
10 FOOT SLIDE ASSEMBLY STEP 4 Ɣ ONCE THE SLIDE BED, SUPPORT TUBES, AND SUPPORT BOARD ARE COMPLETELY IN THE CAVITY AND SUPPORT POCKET, SECURE USING 2-1/2" SCREWS AT EACH OF THE PILOT HOLE LOCATIONS AS SHOWN. Ɣ REPEAT PROCESS FOR OPPOSITE SLIDE RAIL.
(1) (2) DN - GLIDER SEAT DARK GREEN - A100025 DJ - GLIDER ARM LIGHT GREEN - A100021 Light Green & Dark Green Glider (2) WASHER FLAT 8x27 H100105 (2) NUT LOCK 5/16 H100110 '- (2) '- BOLT WH 5/16x5 3/4 H100032 '1 NUT LOCK 5/16 (2 PLCS) WASHER FLAT 8x27 (2 PLCS) BOLT WH 5/16x5 3/4 (2 PLCS) 46
(4) G5 - BAY WINDOW HEADER - W4L04659 1"x5 1/4"x45 1/4" (24x134x1150) (6) WP1 - BAY WINDOW PANEL - W2A01496 BAY WINDOW ASSEMBLY WP1 MAKE 2 WINDOW ASSEMBLIES. SCREW PFH 8x1-1/2" (8 PLCS) (40) SCREW PFH 8x1-1/2" H100086 G5 (8) SCREW PFH 8x1 H100085 NOTE: MARK CENTERS ON EACH PART THEN ALIGN PARTS ON MARKS.
(4) H20 - PORCH ROOF RAFTER - W4L04655 1"x3 3/8"x24 1/2" (24x86x622) PORCH ROOF ASSEMBLY STEP 1 1/2 in (2) 1 1/4 in USING A 3/16" DRILL BIT, MARK AND DRILL A PILOT HOLE INTO 'H20' RAFTER TO PREVENT SPLITTING. ONLY DRILL THROUGH ONE RAFTER NOT BOTH.
(1) (2) M19 - FRONT PORCH ROOF SUPPORT - W4L04658 5/8"x3 3/8"x30 5/8" (16x86x779) (1) N8 - FRONT PORCH GABLE TRIM - W4L04657 5/8"x2 3/8"x9 1/2" (16x60x241) N5 - FRONT PORCH GABLE TRIM - W4L04656 5/8"x2 3/8"x15" (16x60x381) (1) HC - BYD ID TAG (LARGE) AGES 3-10 - A100164 PORCH ROOF ASSEMBLY STEP 2 (6) N5 (4) SCREW PFH 8x1-1/8" (6 PLCS) N8 N8 M19 NOTE ENSURE THAT HOLES ARE ALIGNED (BOTH ENDS) BYD ID TAG (1 PLC) SCREW PWH 8x5/8 (4 PLCS) 49 SCREW PFH 8x1-1/8" H100088 SCREW PWH 8x5/8 H100128
(1) RP1 - LEFT PORCH PEAK ROOF PANEL - W2A02630 1 5/8"x10 1/2"x32 7/8" (42x268x834) (1) RP4 - RIGHT PORCH PEAK ROOF PANEL - W2A02631 1 5/8"x10 1/2"x32 7/8" (42x268x834) PORCH ROOF ASSEMBLY STEP 3 (8) SCREW PFH 8x2 H100111 RP4 SCREW PFH 8x2 (8 PLCS) RP1 50
(1) RP2 - LEFT PORCH ROOF PANEL - W2A02628 1 5/8"x15 5/8"x32 7/8" (42x396x834) (1) RP5 - RIGHT PORCH ROOF PANEL - W2A02629 1 5/8"x15 5/8"x32 7/8" (42x396x834) PORCH ROOF ASSEMBLY STEP 4 (8) RP5 SCREW PFH 8x2 (8 PLCS) RP2 51 SCREW PFH 8x2 H100111
(1) A50 - SWING BEAM - W4L04660 3 3/8"x5 1/4"x89 1/2" (86x134x2274) (4) SWING HANGER - A4M00505 (1) (1) - SWING BEAM EXTENSION BRACKET-LEFT - A100325 - SWING BEAM EXTENSION BRACKET-RIGHT - A100326 SWING BEAM ASSEMBLY STEP 1 (8) A50 T-NUT 3/8 (8 PLCS) BOLT HEX 3/8x5-1/2 H100654 (3) NUT BARREL WH 5/16x7/8 H100005 (3) (8) WASHER LOCK INT 10x18 H100107 (8) BOLT WH 5/16x3 H100016 WASHER FLAT 11x25 H100102 (8) T-NUT 3/8 H100073 BOLT WH 5/16x3 (3 PLCS) NUT BARREL WH 5/16x7/8 (3 PLCS) SWING HAN
(1) (2) (1) G50 - GROUND BOARD - W100947 1"x5 1/4"x86 3/4" (24x134x2202) SP50 - SWING BEAM SUPPORT - W103545 3 3/8"x3 3/8"x48 3/8" (86x86x1228) E51 - ANGLE BRACE - W100948 1 3/8"x3 3/8"x88 3/4" (36x86x2254) (1) E50 - END SUPPORT - W100949 1 3/8"x3 3/8"x44 1/8" (36x86x1120) SWING BEAM ASSEMBLY STEP 2 (1) BOLT WH 5/16X6 H100023 (2) BOLT WH 5/16x3 3/4 H100019 BOLT WH 5/16X6 (1 PLC) WASHER LOCK EXT 8x19 (1 PLC) (7) NUT BARREL WH 5/16x7/8 H100005 (2) NUT BARREL WH 5/16x1 1/2 H100006 SP50 WASHER L
SWING BEAM ASSEMBLY STEP 3 (2) BOLT WH 5/16x3 H100016 (2) NUT BARREL WH 5/16x7/8 H100005 NOTE: TIGHTEN ALL BRACKET HARDWARE AT THIS TIME.
