User Manual GETTING STARTED? EASY.
SAFETY INFORMATION Before the installation and use of the appliance, carefully read the supplied instructions. The manufacturer is not responsible for any injuries or damages that are the result of incorrect installation or usage. Always keep the instructions in a safe and accessible location for future reference.
• • • • • • • • • • • NEVER try to extinguish a fire with water, but switch off the appliance and then cover flame e.g. with a lid or a fire blanket. CAUTION: The cooking process has to be supervised. A short term cooking process has to be supervised continuously. WARNING: Danger of fire: Do not store items on the cooking surfaces. Metallic objects such as knives, forks, spoons and lids should not be placed on the hob surface since they can get hot. Do not use a steam cleaner to clean the appliance.
SAFETY INSTRUCTIONS This appliance is suitable for the following markets: • GB IE INSTALLATION WARNING! Only a qualified person must install this appliance. WARNING! Risk of injury or damage to the appliance. • • • • • • • • • • • • Remove all the packaging. Do not install or use a damaged appliance. Follow the installation instructions supplied with the appliance. Keep the minimum distance from other appliances and units. Always take care when moving the appliance as it is heavy.
• • The information about the gas supply is on the rating plate. This appliance is not connected to a device, which evacuates the products of combustion. Make sure to connect the appliance according to current installation regulations. Pay attention to requirements regarding adequate ventilation. USE • • • • • • • • • • • WARNING! Risk of injury, burns and electric shock. • • Remove all the packaging, labelling and protective film (if applicable) before first use.
DISPOSAL WARNING! Risk of injury or suffocation. • Contact your municipal authority for information on how to discard the appliance correctly. • • • Disconnect the appliance from the mains supply. Cut off the mains electrical cable close to the appliance and dispose of it. Flat the external gas pipes. INSTALLATION WARNING! Refer to Safety chapters. BEFORE THE INSTALLATION Before you install the hob, write down the information bellow from the rating plate. The rating plate is on the bottom of the hob.
Connection to the gas supply should be with either rigid or semi-rigid pipe, i.e. steel or copper. The connection should be suitable for connecting to R 1/2 (1/2 BSP male thread). When the final connection has been made, it is essential that a thorough leak test is carried out on the hob and installation. Make sure that the main connection pipe does not exert any strain on the hob. If you use flexible metal pipes make sure that they agree to ISO 10380 and ISO 10807 standards.
• • L — Live terminal N — Neutral terminal REPLACEMENT OF THE CONNECTION CABLE • or E — Earth terminal Before carrying out the connection, make sure: 1. The limiter valve and the electrical system can take the appliance load (see the rating plate) 2. The supply system is equipped with an efficient earth connection in compliance with the current standards and regulations 3. The outlet or omnipolar switch used for connection is easily accessible with the appliance installed.
ASSEMBLY 1. If a furniture unit is installed at a distance of 400 mm above the hob, there must be a minimum safety distance of 50 mm to the left or right from the edge of the hob. 5. 6. 2. A 3. B min. 600 mm min. 100 mm min. 650 mm 7. A) supplied seal B) supplied brackets min. 55 mm 30 mm 470 02 mm + 550+02 mm 4. 400 mm 50 mm CAUTION! Install the appliance only on a worktop with flat surface.
Kitchen unit with door or drawer A. Removable panel B. Space for connections Kitchen unit with oven The electrical connection of the hob and the oven must be installed separately for safety reasons and to let easy remove oven from the unit.
DAILY USE WARNING! Do not keep the control knob pushed for more than 15 seconds. If the burner does not light after 15 seconds, release the control knob, turn it into off position and try to light the burner again after minimum 1 minute. WARNING! Refer to Safety chapters.
HINTS AND TIPS WARNING! Refer to Safety chapters. COOKWARE CAUTION! Do not use cast iron pans, clay or earthenware pots, grill or toaster plates. WARNING! Do not put the same pan on two burners. CAUTION! Make sure that the pots are placed centrally on the burner in order to get the maximum stability and a lower gas consumption. CAUTION! Liquids spilt during cooking can cause the glass to break. DIAMETERS OF COOKWARE Use cookware with diameters applicable to the size of burners.
CLEANING THE HOB • Remove immediately: melted plastic, plastic foil, sugar and food with sugar, otherwise, the dirt can cause damage to the hob. Take care to avoid burns. • Remove when the hob is sufficiently cool: limescale rings, water rings, fat stains, shiny metallic discoloration. Clean the hob with a moist cloth and a non-abrasive detergent. After cleaning, wipe the hob dry with a soft cloth.
LABELS SUPPLIED WITH THE ACCESSORIES BAG Stick the adhesive labels as indicated below: A B MOD. MOD. PROD.NO. PROD.NO. SER.NO SER.NO DATA DATA C 0049 MOD. PROD.NO. SER.NO. TYPE IP20 03 IT MADE IN ITALY A. Stick it on Guarantee Card and send this part (if applicable). B. Stick it on Guarantee Card and keep this part (if applicable). C. Stick it on instruction booklet.
OTHER TECHNICAL DATA TOTAL POWER: Gas original: G20 (2H) 20 mbar 7,7 kW Gas replacement: G30 (3+) 28-30 mbar 545 g/h G31 (3+) 37 mbar 536 g/h Electric supply: 220-240 V ~ 50/60 Hz 3 core flexible cable with non rewireable plug fitted with a 3 amp cartridge fuse Appliance category: II2H3+ Gas connection: R 1/2" Appliance class: 3 GAS BURNERS FOR NATURAL GAS G20 20 mbar BURNER NORMAL POWER kW MINIMUM POWER kW INJECTOR MARK Rapid 2,9 0,75 119 Semi-rapid 1,9 0,45 96 Auxiliary 1,0 0
Energy efficiency per gas burner (EE gas burner) Left rear - Semi-rapid 54.9% Right rear - Semi-rapid 54.9% Left front - Rapid 57.5% Right front - Auxiliary not applicable Energy efficiency for the gas hob (EE gas hob) 55.8% EN 30-2-1: Domestic cooking appliances burning gas - Part 2-1 : Rational use of energy - General ENERGY SAVING • Before use, make sure that the burners and pan supports are assembled correctly. • Use cookware with diameters applicable to the size of burners.
867321989-D-402018 WWW.ZANUSSI.