OWNER’S MANUAL YW50X LIT-11626-21-15 5PJ-F8199-14_Cv.
1 2 3 EAU10041 4 5 6 7 8 9 5PJ-F8199-14_ch0.
EAU10050 INTRODUCTION EAU10090 Congratulations on your purchase of the Yamaha YW50X. This model is the result of Yamaha’s vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. 1 This manual will give you an understanding of the operation, inspection, and basic maintenance of this scooter.
EAU10122 IMPORTANT MANUAL INFORMATION EAU35821 Particularly important information is distinguished in this manual by the following notations: Q The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! 2 w Failure to follow WARNING instructions could result in severe injury or death to the scooter operator, a bystander, or a person inspecting or repairing the scooter. 3 cC A CAUTION indicates special precautions that must be taken to avoid damage to the scooter.
EAU10122 IMPORTANT MANUAL INFORMATION 1 2 AFFIX DEALER 3 LABEL HERE 4 5 EAUT2190 YW50X OWNER’S MANUAL ©2007 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2007 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. is expressly prohibited. Printed in Taiwan. P/N LIT-11626-21-15 5PJ-F8199-14_ch0.
EAU10210 TABLE OF CONTENTS SAFETY INFORMATION ................... 1-1 Further safe-riding points ............... 1-4 Location of important labels ........... 1-6 1 2 3 4 5 6 7 8 9 DESCRIPTION ................................... 2-1 Left view ......................................... 2-1 Right view ....................................... 2-2 Controls and instruments ............... 2-3 INSTRUMENT AND CONTROL FUNCTIONS ................................................ 3-1 Main switch/steering lock .........
EAU10210 TABLE OF CONTENTS SPECIFICATIONS ............................. 8-1 CONSUMER INFORMATION ............ 9-1 Identification numbers .................... 9-1 Reporting safety defects ................. 9-3 Scooter noise regulation ................. 9-4 Maintenance record ........................ 9-5 YAMAHA MOTOR CORPORATION, U.S.A. .......................................... 9-7 RIVA LIMITED WARRANTY ........... 9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ........................................
Safety information Q SAFETY INFORMATION EAU10261 1 2 3 4 5 6 7 8 9 SCOOTERS ARE SINGLE TRACK VEHICLES. THEIR SAFE USE AND OPERATION ARE DEPENDENT UPON THE USE OF PROPER RIDING TECHNIQUES AS WELL AS THE EXPERTISE OF THE OPERATOR. EVERY OPERATOR SHOULD KNOW THE FOLLOWING REQUIREMENTS BEFORE RIDING THIS SCOOTER. HE OR SHE SHOULD: ● OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF SCOOTER OPERATION. ● OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER’S MANUAL.
Q SAFETY INFORMATION ● ● ● changing lanes. Make sure that other motorists can see you. The posture of the operator and passenger is important for proper control. • The operator should keep both hands on the handlebar and both feet on the footboard during operation to maintain control of the scooter. • The passenger should always hold onto the operator, the seat strap or grab bar, if equipped, with both hands and keep both feet on the passenger footrests.
Q SAFETY INFORMATION 1 2 3 4 5 6 7 8 9 keep the following in mind: ● Cargo and accessory weight should be kept as low and close to the scooter as possible. Make sure to distribute the weight as evenly as possible on both sides of the scooter to minimize imbalance or instability. ● Shifting weights can create a sudden imbalance. Make sure that accessories and cargo are securely attached to the scooter before riding. Check accessory mounts and cargo restraints frequently.
Safe-riding points Q SAFETY INFORMATION ● ● exhaust system when refueling. • Never refuel while smoking or in the vicinity of an open flame. Never start the engine or let it run for any length of time in a closed area. The exhaust fumes are poisonous and may cause loss of consciousness and death within a short time. Always operate your scooter in an area that has adequate ventilation. Always turn the engine off before leaving the scooter unattended and remove the key from the main switch.
Q SAFETY INFORMATION ● 1 2 3 4 ● ● ● 5 6 7 ● 8 9 ● ● Braking can be extremely difficult on a wet road. Avoid hard braking, because the scooter could slide. Apply the brakes slowly when stopping on a wet surface. Slow down as you approach a corner or turn. Once you have completed a turn, accelerate slowly. Be careful when passing parked cars. A driver might not see you and open a door in your path.