(2) E3 - CROWS NEST FLOOR RAIL - W4L11785 1 3/8"x3 3/8"x38" (36x86x964) (1) H19 - CROWS NEST FLOOR RAIL - W4L04663 1"x3 3/8"x27" (24x86x686) CROWS NEST DECK ASSEMBLY STEP 1 (4) SCREW PFH 8x2 1/2 H100090 (4) H19 E3 T-NUT 5/16 (4 PLCS) SCREW PFH 8x2 1/2 (4 PLCS) 55 T-NUT 5/16 H100074
(4) - SWING HANGER QUICK LINK 86 BOARD - H100098 E4 - CROWS NEST DECK BRACE - W4L04662 (2) 1 3/8"x3 3/8"x11" (36x86x280) CROWS NEST DECK ASSEMBLY STEP 2 (2) (4) BOLT WH 5/16x2 1/4 H100013 (2) WASHER SAFETY 17x30 H100103 WASHER LOCK EXT 8x19 H100030 (4) (2) WASHER FLAT 8x27 H100105 (4) NUT LOCK 5/16 (4 PLCS) WASHER SAFETY 17x30 (4 PLCS) WASHER FLAT 8x27 (4 PLCS) SWING HANGER QUICK LINK 86 BOARD (4 PLCS) T-NUT 5/16 (2 PLCS) E4 BOLT WH 5/16x2 1/4 (2 PLCS) WASHER LOCK EXT 8x19 (2 PLCS) 56 T-
(9) L1 - CROWS NEST FLOOR BOARD - W4L04664 5/8"x4 3/8"x27" (16x112x686) CROWS NEST DECK ASSEMBLY STEP 3 (34) 9 PLCS SCREW PFH 8x1-1/2" (34 PLCS) L1 FLUSH 1 in 57 SCREW PFH 8x1-1/2" H100086
(1) H21 - CROWS NEST FLOOR SUPPORT - W4L04665 1"x3 3/8"x24 1/8" (24x86x614) CROWS NEST DECK ASSEMBLY STEP 4 (2) SCREW PFH 8x1-1/4" (2 PLCS) TIP MARK LOCATIONS SHOWN. USING AN 1/8" DRILL BIT DRILL 2 PILOT HOLES.
(1) B1 - TOWER LEG - W4L04562 3"x3"x89 1/2" (76x76x2274) (1) (1) - VERTICAL ID PLATE - A4M00520 (1) (1) E1 - TOWER LEG - W4L04563 1 3/8"x3 3/8"x59" (36x86x1500) G7 - BOTTOM FLOOR RAIL - W4L11775 1"x5 1/4"x80" (24x134x2032) (1) G1 - TOP FLOOR RAIL - W4L04566 1"x5 1/4"x80" (24x134x2032) B3 - TOWER LEG - W4L04564 3"x3"x59" (76x76x1500) FORT ASSEMBLY STEP 1 (4) (4) BOLT WH 5/16x2 1/4 H100013 SCREW PPH 4x1/2 WZ H100360 HOLES UP (8) (12) BOLT WH 5/16x3 3/4 H100019 T-NUT 5/16 H100074 (12) WAS
(1) (1) (1) B2 - TOWER LEG - W4L04561 3"x3"x89 1/2" (76x76x2274) (1) G7 - BOTTOM FLOOR RAIL - W4L11775 1"x5 1/4"x80" (24x134x2032) TOP E2 - TOWER LEG - W4L04567 1 3/8"x3 3/8"x59" (36x86x1500) (1) G2 - TOP FLOOR RAIL - W4L04569 1"x5 1/4"x80" (24x134x2032) B4 - TOWER LEG - W4L04568 3"x3"x59" (76x76x1500) FORT ASSEMBLY STEP 2 (4) BOLT WH 5/16x2 1/4 H100013 (12) (8) BOLT WH 5/16x3 3/4 H100019 (12) T-NUT 5/16 H100074 WASHER LOCK EXT 8x19 H100030 BOLT WH 5/16x3 3/4 (8 PLCS) WASHER LOCK EXT 8x19
(1) H28 - FRONT WALL RAIL - W4L11774 1"x3 3/8"x60 1/2" (24x86x1537) (1) (1) G6 - FLOOR RAIL - W4L11777 1"x5 1/4"x60 1/2" (24x134x1537) G3 - FLOOR RAIL - W4L04571 1"x5 1/4"x60 1/2" (24x134x1537) FORT ASSEMBLY STEP 3 (8) LAG SCREW WH 5/16x2 (2 PLCS) WASHER LOCK EXT 8x19 (10 PLCS) H28 LAG SCREW WH 5/16x2 1/2 (8 PLCS) G3 NOTE HOLE LOCATIONS G6 61 LAG SCREW WH 5/16x2 1/2 H100028 (2) LAG SCREW WH 5/16x2 H100027 (10) WASHER LOCK EXT 8x19 H100030
(1) (1) G4 - FLOOR RAIL - W4L04675 1"x5 1/4"x60 1/2" (24x134x1537) K2 - FLOOR RAIL - W4L04570 5/8"x5 1/4"x60 1/2" (16x134x1537) FORT ASSEMBLY STEP 4 (8) WASHER LOCK EXT 8x19 H100030 (4) LAG SCREW WH 5/16x2 H100027 (4) LAG SCREW WH 5/16x2 1/2 H100028 LAG SCREW WH 5/16x2 1/2 (4 PLCS) WASHER LOCK EXT 8x19 (4 PLCS) LAG SCREW WH 5/16x2 (4 PLCS) WASHER LOCK EXT 8x19 (4 PLCS) G4 NOTE HOLE LOCATIONS K2 62
(1) (1) K3 - FLOOR RAIL - W4L04572 5/8"x5 1/4"x60 1/2" (16x134x1537) H26 - FLOOR JOIST - W4L04573 1"x3 3/8"x60 1/2" (24x86x1537) FORT ASSEMBLY STEP 5 (4) (4) LAG SCREW WH 5/16x2 (4 PLCS) LAG SCREW WH 5/16x2 H100027 (4) WASHER LOCK EXT 8x19 H100030 SCREW PFH 8x2 1/2 H100090 H26 WASHER LOCK EXT 8x19 (4 PLCS) FLUSH NOTE HOLE LOCATIONS SCREW PFH 8x2 1/2 (4 PLCS) K3 63
