User’s Manual XS110A Wireless Communication Module IM01W06D01-01EN IM01W06D01-01EN 1st Edition
Toc-1 CONTENTS 1. Introduction .............................................................................................1-1 1.1 Radio Waves .........................................................................................................1-4 1.2 Warranty................................................................................................................1-5 2. Notes on Handling ...................................................................................2-1 2.2 2.3 2.4 2.
1-1 1. Introduction Thank you for purchasing XS110A Wireless Communication Module. This manual provides important information and installation and maintenance instructions for using the XS110A Wireless Communication Module (Hereinafter, it is described as XS110A.) correctly and safely. The XS110A can be connected to an XS-series Measurement Module. The battery mounted on the XS110A supplies power to the connected Measurement Module.
1-2 Regarding This Manual 7KLV PDQXDO VKRXOG EH SURYLGHG WR WKH HQG XVHU 7KLV PDQXDO DQG WKH LGHQWL¿FDWLRQ WDJ DWWDFKHG RQ WKH SDFNLQJ ER[ are essential parts of the product; keep them in a safe place for future reference. 7KH FRQWHQWV RI WKLV PDQXDO DUH VXEMHFW WR FKDQJH ZLWKRXW SULRU QRWLFH $OO ULJKWV UHVHUYHG 1R SDUW RI WKLV PDQXDO PD\ EH UHSURGXFHG LQ DQ\ IRUP without Yokogawa’s written permission.
1-3 7KH IROORZLQJ VDIHW\ V\PEROV DUH XVHG LQ WKLV PDQXDO WARNING ,QGLFDWHV D SRWHQWLDOO\ KD]DUGRXV VLWXDWLRQ ZKLFK LI QRW DYRLGHG FRXOG UHVXOW LQ GHDWK RU VHULRXV LQMXU\ CAUTION ,QGLFDWHV D SRWHQWLDOO\ KD]DUGRXV VLWXDWLRQ ZKLFK LI QRW DYRLGHG PD\ UHVXOW LQ PLQRU RU PRGHUDWH LQMXU\ RU SK\VLFDO GDPDJH ,W PD\ DOVR EH XVHG WR DOHUW against unsafe practices. IMPORTANT Indicates that operating the hardware or software in this manner may damage it or lead to system failure.
1.1 1-4 Radio Waves 7KLV SURGXFW LV GHVLJQDWHG DV D FHUWL¿FDWLRQ RI FRQVWUXFWLRQ W\SH DV D ZLUHOHVV IDFLOLW\ IRU 0+] EDQG DQG 0+] EDQG ORZ SRZHU GDWD FRPPXQLFDWLRQ system of the Radio Act. Refer to “7.6 Regulatory Compliance Statements” for detail. $UHD &RGH 5HJLRQDO SDUDPHWHU LV (8 DQG IUHTXHQF\ LV WR 0+] 1. $UHD &RGH 5HJLRQDO SDUDPHWHU LV 86 DQG IUHTXHQF\ LV WR 0+] 2. $UHD &RGH 5HJLRQDO SDUDPHWHU LV $6 DQG IUHTXHQF\ LV WR 0+]
1.2 1-5 Warranty 7KH ZDUUDQW\ VKDOO FRYHU WKH SHULRG QRWHG RQ WKH TXRWDWLRQ SUHVHQWHG WR WKH purchaser at the time of purchase. Problems occurring during the warranty period shall basically be repaired free of change. ,I DQ\ SUREOHPV DUH H[SHULHQFHG ZLWK WKLV SURGXFW WKH FXVWRPHU VKRXOG contact the Yokogawa representative from which this product was SXUFKDVHG RU WKH QHDUHVW
2-1 2. Notes on Handling The XS110A is fully factory-tested before shipment. When the XS110A is delivered, check the appearance for damage. 7KLV VHFWLRQ GHVFULEHV WKH SUHFDXWLRQV UHTXLUHG WR KDQGOH WKLV SURGXFW %HIRUH use, read this section thoroughly. For information about other items, refer to the relevant sections. &KHFN WKH 0RGHO DQG 6SHFL¿FDWLRQV ;6 $ 7KH PRGHO QDPH DQG VSHFL¿FDWLRQV DUH ZULWWHQ RQ the nameplate attached to the case.
2-2 NOTE When storing this product over a long period, it is recommended to put the instrument in OFF Mode to conserve the battery. This product is shipped in OFF Mode from the factory. For details on how to switch to OFF Mode, refer to “IM 01W06C01-01EN”. 2.4 Selecting the Installation Location This product is designed to withstand severe environmental conditions.
