EN User Manual Hob ZGG96624 GB IE
Contents Safety information Safety instructions Product description Daily use Hints and tips 2 3 5 6 7 Care and cleaning Troubleshooting Installation Technical information Energy efficiency 7 8 9 13 14 Subject to change without notice. Safety information Before the installation and use of the appliance, carefully read the supplied instructions. The manufacturer is not responsible if an incorrect installation and use causes injuries and damages.
• • • • • • • • Unattended cooking on a hob with fat or oil can be dangerous and may result in fire. Never try to extinguish a fire with water, but switch off the appliance and then cover flame e.g. with a lid or a fire blanket. Do not store items on the cooking surfaces. Metallic objects such as knives, forks, spoons and lids should not be placed on the hob surface since they can get hot. Do not use a steam cleaner to clean the appliance.
• • • • • • • • • • • • • • • • Before carrying out any operation make sure that the appliance is disconnected from the power supply. Make sure that the electrical information on the rating plate agrees with the power supply. If not, contact an electrician. Make sure the appliance is installed correctly. Loose and incorrect electricity mains cable or plug (if applicable) can make the terminal become too hot. Use the correct electricity mains cable. Do not let the electricity mains cable tangle.
• • • • • • • • • • • • • Do not let cookware to boil dry. Be careful not to let objects or cookware fall on the appliance. The surface can be damaged. Do not activate the cooking zones with empty cookware or without cookware. Do not put aluminium foil on the appliance. Use only stable cookware with the correct shape and diameter larger than the dimensions of the burners. Make sure cookware is centrally positioned on the burners.
Control knob Symbol Symbol Description Description ignition position / maximum gas supply no gas supply / off position minimum gas supply Daily use A) B) C) D) WARNING! Refer to Safety chapters. Burner overview Burner cap Burner crown Ignition candle Thermocouple Ignition of the burner Always light the burner before you put on the cookware. A B C D A B C WARNING! Be very careful when you use open fire in the kitchen environment.
CAUTION! In the absence of electricity you can ignite the burner without electrical device; in this case approach the burner with a flame, turn the control knob counter-clockwise to maximum gas supply position and push it down. Keep the control knob pushed for equal or less than 10 seconds to let the thermocouple warm up. The spark generator can start automatically when you switch on the mains, after installation or a power cut. It is normal.
• Wash stainless steel parts with water, and then dry them with a soft cloth. Cleaning the hob • Pan supports • The pan supports are not resistant to washing in a dishwasher. They must be washed by hand. 1. Remove the pan supports to easily clean the hob. Be very careful when you replace the pan supports to prevent the hob top from damage. 2. The enamel coating occasionally can have rough edges, so be careful when you wash the pan supports by hand and dry them.
Problem Possible cause Remedy Burner cap and crown are placed Place the burner cap and crown incorrectly. correctly. The flame extinguishes immediately after ignition. Thermocouple is not heated up sufficiently. After lightning the flame, keep the knob pushed for equal or less than 10 seconds. The flame ring is uneven. Burner crown is blocked with food residues. Make sure that the injector is not blocked and the burner crown is clean. If you cannot find a solution...
Model ....................................... PNC ......................................... Serial number ........................... Important safety requirements Gas Connection WARNING! Any gas installation must be carried out by a GAS SAFE REGISTER installer. This hob must be installed in accordance with the Gas Safety (Installation and Use) Regulations (Current Edition) and the IEE Wiring Regulations (Current Edition).
CAUTION! It is important to install the elbow correctly, with the shoulder on the end of the thread, fitted to the hob connecting pipe. CAUTION! 5. If you change: • from natural gas G20 20 mbar to liquid gas, fully tighten the bypass screw in. • from liquid gas to natural gas G20 20 mbar, undo the bypass screw approximately 1/4 of a turn (1/2 of a turn for Triple Crown burner). Failure to ensure the correct assembly will cause leakage of gas.
Before carrying out the connection, make sure: 1. The limiter valve and the electrical system can take the appliance load (see the rating plate) 2. The supply system is equipped with an efficient earth connection in compliance with the current standards and regulations 3. The outlet or omnipolar switch used for connection is easily accessible with the appliance installed. The appliance is supplied with a 3 core flexible power cable with a 3 amp plug.
B) supplied brackets CAUTION! Install the appliance only on a worktop with flat surface. A Possibilities for insertion 10 mm 27 mm 3 mm 27 mm A The panel installed below the hob must be easy to remove and let an easy access in case a technical assistance intervention is necessary.
Appliance class: 3 Gas burners for NATURAL GAS G20 20 mbar BURNER NORMAL POWER kW MINIMUM POWER kW INJECTOR MARK 1/100 mm Triple Crown 4,0 1,4 146 Rapid 3,0 0,75 119 Semi-rapid 2,0 0,45 96 Auxiliary 1,0 0,33 70 Gas burners for LPG G30/G31 28-30/37 mbar BURNER NORMAL POWER kW MINIMUM POWER kW INJECTOR MARK 1/100 mm NOMINAL GAS FLOW g/h G30 28-30 mbar G31 37 mbar Triple Crown 4,0 1,4 98 291 286 Rapid 2,8 0,75 86 204 200 Semi-rapid 2,0 0,45 71 145 143 Auxiliary 1,
Energy saving • • • • • • • Before use, make sure that the burners and pan supports are assembled correctly. Use cookware with diameters applicable to the size of burners. Center the pot on the burner. When you heat up water, use only the amount you need. If it is possible, always put the lids on the cookware. When the liquid starts to boil, turn down the flame to barely simmer the liquid. If it is possible, use a pressure cooker. Refer to its user manual.
867315304-A-472014 www.zanussi.