2 5/8 in (2) L2 - SAND BOX SEAT - W4L11776 5/8"x4 3/8"x24" (16x112x610) (1) 1 3/4 in H27 - PICNIC TABLE SUPPORT - W4L04574 1"x3 3/8"x28 5/8" (24x86x728) FORT ASSEMBLY STEP 6 (8) (1) SCREW PFH 8x1-1/2" H100086 WASHER LOCK EXT 8x19 H100030 1 3/4 in END AT TOP T-NUT 5/16 (1 PLC) H27 WASHER LOCK EXT 8x19 (1 PLC) BOLT WH 5/16x1 1/2 (1 PLC) L2 SCREW PFH 8x1-1/2" (8 PLCS) 64 (1) (1) BOLT WH 5/16x1 1/2 H100010 T-NUT 5/16 H100074
(2) Y2 - BOTTOM FLOOR BOARD - W4L04577 5/8"x4"x35 1/4" (16x102x895) (4) FP1 - BOTTOM FLOOR PANEL - W2A01485 1 5/8"x13 1/2'x35 3/8" (40x344x897) FORT ASSEMBLY STEP 7 (38) SCREW PFH 8x1-1/2" H100086 Y2 FP1 4 PLCS SCREW PFH 8x1-1/2" (38 PLCS) Y2 SPACE BOARDS & PANELS EVENLY.
(1) M3 - BOTTOM WALL RAIL - W4L04579 5/8"x3 3/8"x60 1/2" (16x86x1537) (1) H3 - PICNIC TABLE RAIL - W4L04578 1"x3 3/8"x67 1/4" (24x86x1708) FORT ASSEMBLY STEP 8 (4) (2) NOTE ANGLE CUT FACES DOWNWARD LAG SCREW WH 5/16x2 1/2 H100028 (6) WASHER LOCK EXT 8x19 H100030 LAG SCREW WH 5/16x2 H100027 H3 LAG SCREW WH 5/16x2 1/2 (4 PLCS) WASHER LOCK EXT 8x19 (4 PLCS) M3 WASHER LOCK EXT 8x19 (2 PLCS) LAG SCREW WH 5/16x2 (2 PLCS) 66
(8) FORT ASSEMBLY STEP 9 M27 - BOTTOM WALL BOARD - W4L04580 5/8"x3 3/8"x21 3/8" (16x86x544) 3 in EQUAL SPACING (32) SCREW PFH 8x1-1/8" (32 PLCS) M27 8 PLCS 67 SCREW PFH 8x1-1/8" H100088
(2) M2 - BOTTOM WALL RAIL - W4L04596 5/8"x3 3/8"x80" (16x86x2032) FORT ASSEMBLY STEP 10 (6) WASHER LOCK EXT 8x19 H100030 (6) LAG SCREW WH 5/16x2 H100027 M2 M2 LAG SCREW WH 5/16x1 1/2 (4 PLCS) LAG SCREW WH 5/16x2 (4 PLCS) WASHER LOCK EXT 8x19 (6 PLCS) 68
(10) FORT ASSEMBLY STEP 11 M27 - BOTTOM WALL BOARD - W4L04580 5/8"x3 3/8"x21 3/8" (16x86x544) 3 1/8 in EQUAL SPACING 3 1/8 in EQUAL SPACING (40) SCREW PFH 8x1-1/8" (40 PLCS) 10 PLCS M27 69 SCREW PFH 8x1-1/8" H100088
(1) (1) H16 - PICNIC TABLE SEAT RAIL - W4L04597 1"x3 3/8"x32" (24x86x812) (2) H23 - PICNIC TABLE BRACE - W4L04598 1"x3 3/8"x17 1/2" (24x86x444) FORT ASSEMBLY STEP 12 LAG SCREW WH 5/16x2 1/2 H100028 (1) BOLT WH 5/16x1 1/2 (1 PLC) (1) LAG SCREW WH 1/4x2 H100146 M27 (1) BOLT WH 5/16x1 3/4 H100011 (1) WASHER LOCK EXT 6x15 H100138 (2) WASHER LOCK EXT 8x19 (2 PLCS) (4) BOLT WH 5/16x1 3/4 (1 PLC) BOLT WH 5/16x1 1/2 H100010 T-NUT 5/16 H100074 WASHER LOCK EXT 8x19 H100030 USING 'H16' AS A GUIDE,
FORT ASSEMBLY STEP 13 (1) H17 - PICNIC TABLE SEAT RAIL - W4L04599 1"x3 3/8"x32" (24x86x812) (1) H23 - PICNIC TABLE BRACE - W4L04598 1"x3 3/8"x17 1/2" (24x86x444) T-NUT 5/16 (2 PLCS) H17 (2) LAG SCREW WH 5/16x2 1/2 H100028 (1) LAG SCREW WH 1/4x2 H100146 H23 BOLT WH 5/16x1 3/4 (2 PLCS) LAG SCREW WH 5/16x2 1/2 (2 PLCS) WASHER LOCK EXT 8x19 (4 PLCS) WASHER LOCK EXT 6x15 (1 PLC) LAG SCREW WH 1/4x2 (1 PLC) 71 (2) (4) BOLT WH 5/16x1 3/4 H100011 WASHER LOCK EXT 8x19 H100030 (2) (1) T-NUT 5/16 H
(4) H15 - PICNIC TABLE SEAT - W4L04600 1"x3 3/8"x35 3/8" (24x86x897) FORT ASSEMBLY STEP 14 (16) SCREW PFH 8x2 (16 PLCS) H15 4 PLCS 72 SCREW PFH 8x2 H100111
(1) H24 - PICNIC TABLE TOP SUPPORT - W4L04601 1"x3 3/8"x16 1/2" (24x86x418) FORT ASSEMBLY STEP 15 (1) (1) BOLT WH 5/16x1 3/4 H100011 T-NUT 5/16 H100074 (2) LAG SCREW WH 5/16x2 1/2 H100028 (3) WASHER LOCK EXT 8x19 H100030 WASHER LOCK EXT 8x19 (1 PLC) BOLT WH 5/16x1 3/4 (1 PLC) T-NUT 5/16 (1 PLC) H24 WASHER LOCK EXT 8x19 (2 PLCS) LAG SCREW WH 5/16x2 1/2 (2 PLCS) 73
(1) (1) M16 - CENTER PICNIC TABLE TOP - W4L04603 5/8"x3"x38 1/4" (16x76x973) M30 - PICNIC TABLE TOP CLEAT - W4L04604 5/8"x3 3/8"x16" (16x86x406) (4) M13 - PICNIC TABLE TOP - W4L04602 5/8"x3 3/8"x41 1/4" (16x86x1049) FORT ASSEMBLY STEP 16 (20) (5) SCREW PFH 8x1-1/2" (20 PLCS) M16 M13 4 PLCS M30 SCREW PFH 8x1-1/8" (5 PLCS) NOTE: CENTER M30 CLEAT ON BOTTOM OF TABLE TOP BOARDS.
