EN User Manual Oven ZOG10311XK EG
Contents Safety information Safety instructions Product description Before first use Daily use Clock functions Using the accessories 2 3 5 6 6 7 7 Additional functions Hints and tips Care and cleaning Troubleshooting Installation Technical data 9 9 14 16 17 21 Subject to change without notice. Safety information Before the installation and use of the appliance, carefully read the supplied instructions.
• • • • • • • • WARNING: The appliance and its accessible parts become hot during use. Care should be taken to avoid touching heating elements. Children less than 8 years of age shall be kept away unless continuously supervised. Always use oven gloves to remove or put in accessories or ovenware. Before maintenance cut the power supply. Ensure that the appliance is switched off before replacing the lamp to avoid the possibility of electric shock. Do not use a steam cleaner to clean the appliance.
• • • • • • • • must be carried out by our Authorised Service Centre. Do not let mains cables touch or come near the appliance door, especially when the door is hot. The shock protection of live and insulated parts must be fastened in such a way that it cannot be removed without tools. Connect the mains plug to the mains socket only at the end of the installation. Make sure that there is access to the mains plug after the installation. If the mains socket is loose, do not connect the mains plug.
Care and cleaning WARNING! Risk of electrical shock. WARNING! Risk of injury, fire, or damage to the appliance. • Before maintenance, deactivate the appliance and disconnect the mains plug from the mains socket. Make sure the appliance is cold. There is the risk that the glass panels can break. Replace immediately the door glass panels when they are damaged. Contact the Authorised Service Centre. Be careful when you remove the door from the appliance.
• • Aluminium baking tray For cakes and biscuits. Turnspit For roasting larger joints of meat and poultry. Before first use Clean the appliance and the accessories before first use. Put the accessories and the removable shelf supports back to their initial position. WARNING! Refer to Safety chapters. Oven cavity bottom plate When you buy the appliance, at first the oven cavity bottom plate is positioned on the accessories.
Knob for the gas control Symbol Function Heat only from the bottom of the oven. Range of temperature adjustment (150 °C 250 °C). Heats from the top. Ignition of oven gas burner Oven safety device: The gas oven has a thermocouple. It stops the gas flow if the flame goes out. 1. Press the knob for the gas control and turn it to . 2. Keep the knob for the gas control pushed for 15 seconds or less to let the thermocouple warm up. If not, the gas flow is interrupted.
Using the turnspit WARNING! Be careful when you use the turnspit. The forks and the spit are sharp. There is a risk of injury. WARNING! Use oven gloves when you remove the turnspit. The turnspit and the grill are hot. There is a risk of burns. A B C D A. B. C. D. Turnspit frame Forks Spit Handle 1. Put the turnspit handle into the spit. 2. Put the deep pan on the lowest shelf position. 3. Put the spit frame on the third shelf position from the bottom. 5. Use the screws to tighten the forks. 6.
Wire shelf and baking tray together: Small indentation at the top increase safety. The indentations are also anti-tip devices. The high rim around the shelf prevents cookware from slipping of the shelf. Push the baking tray between the guide bars of the shelf support and the wire shelf on the guide bars above. Additional functions Cooling fan When the appliance operates, the cooling fan activates automatically to keep the surfaces of the appliance cool.
Cooking tables Preheat the empty oven for 10 minutes before cooking. Casseroles Food Quantity (kg) Shelf position Temperature (°C) Time (min) Lasagna 1.5 - 2.5 4 180 45 - 50 Cannelloni 1.5 - 2.5 4 180 45 - 50 Potato gratin 1.5 - 2.5 4 180 33 - 40 Macaroni oven 1.5 - 2.5 4 180 45 - 50 Kebab Hala 1.5 - 2.5 4 190 35 - 40 Meat Food Quantity (kg) Shelf position Temperature (°C) Time (min) Sheep 1.7 3 180 - 200 80 - 100 Chicken 1 - 1.8 3 220 - 230 80 - 90 Duck 1.
Grilling Food Quantity (kg) Shelf position Time (min) Burgers1) 0.6 (6 pieces) 4 20 - 30 Toast browning1) 0.5 4 9 - 12 Toast Hawai1) 6 pieces 4 7 - 14 1) Preheat the oven for 3 minutes. Gas oven cooking The time does not include preheating. Always preheat the empty oven for 10 minutes. Meat & Poultry Food Quantity (kg) Temperature (°C) Time (min) Shelf position Comments Beef with bone 1 min. 50 - 65 3 On the wire shelf. Put a deep pan on the second shelf position.
Food Quantity (kg) Temperature (°C) Time (min) Shelf position Comments Duck 1 190 90 - 100 3 On the wire shelf. Put a deep pan on the second shelf position. Turkey 4,5 - 5,5 160 220 - 250 2 In a deep pan. Baked vegetables 1 160 - 3 Varies according to the vegetable. Pastry Food Quantity (kg) Temperature (°C) Time (min) Shelf position Comments Fruit tart - 165 50 - 60 4 In a 26 cm round mould on the wire shelf Fruit pie - min.
