R Commercial Service Training Manual RCS / MCS Models RCS / MCS - 60 Hz August 2012 16400020 ® / ™ © 2012 Amana. All rights reserved. Brand used under license.
Table of Contents Important Safety Information........................................................................................3-6 Installation.......................................................................................................................7 !"#$%#&'$()*++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++++, Quick Start Reference Guide (Electronic Mechanical Dial)............................................
Important Information Important Notices for Servicers and Consumers ACP will not be responsible for personal injury or property damage from improper service procedures. Pride and workmanship go into every product to provide our customers with quality products. It is possible, however, that during its lifetime a product may require service.
Important Safety Information ! WARNING Read the following information to avoid possible exposure to microwave radiation: The basic design of the Microwave Oven makes it an inherently safe device to both use and service. However, there are some precautions which should be followed when servicing the microwave to maintain this safety. These are as follows: 1. Always operate the unit from an adequately grounded outlet. Do not operate on a two-wire extension cord. 8.
IMPORTANT SAFETY INSTRUCTIONS This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death. ! WARNING When using electrical equipment, basic safety precautions should be followed to reduce the risk of burns, "<"#'3$#&53?/'(/!"3*()*/$)#<54$)1/':"/K(<<(P$)1+/ 1. READ all instructions before using equipment. 9. DO NOT heat baby bottles in oven.
IMPORTANT SAFETY INSTRUCTIONS WARNING WARNING 0(/&;($4/3$*M/(K/%3"/$)/':"/(;")/#&;$'?Q Liquids such as water, coffee, or tea are able to be overheated beyond the boiling point without appearing to be boiling due to surface tension of the liquid. Visible bubbling or boiling when the container is removed from the microwave oven is not always present. THIS COULD RESULT IN VERY HOT LIQUIDS SUDDENLY BOILING OVER WHEN A SPOON OR OTHER UTENSIL IS INSERTED INTO THE LIQUID.
Installation WARNING Unpacking Oven S/ T)*!"#'/(;")/K(3/4&.&1"/*5#:/&*/4")'*/$)/4((3/(3/ dents inside oven cavity. S/ C"!(3'/&)?/4")'*/(3/=3"&M&1"/'(/*(53#"/(K/!53#:&*"/ immediately. Do not attempt to use oven if damaged. S/ C".(;"/&<
!"#$%#&'$()* Models RCS10DSE, MCS10DSE, RCS10TS, MCS10TS Power Source Voltage AC Amperage Frequency Single Phase, 3 wire grounded 2<51/-()%153&'$()/W/-(34/ Power Output Nominal microwave energy (IEC705) Minimum temperature rise Operating Frequency Power Consumption Cook Condition Microwave Dimensions Cabinet Width Height Depth Cavity Dimensions Width Height Depth Weight Crated Uncrated 120V 15 A 60 Hz X NEMA 5-20 1000 W 10°F / 5°C 2450 MHz 1550 W 22” (560) 13 ¾” (349) 68X/YN,BZ 14 ½X/Y[\,Z ,/½” (216) 6
Quick Start Reference Guide (Electronic / Mechanical Dial) Oven Wall Clearances Menu Guide A—For North American (UL/CSA) models, allow at least 2” (5.1 cm) of clearance around top of oven. For International (50 Hz) models, allow at least 12” (30 cm) of clearance A B 2:00 :15 1:00 - 2:00 :45 :30 1:30 - 2:30 0 oven cools electrical components. With C properly and life of electrical parts is reduced. B—Allow at least 2” (5.1 cm) between air discharge on back of oven and back wall.
Quick Start Reference Guide (Electronic Control) Oven Wall Clearances A—For North American (UL/CSA) models, allow at least 2” (5.1 cm) of clearance around top of oven. For International (50 Hz) models, allow at least 12” (30 cm) of clearance around top of oven. Proper air ;!3",1!'*&"!5.*"#!!4(".4.#01)#,4"#!2-!*.*0(="O)0<" 1.(01)#0.&",)1";!3?"!5.*"2,9"*!0"!-.1,0."-1!-.149",*&" life of electrical parts is reduced. B—Allow at least 2” (5.1 cm) between air discharge on back of oven and back wall.
Quick Start Reference Guide (Electronic Control) Can I change an option? Options such as single or double pad programming, beep volume, and maximum cooking time can be changed to suit individual preferences. To change options: 1. Open oven door. pad is pressed before programming is 7" @%"&!!1")("#4!(.&"!1"P QMRDBPB " complete, changes are discarded and microwave exits programming mode. 2. Press and hold pad 2 for approximately 5 seconds. 7" <)(":.+)*("!-0)!*("2!&.= 7" A)#1!3,5."3)44":..-",*&"0P: displays.