(2) H25 - TOP FLOOR SUPPORT - W4L04606 1"x3 3/8"x3" (24x86x76) FORT ASSEMBLY STEP 17 2 PLCS (4) FLUSH H25 SCREW PFH 8x2 (4 PLCS) 75 SCREW PFH 8x2 H100111
12 5/8 in TOP (1) O2 - SAFETY BOARD - W4L04605 5/8"x1 3/8"x28 5/8" (16x34x726) FORT ASSEMBLY STEP 18 (3) TOP SCREW PFH 8x1-1/8" (3 PLCS) NOTE HOLE LOCATIONS O2 CENTER IN OPENING 76 SCREW PFH 8x1-1/8" H100088
(8) E5 - DECK BRACE - W4L11778 1 7/16"x3 3/8"x20" (36x86x508) FORT ASSEMBLY STEP 19 BOLT WH 5/16x2 1/4 H100013 (8) T-NUT 5/16 H100074 #% ## #& #$ #' #% (8) 8 PLCS $ % # & $ ' % ( & ) ' * ( + ) #, * ## + #$ #, (8) $$ $# #+ $, #) #* #' #( #& #$ #% ## $ % & ' ( ) * + #, # # LAG SCREW WH 5/16x2 1/2 H100028 (16) $% E5 T-NUT 5/16 (8 PLCS) NOTE ORIENTATION OF T-NUTS WASHER LOCK EXT 8x19 H100030 WASHER LOCK EXT 8x19 (8 PLCS) BOLT WH 5/16x2 1/4 (8 PLCS) WASHER LOC
(1) (2) H5 - FLOOR RAIL - W4L04608 1"x3 3/8"x60 1/2" (24x86x1537) H26 - FLOOR JOIST - W4L04573 1"x3 3/8"x60 1/2" (24x86x1537) FORT ASSEMBLY STEP 20 (4) (8) LAG SCREW WH 5/16x2 H100027 SCREW PFH 8x2 1/2 H100090 NOTE: FLUSH TOPS OF BOARDS. ALL PLACES.
(2) FP2 - FLOOR PANEL - W2A01486 1 1/4"x13 1/2'x81 7/8" (32x344x2080) FORT ASSEMBLY STEP 21 Y1 - TOP FLOOR BOARD - W4L04609 5/8"x4"x78" (16x102x1980) T-NUT 5/16 (2 PLCS) (94) SCREW PFH 8x1-1/2" H100086 (2) T-NUT 5/16 H100074 TIP: INSTALL T-NUTS ON BOTTOM SIDE OF BOTH Y1 FLOOR BOARDS BEFORE ATTACHING TO FORT. Y1 SCREW PFH 8x1-1/2" (94 PLCS) NOTE: ENSURE PILOT HOLES ARE CENTERED ON FLOOR JOISTS. T-NUT 5/16 (2 PLCS) NOTE: T-NUTS THESE HOLES ON BOTTOM SIDE.
1 3/4 in 1 1/2 in B8 - BACK RIGHT CLUB HOUSE CORNER - W4L04618 (1) 3"x3"x53 7/8" (76x76x1370) (1) (2) L BRACKET 2.
1 3/4 1 1/2 (1) (1) M34 - WALL RAIL - W4L04611 5/8"x3 3/8"x6 3/8" (16x86x162) M1 - TOP WALL RAIL - W4L04619 5/8"x3 3/8"x80" (16x86x2032) M10 - CLUB HOUSE WALL RAIL - W4L04614 5/8"x3 3/8"x50 1/4" (16x86x1277) (1) FORT ASSEMBLY STEP 23 (4) LAG SCREW WH 5/16x2 H100027 (4) WASHER LOCK EXT 8x19 H100030 WASHER LOCK EXT 8x19 (4 PLCS) LAG SCREW WH 5/16x2 (4 PLCS) NOTE HOLE LOCATIONS FOR BOARD ORIENTATION.
(1) (1) L BRACKET 2.
(1) (1) L BRACKET 2.
(1) (1) L BRACKET 2.