Cakes Food Quantity (kg) Temperature (°C) Time (min) Shelf position Comments Rich fruit cake - min. 160 - 170 4 In a 20 cm mould on the wire shelf Plain fruit cake - min. 160 - 170 4 In a 20 cm mould on the wire shelf Madeira - min. 115 - 130 4 In a 20 cm mould on the wire shelf Small cake - min. - 170 40 - 65 4 In an aluminium baking tray Ginger bread - min.
Food Quantity Pieces Time (min) (g) 1st side Shelf position 2nd side Chicken (cut in 2) 2 1000 35 - 40 30 - 35 4 Kebabs 4 - 15 - 20 12 - 15 4 Breast of chick- 4 en 400 13 - 15 13 - 15 4 Hamburger 6 600 13 - 16 12 - 15 4 Fish fillet 4 400 13 - 15 12 - 14 4 Toasted sandwiches 4-6 - 5-7 - 4 Toast 4-6 - 2-4 2-3 4 Turnspit Preheat the empty oven for 10 minutes before cooking. Use the turnspit with the bottom oven burner.
• To clean the door gasket, refer to the general information about cleaning. 4 Put the door on a soft cloth on a stable surface. Removing the shelf supports To clean the oven, remove the shelf supports. 1. Pull the front of the shelf support away from the side wall. 3 Close the oven door halfway to the first opening position. Then pull forward and remove the door from its seat. 2. Pull the rear end of the shelf support away from the side wall and remove it.
Make sure that you install the internal glass panel in the seats correctly. CAUTION! Always hold the halogen lamp with a cloth to prevent grease residue from burning on the lamp. A 1. Deactivate the appliance. 2. Remove the fuses from the fuse box or deactivate the circuit breaker. The back lamp Replacing the lamp Put a cloth on the bottom of the interior of the appliance. It prevents damage to the lamp glass cover and the cavity. 1. Turn the lamp glass cover counterclockwise to remove it. 2.
Problem Possible cause Remedy The oven does not operate. The automatic ignition does not work. Ignite the burner manually with a long match. Hold the flame near the hole in the bottom of the oven cavity. At the same time push the knob for the gas control and turn it counterclockwise to the maximum temperature. When the flame comes on, keep the knob for the gas control pushed for 15 seconds or less to let the thermocouple warm up. If not, the gas flow is interrupted. The lamp does not operate.
The gas supply ramp is on the rear side of the appliance. WARNING! Do not use rubber flexible pipes! Do not fully put the oven into the built-in cabinet (approximately 30 cm). Connection with a flexible metallic pipe or a rigid metallic pipe: WARNING! Before you replace the injectors, make sure that the gas knobs are in the Off position. Disconnect the appliance from the electrical supply. Let the appliance cool down. There is a risk of injury. Gas grill injector replacement 1.
If the supply gas pressure is changeable or different from the necessary pressure, you must fit an applicable pressure adjuster on the gas supply pipe. BA Minimum level adjustment of the oven burner 2. Release the screw (C), which keeps the burner in position. 1. Disconnect the appliance from the electricity. 2. Turn the knob for the gas control to the minimum position and remove it. 3. Adjust the adjustment screw (A) with a thinbladed screwdriver. C A 3.
Control the flame. If the flame goes out, do the procedure again. There must be a small regular flame on the oven burner crown. The manufacturer objects liability if you do not obey to this safety measures. Only set up the appliance in a kitchen or in a kitchen-dining room. Do not set up the appliance in a bathroom or a bedroom. You can install the appliance "built-in" or "built-under". The dimensions of the built-in cabinet must agree with the related illustrations.
This appliance is supplied only with a main cable. Total power (W) Cable Cable types applicable for installation or replacement: H05 V2V2-F (T90), H05 BB-F For the section of the cable refer to the total power on the rating plate. You can also refer to the table: Total power (W) maximum 1380 Section of the cable (mm²) maximum 2300 3x1 maximum 3680 3 x 1.5 The earth cord (green / yellow cable) must be 2 cm longer than phase and neutral cables (blue and brown cables).
Gas grill burner Gas type NOMINAL GAS POWER (kW) NOMINAL GAS FLOW (g/h) Reduced gas power (kW) BY-PASS NEEDLE (1/100 mm) G20 (2H) 20 mbar 1.5 - - - G30 (3+) 28-30 mbar 1.65 120 - 43 G31 (3+) 37 mbar 1.65 118 - 43 INJECTOR MARK (1/100 mm) 90 ENVIRONMENTAL CONCERNS appliances marked with the symbol with the household waste. Return the product to your local recycling facility or contact your municipal office. Recycle the materials with the symbol .
www.zanussi.
867339329-A-342016 www.zanussi.