2.5 2-3 Restrictions on Use of Radio Transceivers IMPORTANT $OWKRXJK WKLV SURGXFW KDV EHHQ GHVLJQHG WR UHVLVW KLJK IUHTXHQF\ HOHFWULFDO noise, if a radio transceiver is used near this product or its external wiring, WKLV SURGXFW PD\ EH DIIHFWHG E\ KLJK IUHTXHQF\ QRLVH SLFNXS 7R WHVW WKLV start from a distance of several meters and slowly approach this product with the transceiver while observing the measurement loop for noise effects.
2-4 WARNING 327(17,$/ (/(&75267$7,& &+$5*,1* +$=$5' ± 6(( INSTRUCTIONS '2 127 23(1 :+(1 $1 (;3/26,9( $70263+(5( ,6 35(6(17 86( 21/< 63(&,),(' %$77(5< ± 6(( ,16758&7,216 Installation: 7KH HTXLSPHQW PXVW EH LQVWDOOHG LQ DFFRUGDQFH ZLWK (1 ORFDO UHTXLUHPHQWV DQG WKH FRQWURO GUDZLQJ Operation: WARNING :KHQ WKH HTXLSPHQW LV XVHG LQ KD]DUGRXV ORFDWLRQV DYRLG DQ\ DFWLRQV which generate electrostatic charges, such as rubbing with a dry cloth.
2-5 Maintenance and repair: WARNING 2QO\ SHUVRQQHO DXWKRUL]HG E\
2-6 Control drawing: Hazardous Location Connector Uo: 6.88 V Io: 1.54 A Po: 0.3 W Co: 10 μF Lo: 3 μH XS110A Wireless communication module 20 Ui Uo Ii Io Pi Po Ci Co Li Lo IS Apparatus F03.ai 6SHFL¿F FRQGLWLRQV RI XVH 3UHFDXWLRQV VKDOO EH WDNHQ WR PLQLPL]H WKH ULVN IURP HOHFWURVWDWLF GLVFKDUJH RI non-metallic parts.
2-7 Operation: WARNING :KHQ WKH HTXLSPHQW LV XVHG LQ KD]DUGRXV ORFDWLRQV DYRLG DQ\ DFWLRQV which generate electrostatic charges, such as rubbing with a dry cloth. :KHQ XVLQJ 6XVKL 6HQVRU $33 WR VHW WKH SDUDPHWHU RI WKH H[SORVLRQ protected instrument, the Android device must comply with the following. ¾ :KHQ XVLQJ WKH 1)& OLQN LQ D QRQ KD]DUGRXV DUHD WKH PD[LPXP PDJQHWLF ¿HOG VWUHQJWK JHQHUDWHG E\ WKH $QGURLG GHYLFH LV >$ P (r.m.s.
3-1 3. Component Names Strap hole NFC interface Case Measurement Module mounting screw Main body Front Nameplate Back Cables Battery holder Battery holder fixing screw Main Body F04.
4-1 4. Installation The XS110A does not include batteries when shipped from the factory. Install the battery to the XS110A according to the procedure in Section 6.1. After installing the battery, mount the Measurement Module on the XS110A. Refer to the User’s Manual of the Measurement Module connected to the XS110A for installation precautions. 5HIHU WR &KDSWHU *HQHUDO 6SHFL¿FDWLRQV IRU WKH DPELHQW FRQGLWLRQV RI WKH installation site.
5-1 5. Operation To perform the setting and status check of the product, use an Android device with the NFC interface. Download Sushi Sensor App from Google Play. Sushi Sensor App provides the following functions. 1HWZRUN VHWWLQJ 6HQVRU VHWWLQJ 6WDWXV FKHFN RI FRPPXQLFDWLRQ VHQVRU EDWWHU\ OLIH HWF 6ZLWFK WR 2)) 0RGH For details, refer to “IM 01W06C01-01EN”.
6-1 6. Maintenance 6.1 Replacing the Battery The XS110A can be replaced with a new battery. The XS110A does not include batteries when shipped from the factory. Install the battery in the XS110A according to the procedure in this section. If the XS110A is installed on the Measurement Module, remove the XS110A according to the user manual of the Measurement Module. Refer to 6.2 for the battery that can be mounted on the XS110A.