(2) (2) L BRACKET 51x32x82x3.175 A100396 FORT ASSEMBLY STEP 27 H9 - CLUB HOUSE WALL BOARD - W4L11784 1"x3 3/8"x50 1/2" (24x86x1284) H9 (4) (2) NOTE: HOLES ARE CLOSER TO THE INSIDE WHEN INSTALLED. (4) BOLT HEX 5/16x2 H100044 (2) WASHER LOCK EXT 8x19 H100030 (8) T-NUT 5/16 H100074 BOLT WH 5/16x1 1/2 H100010 WASHER SPLIT 5/16 H100095 (4) WASHER FLAT 8x27 H100105 H9 T-NUT 5/16 (4 PLCS) L BRACKET 51x32x82x3.
(1) K5 - CLUB HOUSE WALL RAIL - W4L04626 5/8"x5 1/4"x50 1/4" (16x134x1277) (1) H14 - SWING BEAM MOUNT - W4L04628 1"x3 3/8"x50 1/4" (24x86x1277) FORT ASSEMBLY STEP 28 (2) WASHER LOCK EXT 8x19 (6 PLCS) BOLT WH 5/16x3 3/4 H100019 (4) (4) SCREW PFH 8x1-3/4" H100089 (2) LAG SCREW WH 5/16x2 H100027 BOLT WH 5/16x1 1/2 H100010 (8) WASHER LOCK EXT 8x19 H100030 (4) T-NUT 5/16 H100074 LAG SCREW WH 5/16x2 (4 PLCS) T-NUT 5/16 (2 PLCS) BOLT WH 5/16x1 1/2 (2 PLCS) K5 NOTE HOLE LOCATIONS H14 WASHER LOC
(1) LADDER ASSEMBLY FORT ASSEMBLY STEP 29 (2) BOLT WH 5/16x1 3/4 H100011 (2) WASHER LOCK EXT 8x19 H100030 (2) T-NUT 5/16 H100074 NUT BARREL WH 5/16x7/8 (4 PLCS) WASHER LOCK EXT 8x19 (4 PLCS) BOLT WH 5/16x1 3/4 (4 PLCS) 87
(1) (1) H4 - ROOF SUPPORT RAIL - W4L04623 1"x3 3/8"x67 1/4" (24x86x1709) H7 - FRONT CLUB HOUSE WALL RAIL - W4L04625 1"x3 3/8"x60 1/2" (24x86x1537) FORT ASSEMBLY STEP 30 (4) BOLT WH 5/16x3 3/4 H100019 BOLT WH 5/16x3 3/4 (4 PLCS) WASHER LOCK EXT 8x19 (4 PLCS) T-NUT 5/16 (4 PLCS) H4 H7 88 (4) T-NUT 5/16 H100074 (4) WASHER LOCK EXT 8x19 H100030
1 1/2 in (1) L BRACKET 2.
(1) H13 - CLUB HOUSE WALL RAIL - W4L04624 1"x3 3/8"x50 1/4" (24x86x1277) FORT ASSEMBLY STEP 32 (2) LAG SCREW WH 5/16x2 H100027 H13 (2) WASHER LOCK EXT 8x19 H100030 LAG SCREW WH 5/16x2 (2 PLCS) WASHER LOCK EXT 8x19 (2 PLCS) 90
(1) L BRACKET 2.5x38x50x55 A100340 (1) H10 - PORCH LEG - W4L04683 1"x3 3/8"x50 1/2" (24x86x1282) (1) H11 - PORCH LEG - W4L04610 1"x3 3/8"x50 1/2" (24x86x1282) NOTE: HOLES GO OUTWARD WHEN INSTALLED. FORT ASSEMBLY STEP 33 (2) BOLT WH 5/16x1 3/4 H100011 (1) (3) BOLT WH 5/16x1 1/2 H100010 WASHER LOCK EXT 8x19 H100030 (2) (1) BOLT WH 5/16x1/2 H100115 WASHER LOCK EXT 12x19 H100031 (1) (4) NUT BARREL WH 5/16x7/8 H100005 T-NUT 5/16 H100074 NOTE: HOLES GO OUTWARD.
(2) (2) M8 - CLUB HOUSE WALL BOARD - W4L04630 5/8"x3 3/8"x50 1/2" (16x86x1284) N1 - CLUB HOUSE WALL BOARD - W4L04629 5/8"x2 3/8"x50 1/2" (16x60x1284) (4) M9 - CLUB HOUSE WALL BOARD - W4L04631 (2) 5/8"x3"x50 1/2" (16x76x1284) M23 - CLUB HOUSE WALL BOARD - W4L04634 (2) 5/8"x3 1/8"x29 7/8" (16x80x758) M22 - CLUB HOUSE WALL BOARD - W4L04633 5/8"x3 3/8"x29 7/8" (16x86x758) FORT ASSEMBLY STEP 34 (56) SCREW PFH 8x1-1/8" (56 PLCS) N1 M22 M8 M9 M9 M23 M8 N1 M22 92 SCREW PFH 8x1-1/8" H100088
(2) M26 - WALL BOARD - W4L04636 5/8"x3 3/8"x26 1/8" (16x86x664) (6) (1) M24 - WALL BOARD - W4L04632 5/8"x3 3/8"x29 7/8" (16x86x758) M6 - CLUB HOUSE WALL BOARD - W4L04635 5/8"x3 3/8"x53 7/8" (16x86x1370) FORT ASSEMBLY STEP 35 (38) M26 SCREW PFH 8x1-1/8" (38 PLCS) M6 M24 93 SCREW PFH 8x1-1/8" H100088
(5) M8 - CLUB HOUSE WALL BOARD - W4L04630 5/8"x3 3/8"x50 1/2" (16x86x1284) (2) (2) M33 - FRONT WINDOW WALL BOARD - W4L04638 5/8"x3 3/8"x6 3/8" (16x86x162) M17 - FRONT WINDOW WALL BOARD - W4L04639 5/8"x3 3/8"x35" (16x86x889) FORT ASSEMBLY STEP 36 (35) SCREW PFH 8x1-1/8" (35 PLCS) M8 M33 M8 M17 94 SCREW PFH 8x1-1/8" H100088