Labels, location of Q SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 2 4 5 6 1 2 3 3 4 5 6 7 8 9 1-6 5PJ-F8199-14_ch1.
Q SAFETY INFORMATION 1 5 2 6 1 2 3 4 3 5 4 6 7 8 9 1-7 5PJ-F8199-14_ch1.
Q SAFETY INFORMATION 1 2 3 4 5 6 7 8 9 1-8 5PJ-F8199-14_ch1.
Part locations EAU10400 DESCRIPTION EAU10410 Left view 1 2 4 3 6 5 1 2 3 4 5 6 7 8 9 1. Front wheel 2. Front brake caliper (page 6-15) 3. Front turn signal light 4. Helmet holder (page 3-8) 5. Storage compartment (page 3-9) 6. Rear turn signal light 7. Rear wheel 8. Adjusting nut (page 6-15) 9. Kickstarter (page 3-7) 10.Air filter element (page 6-10) 11.Battery (page 6-21) 11 10 9 8 2-1 5PJ-F8199-14_ch2.
DESCRIPTION EAU10420 Right view 12 13 14, 15 16 17 1 2 3 4 5 6 7 20 19 8 18 12.Tail/brake light 13.Carrier (page 3-10) 14.Fuel tank cap 15.2-stroke engine oil tank cap 16.Seat (page 3-8) 17.Headlight 18.Spark plug (page 6-7) 19.Centerstand 20.Muffler 9 2-2 5PJ-F8199-14_ch2.
DESCRIPTION EAU10430 Controls and instruments 21 22 23 24 25 26 1 2 3 4 27 5 28 6 7 8 9 21.Rear brake lever (page 3-4) 22.Left handlebar switches (page 3-3) 23.Speedometer unit (page 3-2) 24.Fuel gauge (page 3-3) 25.Right handlebar switches (page 3-3) 26.Front brake lever (page 3-4) 27.Throttle grip (page 6-12) 28.Main switch/steering lock (page 3-1) 2-3 5PJ-F8199-14_ch2.
Main switch/steering lock EAU1044D INSTRUMENT AND CONTROL FUNCTIONS EAU10460 Main switch/steering lock EAU10660 OFF All electrical systems are off. The key can be removed. sition, and then turn it to “LOCK” while still pushing it. 3. Remove the key. To unlock the steering EAU10670 ON OFF * The 2-stroke engine oil level warning light should come on. (See page 3-2.
Indicator and warning lights Turn signal indicator light High beam indicator light 2-stroke engine oil level warning light Speedometer unit INSTRUMENT AND CONTROL FUNCTIONS EAU11003 Indicator and warning lights 1 2 3 1 2 20 10 10 3 4 5 6 7 8 9 0 20 30 40 30 50 km/h 60 40 0 MPH 0000001 ZAUM00** 1. Turn signal indicator light "5" 2. High beam indicator light "&" 3.
Fuel gauge Handlebar switches Dimmer switch Turn signal switch Horn switch Engine stop switch INSTRUMENT AND CONTROL FUNCTIONS EAU12140 Fuel gauge EAU12347 1 EAU12400 %/& &” Dimmer switch “% Set this switch to “&” for the high beam and to “%” for the low beam. Handlebar switches 1 EAU12460 20 10 10 0 20 30 40 30 50 km/h 60 40 0 MPH 0000001 2 ZAUM00** ZAUM00** 1. Fuel gauge The fuel gauge indicates the amount of fuel in the fuel tank.
Start switch Brake lever, front Brake lever, rear INSTRUMENT AND CONTROL FUNCTIONS EAU12710 ,” Start switch “, Push this switch to crank the engine with the starter. 1 2 EAU12900 Front brake lever EAU12950 Rear brake lever ECA10050 cC See page 5-1 for starting instructions prior to starting the engine. 3 4 ZAUM00** ZAUM00** The front brake lever is located on the right handlebar grip. To apply the front brake, pull this lever toward the handlebar grip.
