User Manual GETTING STARTED? EASY.
SAFETY INFORMATION Before the installation and use of the appliance, carefully read the supplied instructions. The manufacturer is not responsible for any injuries or damages that are the result of incorrect installation or usage. Always keep the instructions in a safe and accessible location for future reference.
• • • • • • • • • NEVER try to extinguish a fire with water, but switch off the appliance and then cover flame e.g. with a lid or a fire blanket. CAUTION: The cooking process has to be supervised. A short term cooking process has to be supervised continuously. WARNING: Danger of fire: Do not store items on the cooking surfaces. Metallic objects such as knives, forks, spoons and lids should not be placed on the hob surface since they can get hot. Do not use a steam cleaner to clean the appliance.
• • • Do not install the appliance adjacent to a door or under a window. This prevents hot cookware falling from the appliance when the door or the window is opened. If the appliance is installed above drawers make sure that the space, between the bottom of the appliance and the upper drawer, is sufficient for air circulation. The bottom of the appliance can get hot. Make sure to install a non-combustible separation panel under the appliance to prevent access to the bottom.
• • Used oil, that can contain food remnants, can cause fire at a lower temperature than oil used for the first time. Do not put flammable products or items that are wet with flammable products in, near or on the appliance. • CARE AND CLEANING WARNING! Do not remove the buttons, knobs or gaskets from the control panel. Water may get inside the appliance and cause damage. WARNING! Risk of damage to the appliance. • • • • • • • • • • • • • • Do not keep hot cookware on the control panel.
PRODUCT DESCRIPTION COOKING SURFACE LAYOUT 1 2 1 Semi-rapid burner 2 Multi Crown burner 3 Auxiliary burner 4 Control knobs 3 4 CONTROL KNOB Symbol Symbol Description Description minimum gas supply no gas supply / off position ignition position / maximum gas supply DAILY USE WARNING! Refer to Safety chapters. A BURNER OVERVIEW B A C D B C D 6 A. B. C. D.
IGNITION OF THE BURNER Always light the burner before you put on the cookware. If the burner accidentally goes out, turn the control knob to the off position and try to light the burner again after minimum 1 minute. WARNING! Be very careful when you use open fire in the kitchen environment. The manufacturer declines any responsibility in case of the flame misuse. The spark generator can start automatically when you switch on the mains, after installation or a power cut. It is normal.
CAUTION! Make sure that pot handles are not above the front edge of the cooktop. CAUTION! Make sure that the pots are placed centrally on the burner in order to get the maximum stability and a lower gas consumption. Burner Diameter of cookware (mm) Multi Crown 180 - 260 Semi-rapid 120 - 220 Auxiliary 80 - 180 DIAMETERS OF COOKWARE Use cookware with diameters applicable to the size of burners. CARE AND CLEANING WARNING! Refer to Safety chapters. GENERAL INFORMATION • Clean the hob after each use.
• • dirt can cause damage to the hob. Take care to avoid burns. Remove when the hob is sufficiently cool: limescale rings, water rings, fat stains, shiny metallic discoloration. Clean the hob with a moist cloth and a non-abrasive detergent. After cleaning, wipe the hob dry with a soft cloth. To clean the enamelled parts, caps and crowns, wash them with warm soapy water and dry them carefully before you put them back on.
LABELS SUPPLIED WITH THE ACCESSORIES BAG Stick the adhesive labels as indicated below: A B MOD. MOD. PROD.NO. PROD.NO. SER.NO SER.NO DATA DATA C 0049 MOD. PROD.NO. SER.NO. TYPE IP20 03 IT MADE IN ITALY A. Stick it on Guarantee Card and send this part (if applicable). B. Stick it on Guarantee Card and keep this part (if applicable). C. Stick it on instruction booklet. INSTALLATION WARNING! Refer to Safety chapters. 813 Current Editions and the ETCI Rules for Electrical Installations.
should be consulted to determine the requisite air vent requirements. For appliances installed in the Republic of Ireland please refer to the NSAI- Domestic Gas Installation I.S. 813 Current Editions Table Four. Location The hob may be located in a kitchen, a kitchen/ diner or bed sitting room (with a volume greater than 20 m³), but not in a bathroom or shower room. The minimum distance combustible material can be fitted above the hob in line with the edges of the hob is 400 mm.
WARNING! Make sure the flame does not go out when you quickly turn the knob from the maximum position to the minimum position. 4. With a thin screwdriver, adjust the bypass screw position (A). A ELECTRICAL CONNECTION • Do not pull the mains cable to disconnect the appliance. Always pull the mains plug (if applicable). • The appliance must not be connected with an extension cable, an adapter or a multiple socket. There is a risk of fire.
A B A B C D E A. Green and Yellow B. 3 amp fuse C. Brown D. Cord clamp E. Blue The wires in the cord are coloured as follows: Green and yellow - Earth Blue - Neutral Brown - Live 1. Connect the green and yellow (earth) wire to the terminal which is marked with the letter 'E', , or coloured green and or the earth symbol yellow. 2. Connect the blue (neutral) wire to the terminal which is marked with the letter 'N' or coloured blue. 3.
3. 7. min. 600 mm min. 100 mm min. 650 mm min. 55 mm 30 mm 480+02 mm 560+02 mm 8. 4. 400 mm A 50 mm 9. A) supplied bracket If a furniture unit is installed at a distance of 400 mm above the hob, there must be a minimum safety distance of 50 mm to the left or right from the edge of the hob. 5. CAUTION! Install the appliance only on a worktop with flat surface. 6.
A min 30 mm A. Removable panel B. Space for connections Kitchen unit with oven B min 5 mm (max 150 mm) 60 mm The electrical connection of the hob and the oven must be installed separately for safety reasons and to let easy remove oven from the unit.
GAS BURNERS FOR LPG G30/G31 28-30/37 MBAR NOMINAL GAS FLOW g/h BURNER NORMAL POWER kW MINIMUM POWER kW INJECTOR MARK G30 28-30 mbar G31 37 mbar Multi Crown 3,65 1,4 095 265 261 Semi-rapid 2,0 0,45 71 145 143 Auxiliary 1,0 0,33 50 73 71 ENERGY EFFICIENCY PRODUCT INFORMATION ACCORDING TO EU 66/2014 Model identification ZGH66424BB, ZGH66424XX Type of hob Built-in hob Number of gas burners 4 Energy efficiency per gas burner (EE gas burner) Left rear - Semi-rapid 54.
867345144-C-502017 WWW.ZANUSSI.