(13) M24 - WALL BOARD - W4L04632 5/8"x3 3/8"x29 7/8" (16x86x758) FORT ASSEMBLY STEP 37 (52) SCREW PFH 8x1-1/8" H100088 SCREW PFH 8x1-1/8" (52 PLCS) 13 PLCS M24 95
(4) M24 - WALL BOARD - W4L04632 5/8"x3 3/8"x29 7/8" (16x86x758) FORT ASSEMBLY STEP 38 (16) SCREW PFH 8x1-1/8" H100088 2 5/8 in EQUAL SPACING SCREW PFH 8x1-1/8" (16 PLCS) M24 96
(2) BAY WINDOW ASSEMBLY FORT ASSEMBLY STEP 39 (20) SCREW PFH 8x2 H100111 (24) SCREW PWH 8x5/8 H100128 SCREW PWH 8x5/8 (24 PLCS) BAY WINDOW ASSEMBLY SCREW PFH 8x2 (20 PLCS) BAY WINDOW ASSEMBLY 97
(1) FORT ASSEMBLY STEP 40 - WINDOW 216x267 GREEN - A100146 WINDOW 216x267 GREEN (1 PLC) (4) SCREW PWH 8x3/4 (4 PLCS) 98 SCREW PWH 8x3/4 H100070
(2) - LADDER RUNG 629 GREEN - A100324 FORT ASSEMBLY STEP 41 (2) (4) T-NUT 5/16 (2 PLCS) LADDER RUNG 629 GREEN (2 PLCS) BOLT WH 5/16x1 (4 PLCS) 99 T-NUT 5/16 H100074 BOLT WH 5/16x1 H100008
(4) H12 - ROOF RAFTER - W4L04640 1"x3 3/8"x50 3/8" (24x86x1278) FORT ASSEMBLY STEP 42 (4) H4 1 in USING A 3/16" DRILL BIT, MARK AND DRILL A PILOT HOLE INTO 'H12' RAFTER TO PREVENT SPLITTING. ONLY DRILL THROUGH ONE RAFTER NOT BOTH.
(2) M5 - GABLE BOARD - W4L04641 5/8"x3 3/8"x59 1/2" (16x86x1510) (2) M7 - GABLE BOARD - W4L04642 5/8"x3 3/8"x52 5/8" (16x86x1338) FORT ASSEMBLY STEP 43 (8) SCREW PFH 8x1-1/8" H100088 SCREW PFH 8x1-1/8" (8 PLCS) M7 M5 M7 101 M5
(2) N6 - WINDOW TRIM - W4L04646 5/8"x2 3/8"x12 1/4" (16x60x310) (2) (1) (2) M29 - GABLE WINDOW BOARD - W4L04643 5/8"x3 3/8"x16 1/8" (16x86x410) (2) M28 - GABLE WINDOW BOARD - W4L04647 5/8"x3 3/8"x19 1/2" (16x86x496) M31 - GABLE WINDOW BOARD - W4L04644 5/8"x3 3/8"x12 3/4" (16x86x324) N10 - GABLE BOARD - W4L04645 5/8"x2 3/8"x27 5/8" (16x60x702) FORT ASSEMBLY STEP 44 (18) 1 in 1 in SCREW PFH 8x1-1/8" H100088 1 3/8 in SCREW PFH 8x1-1/8" (18 PLCS) 6 7/8 in N6 M31 N10 M31 M29 M29 M28 M28 102
(1) N10 - GABLE BOARD - W4L04645 5/8"x2 3/8"x27 5/8" (16x60x702) (1) M14 - GABLE BOARD - W4L04651 5/8"x3 3/8"x39 1/8" (16x86x994) (1) M18 - GABLE BOARD - W4L04652 5/8"x3 3/8"x32 3/8" (16x86x822) (1) M12 - GABLE BOARD - W4L04650 5/8"x3 3/8"x45 7/8" (16x86x1166) FORT ASSEMBLY STEP 45 (8) NOTE HOLE LOCATIONS SCREW PFH 8x1-1/8" (8 PLCS) N10 M18 M14 M12 103 SCREW PFH 8x1-1/8" H100088
(2) N7 - GABLE TRIM - W4L04648 5/8"x2 3/8"x11 1/2" (16x60x292) (4) N9 - GABLE TRIM - W4L04649 5/8"x2 3/8"x6 1/2" (16x60x165) (2) K6 - TRIANGLE SUNBURST - W4L04827 5/8"x5 1/4"x10 3/8" (16x134x265) FORT ASSEMBLY STEP 46 (22) SCREW PFH 8x1-1/8" H100088 1 1/8 in N7 SCREW PFH 8x1-1/8" (22 PLCS) N9 N9 K6 104
(1) - WINDOW 216x267 GREEN - A100146 FORT ASSEMBLY STEP 47 (4) WINDOW 216x267 GREEN (1 PLC) SCREW PWH 8x3/4 (4 PLCS) 105 SCREW PWH 8x3/4 H100070
(1) (1) M11 - SOFFIT CAP - W4L04653 5/8"x3 3/8"x50 1/4" (16x86x1277) N2 - SOFFIT CAP - W4L04654 5/8"x2 3/8"x50 1/4" (16x60x1277) FORT ASSEMBLY STEP 48 (6) N2 SCREW PFH 8x1-1/2" (6 PLCS) M11 106 SCREW PFH 8x1-1/2" H100086
(2) RP6 - ROOF PANEL - W2A02627 1 5/8"x15 5/8"x59" (42x396x1499) (1) RP3 - PEAK ROOF PANEL - W2A02626 1 5/8"x20 5/8"x59" (42x524x1499) FORT ASSEMBLY STEP 49 (14) NOTE: START WITH TOP PANEL FIRST. FLUSH EDGES.