Fuel and 2-stroke engine oil tank caps INSTRUMENT AND CONTROL FUNCTIONS EAUT1030 Fuel and 2-stroke engine oil tank caps The fuel tank cap and the 2-stroke engine oil tank cap are located under the seat. (See page 3-8.) To install the fuel tank cap Insert the fuel tank cap into the tank opening with the mark on the cap and fuel filler aligned. Turn the lever to the “LOCK” position, and then push it down. EWA10120 w Make sure that the fuel tank cap is properly closed and locked before riding.
Fuel INSTRUMENT AND CONTROL FUNCTIONS EAU13211 Fuel 1 1 ECA10070 cC Immediately wipe off spilled fuel with a clean, dry, soft cloth, since fuel may deteriorate painted surfaces or plastic parts. 2 does not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. 2 EAU40680 3 4 5 6 Recommended fuel: UNLEADED GASOLINE ONLY Fuel tank capacity: 5.7 L (1.5 US gal) (1.25 Imp.gal) ZAUM00** 1.
Catalytic converter Engine oil Kickstarter INSTRUMENT AND CONTROL FUNCTIONS EAU13431 EAU13452 Catalytic converter 2-stroke engine oil This model is equipped with a catalytic converter in the exhaust system. Make sure that there is sufficient 2stroke engine oil in the oil tank. Add the recommended 2-stroke engine oil as necessary. EWA10860 w EAU13680 Kickstarter 1 The exhaust system is hot after operation.
Seat Helmet holder INSTRUMENT AND CONTROL FUNCTIONS EAU13932 Seat 1 2 EAU14300 3. Fold the seat up. To open the seat 1. Place the scooter on the centerstand. 2. Insert the key into the main switch, and then turn it counterclockwise to “OPEN”. Helmet holder 1 1 3 OPEN 4 ZAUM00** ZAUM00** 1. Seat 1. Helmet holder 5 6 ZAUM00** 7 8 NOTE: Do not push inward when turning the key. 9 To close the seat 1. Fold the seat down, and then push it down to lock it in place. 2.
Storage compartment INSTRUMENT AND CONTROL FUNCTIONS To release the helmet from the helmet holder Open the seat, remove the helmet from the helmet holder, and then close the seat. EAU14510 Storage compartment 1 ZAUM00** 1. Storage compartment There is a storage compartment under the seat. (See page 3-8.) EWA10960 w ● ● Do not exceed the load limit of 5 kg (11 lb) for the storage compartment. Do not exceed the maximum load of 143 kg (315 lb) for the vehicle.
Storage compartment (front) Carrier INSTRUMENT AND CONTROL FUNCTIONS tended with the seat open. EAU14400 Front storage compartment EAU15110 Carrier 1 1 2 1 3 4 ZAUM00** ZAUM00** 1. Front storage compartment 5 1. Carrier EWA11190 w ● 6 7 ● 8 EWA10170 w Do not exceed the load limit of 3 kg (7 lb) for the front storage compartment. Do not exceed the maximum load of 143 kg (315 lb) for the vehicle. ● ● Do not exceed the load limit of 3 kg (7 lb) for the carrier.
EAU15580 PRE-OPERATION CHECKS EAU15593 The condition of a vehicle is the owner’s responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air pressure could have serious consequences. Therefore, it is very important, in addition to a thorough visual inspection, to check the following points before each ride.
Pre-operation check list PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM 1 2 3 CHECKS Fuel 3-6 2-stroke engine oil • Check oil level in oil tank. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. 3-5 Final transmission oil • Check vehicle for oil leakage. 6-9 Front brake • • • • • • • Check operation. If soft or spongy, have Yamaha dealer bleed hydraulic system. Check brake pads for wear. Replace if necessary.
PRE-OPERATION CHECKS ITEM CHECKS • Make sure that operation is smooth. • Lubricate pivot if necessary. Centerstand PAGE 6-19 Chassis fasteners • Make sure that all nuts, bolts and screws are properly tightened. • Tighten if necessary. Instruments, lights, signals and switches • Check operation. • Correct if necessary. 3-2~3-3 1 2 3 4 5 6 7 8 9 4-3 5PJ-F8199-14_ch4.
