3IPROUDA Instruction Manual Full Automatic Tablet Packing Machine PROUD • Thank you very much for purchasing our full automatic tablet packing machine “PROUD.” • Please read this instruction carefully for proper use. • After you read this instruction manual, keep it at hand with warranty. Safety Instructions Read Pages 3 to 5 to use the machine properly.
Table of Contents Introduction Safety instructions ��������������������������������������3 Before use ��������������������������������������������������7 ■■ Instruction Manual ������������������������������7 ■■ Terminology ����������������������������������������7 Accessories ������������������������������������������������8 Name of each unit ��������������������������������������9 ■■ Machine appearance �������������������������9 ■■ Inside the machine ���������������������������10 ■■ Separately sold items
はじめに Safety instructions ■■ Degrees of dangers and damages caused by wrong usage ignoring instructions are categorized and explained in the following symbols. WARNING This symbol indicates that failure to obey this instruction may result in serious injury or death. CAUTION This symbol indicates that failure to obey this instruction may result in injury or only property damage. This symbol is used to “promote awareness.” This symbol is used to indicate “prohibited” actions.
WARNING Do not move your fingers close to the cutter blade. Sharp blades are used for the machine. Do not move your fingers close to the cutter blades. Failure to obey this instruction may result in injury. Failure to obey this instruction may result in burn injury or injury. Prohibited ᅠഥ Do not move your fingers close to the heater roller during paper feed. Failure to obey this may result in burn injury.
CAUTION Be sure to use the genuine power outlet. Use of an outlet with an inapplicable voltage and electric capacitance may result in heat generation and fire. In addition, lack of the power capacity and rapid voltage fluctuations may result in malfunctions. Be sure to use the genuine power outlet. Disconnect the power cord and plug in case of abnormal conditions. Damaged power cord/plug, loosen outlet or piled dust may cause an electric shock, heat generation and fire.
FCC Part15.19 This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. FCC Part.15.105(b) This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules.
Before use ■■ Instruction Manual • Please note that descriptions and illustrations in this Instruction Manual may not agree with actual ones because of the machine improvement. • In this Instruction Manual, pages to be referred are described as (P00). ■■ Terminology Term Dispensing DTA Printing Sealing Description Putting drugs into bags This is an abbreviation of Detachable Tablet Adapter This is a table used when dispensing tablets in separate bags manually.
Accessories (1) (1) (4)(4) (7) (7) (2) (2) (5) (5) (8) (8) (10) (10) (11) (11) (3) (3) (6) (6) (9)(9) (13) (13) (14) (14) (12) (12) (15) (15) (1) Packing paper (11) Phillips screwdriver (large and small) and straight slot screwdriver (2) Refill ribbon cassette (3) Refill ribbon and refill ribbon shaft (12) Wax (4) Drug basket (14) Heater roller cleaning brush (5) Key (for upper door) x 2 (15) Cleaning brush (13) Printer head cleaner (6) Key (for the sides of the packing machine) x 2 (7)
Name of each unit ■■ Machine appearance (1) (1) (12) (12) (7) (7) (2) (2) (3) (3) (4) (4) (11) (11) POWER 㹃㹌㹂 CUTTER (5) (5) (6) (6) (8) (8) (9) (9) (10) (10) (1) Upper door (P17) (2) Operation panel (3) DTA tray (P33) (4) Refilling table (P20) (5) Lower door (P55) (6) Personal computer (notebook or desktop) (7) Touch panel (P12) (8) [Reserve power] switch (P42) (9) [Packing paper cutter] switch (10) [Emergency stop] switch (P41) (11) Door key (12) Speaker 9
■■ Inside the machine (12) l s t (17) (18) (16) (13) p (15) o (14) n m (1) a (2) b (3) c (11) k (10) j v u (20) (19) (9) i (8) h (7) g (6) f (5) e (4) d (1) Revolver unit (P89) (19) [Heater roller RW] switch (P60) (2) Large hopper (P87) (20) [Heater roller FW] switch (P60) (3) Breaker (P16) (4) Paper core (P55) (5) Packing paper (6) Packing unit open/close lever (7) Paper guide (P61) (8) Heater roller (P101) (P57) (9) Conveyor (10) Last hopper (P84) (11) Lower operation panel (1
■■ Separately sold items (1) a (2) b (3) c (1) Slid unit (YS-TR-406FDSII) (2) Key hole (3) Lock button (P18) 11
Touch panel (1) (2) POWER 㹃㹌㹂 CUTTER (3) (4) (1) Message display Displays the status and operation of the packing machine. (2) Key button Used to operate the packing machine. (P13) (3) Display of prescription information Displays the prescription information for the drug that is now being dispensed (or and status of the packing machine is to be dispensed) and the status of the packing machine. (P14) (4) Display and setting of details 12 Displays the detail of prescription.
■■ Key button (1) (2) 67$57 6723 (3) 23(1 '7$ &/26( '7$ &/26( 23(1 '7$ &/26( '7$ 6(7 '7$ 6(7 '7$ 6(7 23(1 (4) (5) (6) (7) &$1 ),1' (8) (9) 5(/($6( (10) (11) 5(/($6( (12) (13) %#0%'. (1) Switches the mode to the one where dispensing is issued only by the packing machine. (P42) Restarts dispensing when the machine is temporarily stopped. (2) Stops dispensing temporarily. (P39) (3) Opens/closes the DTA tray. (P33) (4) Sets the DTA. (P33) (Cannot set the DTA when [Number of DTAs: 2].
■■ Displaying the prescription Information and the status of the packing machine (1) (12) (2) (3) (4) (5) (6) (7) (8) (9) (11) (10) (1) Number of pouches Displays the number of finished pouches and the number of the remaining pouches during dispensing. (2) Patient ID Displays the patient ID during dispensing. (3) Name of patient Displays the name of the patient during dispensing. (4) Ticket number Displays the ticket number of the drug that is currently being dispensed.
使いかた(基本) Turning on the power The packing machine is interlocked with the personal computer. Even when the packing machine has been turned ON, do not start operation until the rapid thermal processing of the heater roller is completed. *Operate the breaker before installing the packing machine or cleaning the printer head. 1. Connect the power plug to the outlet. • Be sure to use an AC100V outlet with the 3P earth or the 2P conversion adapter.
3. Turn [ON] the breaker. • After the breaker has been turned on, close the lower door. 4. Turn on the personal computer. • Wait for a while until packing is ready as the heater roller is heated. • You can start dispensing when [Ready to dispense] is displayed.
Unlocking the upper door You are required to input a password to open the upper door. Open the door after entering the password. Once the password has been entered, you can set the machine so that you can open the door without entering the password or you are required to enter the password every time you open the door. Once the power is turned off, you are required to enter the password again. * You can set [Operator] and [Password] on the personal computer.