6-2 :RUNÀRZ IMPORTANT 7KLV SURGXFW FRQWDLQV SDUWV WKDW FDQ EH GDPDJHG E\ VWDWLF HOHFWULFLW\ When replacing a battery, take precautions such as using a grounded wrist strap to avoid handling electronic parts or touching the board circuit patterns. :KHQ SXWWLQJ RQ RU UHPRYLQJ WKH &DVH SD\ JUHDW DWWHQWLRQ WR WKH environmental conditions to prevent dust and water droplets entering the product. 7DNH VXI¿FLHQW FDUH QRW WR DSSO\ H[FHVVLYH IRUFH WR WKH FLUFXLW ERDUG KLW WKH ERDUG Z
6-3 case fixing screw F05.ai Figure 6-1 Bottom of XS110A F06.ai Figure 6-2 Removing the case and body F07.
6.2 6-4 Handling the Battery This product uses one lithium thionyl chloride primary battery. A single battery contains approximately 5 grams of lithium. Under normal conditions, the battery materials are self-contained and are not reactive as long as the battery integrity is maintained. Care should be taken to prevent thermal, electrical or mechanical damage. Battery should be stored in a clean and dry area. For maximum battery life, storage temperature should not exceed 30°C.
*HQHUDO 6SHFL¿FDWLRQV! 7-1 Batteries 3DUW 1R ) 15 EDWWHULHV 1 2 Alternatively, following batteries may be purchased and used. 7DGLUDQ 7/ 6 RU 6/ 6 9,7=52&(// 6% ' Transportation of products containing a lithium battery: This product contains a lithium battery. When transporting this product with the battery installed, set this product to OFF mode to prevent the battery from draining. For details about how to change to OFF mode, refer to “IM 01W06C01-01EN”.
*HQHUDO 6SHFL¿FDWLRQV! 7-2 *HQHUDO 6SHFL¿FDWLRQV Please refer to “GS 01W06D01-01EN” for the latest information. 7.1 STANDARD SPECIFICATIONS WIRELESS SPECIFICATIONS Communication protocol: LoRaWAN Class A, (8 $6 86 Data Rate: WR ESV $YDLODEOH GDWD UDWH YDU\ depending on the country. Frequency: >>$UHD FRGH @ WR 0+] 1 >$UHD FRGH @ WR 0+] 2 >$UHD FRGH @ WR 0+] 2 7KLV ZLUHOHVV IUHTXHQF\ FDQ be used throughout, Europe, although there are so
Diagnostics Function: Battery alarm, internal temperature, wireless communication failures, memory failures, Measurement Module connection failure Software Download Features: Allows the user to update the software of the sensor via the NFC interface. Power supply to the Measurement Module: Supply voltage: 3.
Ex marking: II 2 G Ex ib IIC T4 Gb Ambient temperature: -40 to & $GGLWLRQDOO\ OLPLWHG E\ WKH ambient temperature range RI WKH HTXLSPHQW FRQQHFWHG to XS110A. Electrical parameters: Connector Uo = 6.88 V, Io = 1.54 A, 3R : &R ȝ) /R ȝ+ Enclosure: IP66/IP67 when accordance with EN ZKHQ FRPELQHG ZLWK FHUWL¿HG HTXLSPHQW Canadian Safety Standards: CAN/CSA-C22.2 No.
*HQHUDO 6SHFL¿FDWLRQV! 7.2 Software 6SHFL¿FDWLRQV Sushi Sensor App This software is used to perform the setting and status check of this product via the NFC interface. Operating Environment: Item Recommended System Requirements OS Android 5.1.1 or higher CPU Snapdragon 800 or better Resolution 1280 x 720 dots or more NFC Readers, Writer GPS Optional 7-5 Note of Available Android Device: When using Sushi Sensor APP to the Android device must comply with the following.
*HQHUDO 6SHFL¿FDWLRQV! 7.3 7-6 MODEL AND SUFFIX CODES 6XI¿[ &RGHV Model XS110A Inter-module -A Communication 2 3 4 Area Code 00 K2 S2 Type ʊ Housing material Power source ʊ -A. 5 D A Description Wireless Communication Module XS-series dedicated digital communication Europe EU868 1RUWK $PHULFD 86 6RXWKHDVW $VLD $6 *HQHUDO 3XUSRVH 1 $7(; LQWULQVLF VDIHW\ 2 ,(&([ LQWULQVLF VDIHW\ 3 Always A Plastic (PC) Battery powered Always A $SSOLFDEOH ZKHQ $UHD &RGH LV RU $SSOLFDEOH ZKHQ
*HQHUDO 6SHFL¿FDWLRQV! 7.5 7-7 Outline z Main body Units: mm (Approx. inch) 133.5 (5.26) NFC Interface Measurement Module mounting screw ø68 (2.68) Measurement Module connector Case fixing screw F08.