Starting and warming up a cold engine EAU15942 OPERATION AND IMPORTANT RIDING POINTS EAU15980 EWA10870 w ● 1 2 3 ● 4 5 6 7 ● Become thoroughly familiar with all operating controls and their functions before riding. Consult a Yamaha dealer regarding any control or function that you do not thoroughly understand. Never start the engine or operate it in a closed area for any length of time. Exhaust fumes are poisonous, and inhaling them can cause loss of consciousness and death within a short time.
Starting off OPERATION AND IMPORTANT RIDING POINTS starting attempt should be as short as possible to preserve the battery. Do not crank the engine more than 5 seconds on any one attempt. If the engine does not start with the starter motor, try using the kickstarter. ECA11130 cC For maximum engine life, always warm the engine up before starting off. Never accelerate hard when the engine is cold! EAU16770 Starting off 5. Switch the turn signal off.
Acceleration and deceleration Braking OPERATION AND IMPORTANT RIDING POINTS EAU16780 Acceleration and deceleration 1 EAU16792 1. Close the throttle completely. 2. Apply both front and rear brakes simultaneously while gradually increasing the pressure. FRONT (b) 2 EWA10300 w Braking ● ● 3 (a) 4 5 6 ZAUM00** The speed can be adjusted by opening and closing the throttle. To increase the speed, turn the throttle grip in direction (a).
Engine break-in Parking OPERATION AND IMPORTANT RIDING POINTS EAU16830 Engine break-in There is never a more important period in the life of your engine than the period between 0 and 1000 km (600 mi). For this reason, you should read the following material carefully. Since the engine is brand new, do not put an excessive load on it for the first 1000 km (600 mi). The various parts in the engine wear and polish themselves to the correct operating clearances.
OPERATION AND IMPORTANT RIDING POINTS EWA10310 w ● 1 2 ● 3 Since the engine and exhaust system can become very hot, park in a place where pedestrians or children are not likely to touch them. Do not park on a slope or on soft ground, otherwise the vehicle may overturn. 4 ECA10380 cC 5 6 Never park in an area where there are fire hazards such as grass or other flammable materials. 7 8 9 5-5 5PJ-F8199-14_ch5.
Tool kit EAU17226 EAU17227 PERIODIC MAINTENANCE AND MINOR REPAIR EAU17271 Safety is an obligation of the owner. Periodic inspection, adjustment and lubrication will keep your vehicle in the safest and most efficient condition possible. The most important points of scooter inspection, adjustment, and lubrication are explained on the following pages.
PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 NOTE: If you do not have the tools or experience required for a particular job, have a Yamaha dealer perform it for you. EWA10340 w Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6 7 8 9 6-2 5PJ-F8199-14_ch6.
Maintenance, emission control system EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU17560 Periodic maintenance chart for the emission control system INITIAL NO. ITEM ROUTINE 1 * Fuel line • Check fuel and vacuum hoses for cracks or damage. • Replace if necessary. 2 * Idle speed • Check and adjust engine idle speed.
Maintenance and lubrication, periodic EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU32125 General maintenance and lubrication chart INITIAL 1 NO. ITEM ROUTINE 2 3 1 * Air filter element • Clean with solvent. • Replace if necessary. 2 * Front brake • Check operation, fluid level, and for fluid leakage. • Replace brake pads if necessary. 3 * Rear brake • Check operation. • Adjust cable and replace brake shoes if necessary.
EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL NO. 8 ITEM ROUTINE * Chassis fasteners 600 mi (1,000 km) or 1 month ODOMETER READING 2,000 mi (4,000 km) or 6 months 10,000 mi 8,000 mi 6,000 mi 4,000 mi (7,000 km) (10,000 km) (13,000 km) (16,000 km) or or or or 30 24 18 12 months months months months • Check all chassis fitting and fasteners. • Correct if necessary. 2 3 9 Front brake lever pivot shaft • Apply silicone grease lightly.
EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL NO. ITEM ROUTINE 1 2 4 5 • Check operation and free play. • Adjust the throttle cable free play if Throttle grip housing necessary. and cable • Lubricate the throttle grip housing and cable. 18 * 19 * switches 3 600 mi (1,000 km) or 1 month Lights, signals and • Check operation. • Adjust headlight beam.