(1) FORT ASSEMBLY STEP 50 TOP N3 - ROOF SUPPORT - W103535 5/8"x2 3/8"x47" (16x60x1193) 25 7/8 1 in 2 1/2 SCREW PFH 8x1-1/8" (9 PLCS) N3 108 (9) SCREW PFH 8x1-1/8" H100088
FORT ASSEMBLY STEP 51 REPEAT STEPS 48 & 49 TO ATTACH LEFT SIDE ROOF PANELS.
(1) PORCH ROOF ASSEMBLY FORT ASSEMBLY STEP 52 (1) (1) BOLT WH 5/16x2 3/4 H100015 (2) BOLT WH 5/16x1 3/4 H100011 (4) BOLT WH 5/16x2 1/2 H100014 (4) WASHER LOCK EXT 8x19 H100030 T-NUT 5/16 H100074 PORCH ROOF ASSEMBLY T-NUT 5/16 (2 PLCS) WASHER LOCK EXT 8x19 (2 PLCS) BOLT WH 5/16x2 1/2 (2 PLCS) BOLT WH 5/16x2 3/4 (1 PLC) T-NUT 5/16 (2 PLCS) BOLT WH 5/16x1 3/4 (1 PLC) WASHER LOCK EXT 8x19 (2 PLCS) 110
(1) FORT ASSEMBLY STEP 53 L BRACKET 51x32x82x3.175 A100396 (1) SWING BEAM ASSEMBLY L BRACKET 51x32x82x3.
(1) CROW'S NEST DECK ASSEMBLY FORT ASSEMBLY STEP 54 (2) (4) LAG SCREW WH 5/16x2 1/2 H100028 WASHER FLAT 8x27 H100105 WASHER SPLIT 5/16 (4 PLCS) (4) (4) NUT BARREL WH 5/16x7/8 H100005 WASHER SPLIT 5/16 H100095 (2) (4) BOLT HEX 5/16x1 1/4 H100042 WASHER LOCK EXT 8x19 H100030 (4) (2) SCREW PFH 8x1-1/2" H100086 WASHER LOCK EXT 12x19 H100031 WASHER FLAT 8x27 (4 PLCS) BOLT HEX 5/16x1 1/4 (4 PLCS) SCREW PFH 8x1-1/2" (2 PLCS) WASHER LOCK EXT 12x19 (4 PLCS) NUT BARREL WH 5/16x7/8 (4 PLCS) CROW'
(2) L BRACKET 51x32x82x3.175 A100396 FORT ASSEMBLY STEP 55 (8) LAG SCREW HEX 5/16x1-1/2 (8 PLCS) WASHER SPLIT 5/16 (8 PLCS) L BRACKET 51x32x82x3.
(2) F3 - CROWS NEST WALL SUPPORT - W4L11779 1 3/8"x2 3/8"x37 1/2" (36x60x952) (2) F2 - CROWS NEST WALL SUPPORT - W4L11780 1 3/8"x2 3/8"x37 1/2" (36x60x952) FORT ASSEMBLY STEP 56 (8) (4) F2 BOLT WH 5/16x2 3/4 H100015 (8) WASHER LOCK EXT 8x19 H100030 T-NUT 5/16 H100074 F3 NOTE HOLE ORIENTATIONS F2 T-NUT 5/16 (4 PLCS) F3 WASHER LOCK EXT 8x19 (8 PLCS) BOLT WH 5/16x2 3/4 (8 PLCS) 114
(2) H31 - CROWS NEST WALL RAIL - W4L11781 1"x3 3/8"x38 7/8" (24x86x988) (1) H30 - CROWS NEST WALL RAIL - W4L11782 1"x3 3/8"x29 7/8" (24x86x758) FORT ASSEMBLY STEP 57 (4) (4) LAG SCREW WH 5/16x2 1/2 H100028 (4) T-NUT 5/16 H100074 (8) BOLT WH 5/16x2 1/4 H100013 WASHER LOCK EXT 8x19 H100030 H31 T-NUT 5/16 (4 PLCS) H31 BOLT WH 5/16x2 1/4 (4 PLCS) WASHER LOCK EXT 8x19 (8 PLCS) LAG SCREW WH 5/16x2 1/2 (4 PLCS) H30 115
(2) L BRACKET 2.5x38x50x55 A100340 FORT ASSEMBLY STEP 58 (2) BOLT WH 5/16x1 (2 PLCS) L BRACKET 2.5x38x50x55 (2 PLCS) BOLT WH 5/16x1 H100008 (4) (2) BOLT WH 5/16x1/2 H100115 T-NUT 5/16 H100074 T-NUT 5/16 (4 PLCS) BOLT WH 5/16x1/2 (2 PLCS) USING BRACKETS AS A GUIDE, DRILL 3/8" HOLES THROUGH WALL BOARD.
(2) M4 - CROWS NEST WALL RAIL - W4L11773 5/8"x3 3/8"x29 7/8" (16x86x758) (1) H30 - CROWS NEST WALL RAIL - W4L11782 1"x3 3/8"x29 7/8" (24x86x758) (2) H29 - CROWS NEST WALL RAIL - W4L11783 1"x3 3/8"x30 5/8" (24x86x778) FORT ASSEMBLY STEP 59 (4) BOLT WH 5/16x2 1/4 H100013 (4) (16) M4 LAG SCREW WH 5/16x2 1/2 H100028 WASHER LOCK EXT 8x19 H100030 (8) (4) LAG SCREW WH 5/16x2 H100027 T-NUT 5/16 H100074 LAG SCREW WH 5/16x2 (8 PLCS) T-NUT 5/16 (4 PLCS) H29 BOLT WH 5/16x2 1/4 (4 PLCS) WASHER LOCK EXT
1 1/8 (2) 1 3/4 M32 - CROWS NEST WALL RAIL - W4L04671 5/8"x3 3/8"x10" (16x86x254) (2) L BRACKET 2.5x38x50x55 A100340 FORT ASSEMBLY STEP 60 (2) M32 USING BRACKETS AS A GUIDE, DRILL 3/8" HOLES THROUGH WALL (2) (6) BOLT WH 5/16x2 H100012 BOLT WH 5/16x1/2 H100115 T-NUT 5/16 H100074 T-NUT 5/16 (6 PLCS) BOLT WH 5/16x1/2 (2 PLCS) L BRACKET 2.