Components Location (Oven Cavity) 19 2 3 1 20 4 5 25 18 7 6 8 17 27 9 22 23 16 13 12 14 15 10 21 11 26 24 Reference 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 Part Number 12002625 54127062 54127037 54127062 56002013 B5667304 14114048 54127038 54116025 54127064 54127061 54127015 54127001 54127011 54127064 54127061 54127029 54127019 54127045 54127064 54127042 53001724 20036801 R0000413 54116064 54116021 54127066 12 Description KIT, COVER / STIRRER BLADE/ RIVETS S
Components Location (Blower / Interlock) 6 7 5 3 4 2 1 12 8 11 10 9 1 14 15 13 16 Reference 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Part Number 54116017 54127039 54127049 54116017 54116017 54127009 54116017 54127048 54116017 54127040 54127036 20034003 54127065 54127056 56112070 54127059 Description SCREW DUCT, MAG LAMP / SOCKET ASSY SCREW SCREW INTERLOCK SWITCH ASSY SCREW POWER CORD SCREW BRKT, INLET AIR FUSE BLOCK / FILTER ASSY FUSE SCREW MOTOR, BLOWER & BLADE BLADE, FAN BRKT, BLOWER 13 Qu
Components Location (Dial Control) 2 1 3 4 5 6 7 Reference 1 2 2 3 3 4 5 6 7 Part Number 54127053 54127002 54127004 54127031 54127054 54127067 54127030 54127067 54127032 Description KNOB ESC / TOUCH PANEL ASSY (RCS10DSE) ESC / TOUCH PANEL ASSY (MCS10DSE) BOARD, LED (RCS10DSE) BOARD, LED (MCS10DSE) SCREW BOARD, HV / LV SCREW HARNESS, PCB 14 Quantity 1 1 1 1 1 5 1 4 1
Components Location (Electronic Control) 1 2 3 Reference 1 1 2 3 Part Number 54127003 54127005 54127033 54127067 Description ESC / TOUCH PANEL ASSY (RCS10TS) ESC / TOUCH PANEL ASSY (MCS10TS) BOARD, HV / LV SCREW 15 Quantity 1 1 1 4
Components Location (Door) 4 7 6 5 1 2 8 3 Reference 1 1 2 3 4 5 6 7 8 Part Number 54127021 54127023 14124068 14124069 54127027 54127028 54127061 54127064 54127063 Description DOOR ASSY (RCS10*) DOOR ASSY (MCS10*) KIT, SPRING/LATCH/CHOKE COVER KIT, DOOR HANDLE WINDOW, INNER HINGE, UPPER SCREW SCREW SCREW 16 Quantity 1 1 1 1 1 1 2 1 2
Performance Testing Procedures ! WARNING To avoid risk of electrical shock, personal injury or death, disconnect power to oven and discharge capacitor before servicing, unless testing requires it. All Amana and Menumaster microwave oven power outputs are rated using the IEC705 standards. Using the IEC705 test method requires precision measurements and equipment that is not practical to be performed in the field. Using the test shown below will indicate if the oven performance is satisfactory.
Component Testing Procedures ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. I l l u s tr a ti o n C o m po n en t Thermal cutout Diode Capacitor T e s ti n g R e s u l ts Disconnect all wires from TCO. Measure resistance across terminals. Cavity TCO ................................................................ Opens at 212ºF (100ºC) Magnetron TCO ..............................
Component Testing Procedures ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. I l l u s tr a ti o n C o m po n en t Fuse block / Filter assembly Interlock switch assembly (Mechanical) 1 2 PRIMARY INTERLOCK SWITCH 3 4 MONITOR INTERLOCK SWITCH 5 6 SECONDARY INTERLOCK SWITCH T e s ti n g R e s u l ts Power In terminals ......................................................
Troubleshooting Service Diagnostics Control does not power up 12"34 5%6 +/)" (%+78-" 9"7:"") 72" :2/7" 8). 9+834 :/6" %) 72" /)+"7 #/." %5 72" 5/+7"6 9%86.; !"# &# '(") *+,--". /)0 $% !"# 12"34 5%6 +/)" (%+78-" 9"7:"") 72" 9+,"<:2/7" 8). 9+834 :/6"# %) 72" %,7+"7 #/." %5 72" 5/+7"6 9%86.; 12"34 5,#" %) 5/+7"6 9%86. 8). 6"=+83" 8# )"".".; $% !"# G"=+83" .
Troubleshooting Service Diagnostics !"#$!%&'!()$*&+',&-+#&"!&.)/#& 0.)"&#.)&!1)"&2*&'%+33)4&2"&2*&#.)$)&& 55&5555&*.!(2"3&2"&#.)&42*'%/6& No 7))&*)$128)&42/3"!*#28*&9& "!&'!()$& Yes :')"&4!!$,&4!)*&!1)"&%23.#&/"4& ;/"&8!<)&!"& .)8=&4!!$&*(2#8.&/**)<-%6,& /4>+*#&!$&$)'%/8)&/*&"))4)4?& No Yes %!*)&4!!$&/"4&8!"#$!%& *.!+%4&*/6&$)/46& .)8=&4!!$&*(2#8.&/**)<-%6,&/4>+*#&!$& $)'%/8)&/*&"))4)4?& No Yes @+*.<)&=)6,&)"#)$A&BC&*)8!"4*& .
Schematic / Wiring Diagram RCS10* / MCS10* 22
Notes: 23
Part No. 16400020 !"#$%&'"#'()*)+)',-./0 www.acpsolutions.com 2012 ACP Inc.