Panel, removing and installing Spark plug, checking EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18751 EAU19210 Removing and installing the panel Panel A To remove the panel Remove the screws, and then take the panel off. 1 2(✕2) 1 ZAUM00** The panel shown needs to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the panel needs to be removed and installed.
EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR 3. Remove the spark plug as shown, with the spark plug wrench included in the owner’s tool kit. 1 2. Check the spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: BPR7HS (NGK) 2 3 1 4 ZAUM00** To install the spark plug 1. Measure the spark plug gap with a wire thickness gauge and, if necessary, adjust the gap to specification. 5 1.
Final transmission oil EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU20061 Tightening torque: Final transmission oil drain bolt: 18 Nm (1.8 m • kgf, 13 ft • lbf) Final transmission oil The final transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the final transmission oil must be changed as follows at the intervals specified in the periodic maintenance and lubrication chart. 1.
Air filter element, cleaning EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAUT0030 Cleaning the air filter element 1 2(✕2) 1 2 1 ZAUM00** 3 4 5 6 7 1 ZAUM00** 1. Air filter case 2. Screw 1. Air filter element ZAUM00** 4. Remove the air filter case cover by removing the screws. 1. Air filter joint clamp The air filter element should be cleaned at the intervals specified in the periodic maintenance and lubrication chart.
Carburetor EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR 1 3 10. Install the air filter case cover by installing the screws. 11. Install the air filter case by installing the screws, and then install the air filter joint clamp. 12. Install the panel. 2 4 EC000082 cC ● ZAUM00** 7. Apply oil of the recommended type to the entire surface of the air filter element, and then squeeze the excess oil out. NOTE: The air filter element should be wet but not dripping.
Throttle cable free play, checking Tires EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU21382 Checking the throttle cable free play 1 EAUT1701 Tires To maximize the performance, durability, and safe operation of your scooter, note the following points regarding the specified tires. 2 Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before each ride. 1 3 4 EWA10500 w ZAUM00** 5 6 7 8 ● 1.
EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR that the total weight of the cargo, rider, passenger, and accessories (cowling, saddlebags, etc. if approved for this model) does not exceed the maximum load of the vehicle. Operation of an overloaded motorcycle could cause tire damage, an accident, or even injury. Tire inspection sidewall is cracked, have a Yamaha dealer replace the tire immediately. Minimum tire tread depth (front and rear): 0.8 mm (0.
Wheels Front brake lever free play, checking Rear brake lever free play, adjusting EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU21960 Cast wheels 1 2 3 4 5 6 7 8 9 To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified wheels. ● The wheel rims should be checked for cracks, bends or warpage before each ride. If any damage is found, have a Yamaha dealer replace the wheel.
Brake pads and shoes, checking EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU22380 Checking the front brake pads and rear brake shoes (a) 1 (b) The front brake pads and the rear brake shoes must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. of the wear indicators while applying the brake. If a brake pad has worn to the point that a wear indicator almost touches the brake disc, have a Yamaha dealer replace the brake pads as a set.
Brake fluid level, checking EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR limit line, have a Yamaha dealer replace the brake shoes as a set. EAU32343 Checking the front brake fluid level 1 2 1 3 Recommended brake fluid: DOT 4 4 ZAUM00** 5 1. Minimum level mark Insufficient brake fluid may allow air to enter the brake system, possibly causing it to become ineffective. Before riding, check that the brake fluid is above the minimum level mark and replenish if necessary.
Brake fluid, changing Cables, checking and lubricating Throttle grip and cable, checking and lubricating EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU22720 Changing the brake fluid Have a Yamaha dealer change the brake fluid at the intervals specified in the NOTE after the periodic maintenance and lubrication chart.
Autolube pump, adjusting Brake levers, lubricating EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 EAU23120 EAU43640 Adjusting the Autolube pump Lubricating the front and rear brake levers The Autolube pump is a vital and sophisticated component of the engine, which must be adjusted by a Yamaha dealer at the intervals specified in the periodic maintenance and lubrication chart.