(2) N4 - CROWS NEST WALL BOARD - W4L04673 5/8"x2 3/8"x19" (16x60x483) FORT ASSEMBLY STEP 61 (4) SCREW PFH 8x1-1/8" (4 PLCS) 3 in N4 119 SCREW PFH 8x1-1/8" H100088
(6) FORT ASSEMBLY STEP 62 O1 - CROWS NEST WALL BOARD - W4L04672 5/8"x1 3/8"x32 1/2" (16x34x825) 2 3/4 in EQUAL SPACING (12) O1 6 PLCS SCREW PFH 8x1-1/8" (12 PLCS) 120 SCREW PFH 8x1-1/8" H100088
(12) FORT ASSEMBLY STEP 63 O1 - CROWS NEST WALL BOARD - W4L04672 5/8"x1 3/8"x32 1/2" (16x34x825) 2 1/2 in EQUAL SPACING (24) O1 12 PLCS SCREW PFH 8x1-1/8" (24 PLCS 121 SCREW PFH 8x1-1/8" H100088
(1) F1 - TELESCOPE MOUNTING BLOCK - W4L04674 1 3/8"x2 3/8"x3" (36x60x76) (1) TELESCOPE - A100104 FORT ASSEMBLY STEP 64 (1) (1) SCREW TAPPING 14x2-1/2 H100082 (2) SCREW PFH 8x2 1/4 H100091 TELESCOPE SCREW TAPPING 14x2-1/2 (1 PLCS) FLANGE CUP WASHER (1 PLCS) F1 SCREW PFH 8x2 1/4 (2 PLCS) 122 FLANGE CUP WASHER H100225
(4) - HAND GRIP METAL GREEN 381 c/c - A100118 FORT ASSEMBLY STEP 65 (4) (4) (4) LAG SCREW WH 5/16x1 1/2 (4 PLCS) T-NUT 5/16 (4 PLCS) HAND GRIP METAL GREEN 381 c/c (4 PLCS) BOLT WH 5/16x1 (4 PLCS) 123 LAG SCREW WH 5/16x1 1/2 H100026 BOLT WH 5/16x1 H100008 T-NUT 5/16 H100074
(1) ROCK WALL ASSEMBLY FINAL ASSEMBLY STEP 1 (2) BOLT WH 5/16x1 1/2 H100010 (2) WASHER LOCK EXT 8x19 H100030 M WASHER LOCK EXT 8x19 (2 PLCS) ROCK WALL ASSEMBLY BOLT WH 5/16x1 1/2 (2 PLCS) 124
(1) MONKEY BAR ASSEMBLY FINAL ASSEMBLY STEP 2 (4) T-NUT 5/16 H100074 (4) T-NUT 5/16 (4 PLCS) BOLT WH 5/16x1 H100008 BOLT WH 5/16x1 (4 PLCS) MONKEY BAR ASSEMBLY 125
(1) SLIDE FINAL ASSEMBLY STEP 3 NOTE: CENTER SLIDE IN OPENING. USING DIMENSIONS BELOW AS A TEMPLATE, DRILL (3) 3/8" HOLES THROUGH DECK FOR HARDWARE.
(1) SS - "C" REVISION TAG - A100316 FINAL ASSEMBLY STEP 4 (2) "C" REVISION TAG (1 PLC) SCREW PWH 8x5/8 (2 PLCS) 127 SCREW PWH 8x5/8 H100128
(8) FA - QUICK LINK - A100069 (2) DP - SWING SEAT GREEN - A100027 (4) HW - CHAIN GREEN 44" - A100048 (4) EF - CHAIN GREEN 57" - A100047 (1) GLIDER FINAL ASSEMBLY STEP 5 TIGHTEN QUICK LINK INSERT CHAIN INTO QUICK LINK CHAIN GREEN 44" (4 PLCS) CHAIN GREEN 57" (4 PLCS) QUICK LINK (8 PLCS) GLIDER SWING SEAT GREEN (2 PLCS) 128
(2) (8) KC - METAL GROUND STAKE BROWN - A100178 - GROUND STAKE REBAR - A4M00527 FINAL ASSEMBLY STEP 6 DETAIL "A" & "B" TWIST STAKES INTO GROUND AGAINST GROUND BOARDS AND CORNER POSTS IN LOCATIONS SHOWN. USING STAKE AS A TEMPLATE, DRILL A 3/16" HOLE FOR LAGS. (8) DETAIL "C" DRIVE STAKE INTO GROUND AT LOCATIONS SHOWN. USING STAKE AS A TEMPLATE, DRILL A 7/16" HOLE FOR HARDWARE. (1) DETAIL "D" DRIVE STAKE INTO GROUND AT LOCATIONS SHOWN. USING STAKE AS A TEMPLATE, DRILL A 7/16" HOLE FOR HARDWARE.
Limited Warranty This Limited Warranty by Backyard Discovery applies to products manufactured under the Backyard Discovery brand or its other brands including but not limited to Backyard Botanical, Adventure Playsets, and Leisure Time Products. Backyard Discovery warrants that this product is free from defect in materials and workmanship for a period of one (1) year from the original date of purchase. This one (1) year warranty covers all parts including wood, hardware, and accessories.
NOTES: 131
NOTES: 132