7.6 *HQHUDO 6SHFL¿FDWLRQV! 7-8 Regulatory Compliance Statements 7KLV SURGXFW VDWLV¿HV WKH IROORZLQJ VWDQGDUGV 3OHDVH FRQ¿UP WKDW DQ LQVWDOODWLRQ UHJLRQ IXO¿OOV DQ DSSOLFDEOH VWDQGDUG ,I DGGLWLRQDO UHJXODWRU\ LQIRUPDWLRQ DQG DSSURYDOV DUH UHTXLUHG FRQWDFW D Yokogawa representative. Telecommunication Compliance: RE Directive (EU Countries) +HUHE\
*HQHUDO 6SHFL¿FDWLRQV! 7-9 NOTE 7KLV HTXLSPHQW KDV EHHQ WHVWHG DQG IRXQG WR FRPSO\ ZLWK WKH OLPLWV IRU D Class A digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference ZKHQ WKH HTXLSPHQW LV RSHUDWHG LQ D FRPPHUFLDO HQYLURQPHQW 7KLV HTXLSPHQW JHQHUDWHV XVHV DQG FDQ UDGLDWH UDGLR IUHTXHQF\ HQHUJ\ and, if not installed and used in accordance with the instruction manual, may cause harmful interference to radio comm
*HQHUDO 6SHFL¿FDWLRQV! 7-10 French: L’émetteur/récepteur exempt de licence contenu dans le présent appareil est FRQIRUPH DX[ &15 G¶,QQRYDWLRQ 6FLHQFHV HW 'pYHORSSHPHQW pFRQRPLTXH Canada applicables aux appareils radio exempts de licence. L’exploitation est autorisée aux deux conditions suivantes : (1) L’appareil ne doit pas produire de brouillage; /¶DSSDUHLO GRLW DFFHSWHU WRXW EURXLOODJH UDGLRpOHFWULTXH VXEL PrPH VL OH brouillage est susceptible d’en compromettre le fonctionnement.
7-11 RE Directive: 6DIHW\ (1 ,QGRRU 2XWGRRU XVH (1 (1) Pollution Degree 2 ³3ROOXWLRQ GHJUHH´ GHVFULEHV WKH GHJUHH WR ZKLFK D VROLG OLTXLG RU gas which deteriorates dielectric strength or surface resistivity is adhering. “2” applies to normal indoor atmosphere. Normally, only non-conductive pollution occurs.Occasionally, however, temporary conductivity caused by condensation must be expected.
7-12 Waste Electrical and Electronic Equipment (WEEE), Directive (This directive is valid in the EU member states.) 7KLV SURGXFW FRPSOLHV ZLWK WKH :((( 'LUHFWLYH PDUNLQJ UHTXLUHPHQW The following marking indicates that you must not discard this electrical/ electronic product in domestic household waste. Product Category :LWK UHIHUHQFH WR WKH HTXLSPHQW W\SHV LQ WKH :((( GLUHFWLYH WKLV SURGXFW LV FODVVL¿HG DV ³6PDOO HTXLSPHQW´ Do not dispose of this product in domestic household waste.
i Revision Information Title: XS110A Wireless Communication Module Reference Number: IM 01W06D01-01EN Edition 1st Date July 2020 Page ʊ Revision Item New publication IM 01W06D01-01EN
YOKOGAWA ELECTRIC CORPORATION Headquarters 9-32, Nakacho, 2-chome, Musashino-shi, Tokyo, 180-8750 JAPAN Phone : 81-422-52-5555 Branch Sales Offices Osaka, Nagoya, Kurashiki, Hiroshima, Fukuoka, Kitakyusyu YOKOGAWA CORPORATION OF AMERICA Head Office 12530 West Airport Blvd, Sugar Land, Texas 77478, USA Phone : 1-281-340-3800 Fax : 1-281-340-3838 Georgia Office 2 Dart Road, Newnan, Georgia 30265, USA Phone : 1-800-888-6400 Fax : 1-770-254-0928 YOKOGAWA AMERICA DO SUL LTDA.