Centerstand, checking and lubricating Front fork, checking EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU23191 Checking and lubricating the centerstand EAU23271 Checking the front fork The condition and operation of the front fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. 1 2 To check the condition EWA10750 w Securely support the motorcycle so that there is no danger of it falling over.
Steering, checking Wheel bearings, checking EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU23280 1 2 3 EAU23290 Checking the steering Checking the wheel bearings Worn or loose steering bearings may cause danger. Therefore, the operation of the steering must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place a stand under the engine to raise the front wheel off the ground.
Battery EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU23380 EWA10760 CHILDREN. w Battery ● 1 ZAUM00** 1. Battery The battery is located behind panel A. (See page 6-7.) This model is equipped with a sealedtype (MF) battery, which does not require any maintenance. There is no need to check the electrolyte or to add distilled water. ● ECA10620 cC Never attempt to remove the battery cell seals, as this would permanently damage the battery.
Fuse, replacing EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR ● 1 2 3 4 battery can cause permanent battery damage. To charge a sealed-type (MF) battery, a special (constant-voltage) battery charger is required. Using a conventional battery charger will damage the battery. If you do not have access to a sealed-type (MF) battery charger, have a Yamaha dealer charge your battery.
Troubleshooting EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU25860 Troubleshooting Although Yamaha scooters receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting chart represents a quick and easy procedure for checking these vital systems yourself.
Troubleshooting chart EAU17226 PERIODIC MAINTENANCE AND MINOR REPAIR EAU25901 Troubleshooting chart EWA10840 w 1 Keep away open flames and do not smoke while checking or working on the fuel system. 2 1. Fuel 3 4 5 There is enough fuel. Check the compression. There is no fuel. Supply fuel. There is compression. Check the ignition. There is no compression. Have a Yamaha dealer check the vehicle. Check the fuel level in the fuel tank. The engine does not start. Check the compression. 2.
Care EAU25991 SCOOTER CARE AND STORAGE EAU26091 axles. Always rinse the dirt and degreaser off with water. Care While the open design of a scooter reveals the attractiveness of the technology, it also makes it more vulnerable. Rust and corrosion can develop even if high-quality components are used. A rusty exhaust pipe may go unnoticed on a car, however, it detracts from the overall appearance of a scooter.
SCOOTER CARE AND STORAGE 1 2 3 4 5 6 7 8 9 After normal use Remove dirt with warm water, a mild detergent, and a soft, clean sponge, and then rinse thoroughly with clean water. Use a toothbrush or bottlebrush for hard-to-reach areas. Stubborn dirt and insects will come off more easily if the area is covered with a wet cloth for a few minutes before cleaning.
Storage SCOOTER CARE AND STORAGE EAU26300 away the paint. Storage NOTE: Consult a Yamaha dealer for advice on what products to use. Short-term Always store your scooter in a cool, dry place and, if necessary, protect it against dust with a porous cover. ECA10820 cC ● ● Storing the scooter in a poorly ventilated room or covering it with a tarp, while it is still wet, will allow water and humidity to seep in and cause rust.
SCOOTER CARE AND STORAGE spark plug electrodes while turning the engine over. 1 2 3 4 5 6 7 8 9 NOTE: Make any necessary repairs before storing the scooter. 5. Lubricate all control cables and the pivoting points of all levers and pedals as well as of the sidestand/ centerstand. 6. Check and, if necessary, correct the tire air pressure, and then lift the scooter so that both of its wheels are off the ground.
Specifications EAU26320 SPECIFICATIONS Type YAMALUBE 2 or 2-stroke engine oil Dimensions Overall length 1890 mm (74.4 in) Overall width 705 mm (27.8 in) Overall height 1110 mm (43.7 in) Seat height 765 mm (30.1 in) Wheelbase 1275 mm (50.2 in) Ground clearance 120 mm (4.72 in) Minimum turning radius 1800 mm (70.9 in) Engine oil quantity Quantity 1.40 L (1.48 US qt) (1.23 Imp.qt) Transmission oil Type SAE 85W140 Oil change quantity 0.11 L (0.12 US qt) (0.10 Imp.
SPECIFICATIONS Tire air pressure (measured on cold tires) 1 2 3 4 Loading condition 90 kg (198 lb) Front 200 kPa (29 psi) (2.00 kgf/cm2) Rear 200 kPa (29 psi) (2.00 kgf/cm2) Loading condition 90 kg - maximum load Front 200 kPa (29 psi) (2.00 kgf/cm2) Rear 200 kPa (29 psi) (2.00 kgf/cm2) Front wheel 5 6 8 9 Front suspension (2.00 bar) (2.00 bar) Type Telescopic fork Spring/shock absorber type Coil spring/oil damper Rear suspension (2.00 bar) (2.
Identification numbers Key identification number Vehicle identification number EAU26342 CONSUMER INFORMATION EAU26351 Identification numbers EAU26381 Key identification number Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is stolen.
Model label CONSUMER INFORMATION EAU26460 Model label 1 1 2 3 4 5 6 7 ZAUM00** 1. Model label The model label is affixed to the location shown. Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 8 9 9-2 5PJ-F8199-14_ch9ind.
Safety defects, reporting CONSUMER INFORMATION EAU26551 Reporting safety defects If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Yamaha Motor Corporation, U.S.A.
Noise regulation CONSUMER INFORMATION EAU26580 Scooter noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: 1 2 3 4 Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any device or element of design incorporated into any new vehicle for the purpose of noise control prior to its sale or delivery to the ultimate purchaser or while it is in use or (2) the us
Maintenance record CONSUMER INFORMATION EAU26600 Maintenance record Copies of work orders and/or receipts for parts purchased and installed on your motorcycle will be required to document that maintenance has been completed in accordance with the emissions warranty. The chart below is printed only as a reminder that maintenance work is required. It is not acceptable proof of maintenance work.
CONSUMER INFORMATION 1 Maintenance interval 16000 mi (25000 km) or 48 months 2 18000 mi (28000 km) or 54 months 3 20000 mi (31000 km) or 60 months Date of service Servicing dealer name and address Mileage 4 5 6 7 8 9 9-6 5PJ-F8199-14_ch9ind.
Warranty, limited CONSUMER INFORMATION EAU26681 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY 1 2 3 4 5 6 7 8 9 9-7 5PJ-F8199-14_ch9ind.
CONSUMER INFORMATION 1 2 3 4 5 6 7 8 9 9-8 5PJ-F8199-14_ch9ind.
Warranty, extended CONSUMER INFORMATION EAU26750 YAMAHA EXTENDED SERVICE (Y.E.S.) Keep your Yamaha protected even after your warranty expires with genuine Yamaha Extended Service (Y.E.S.). In addition, Travel and Recreation Interruption Protection (TRIP) is included at no extra cost.
CONSUMER INFORMATION We urge you to act now. You’ll get the excellent benefits of TRIP coverage right away, and you’ll rest easy knowing you’ll have strong factory-backed protection even after your Yamaha Limited Warranty expires. 1 2 3 4 A special note: If visiting your dealer isn’t convenient, contact Yamaha with your Primary ID number (your frame number). We’ll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O.
INDEX Fuel gauge ............................................... 3-3 Fuse, replacing ...................................... 6-22 2 2-stroke engine oil level warning light ...... 3-2 Seat .......................................................... 3-8 Spark plug, checking ............................... 6-7 Specifications ........................................... 8-1 Speedometer unit ..................................... 3-2 Start switch ..............................................
INDEX 5PJ-F8199-14_ch9ind.
1 2 3 4 5 6 7 8 9 5PJ-F8199-14_ch9ind.
1 2 3 4 5 6 7 8 9 5PJ-F8199-14_ch9ind.
1 2 3 4 5 6 7 8 9 5PJ-F8199-14_ch9ind.
1 2 3 4 5 6 7 8 9 5PJ-F8199-14_ch9ind.
1 2 3 4 5 6 7 8 9 5PJ-F8199-14_ch9ind.
YAMAHA MOTOR TAIWAN CO., LTD PRINTED IN TAIWAN ×1! 2007.06-1.3× (E) 5PJ-F8199-14_Cv.
