Product Manual

ManualsBrandsWelch Allyn ManualsDiagnostics2.5 V Rechargeable Fiber Optic HPX Laryngoscope Handle

4341 State Street Road

PO Box 220

Skaneateles Falls, NY 13153-0220 USA

Tel: +1 315 685 4560

Fax: +1 315 685 3361

www.welchallyn.com

Part No. 690048-1 Rev D

Fiber Optic Laryngoscope Blades and

Handles

Fiber Optic Laryngoscope Blades

Care and Maintenance

Welch Allyn laryngoscope blades are crafted from enduring stainless steel. To insure

maximum life and performance the following instructions should be strictly adhered to.

Miller, MacIntosh, and E-MacIntosh styles of fiber optic blades all have removable light

pipes. This unique feature eliminates the expense of replacing the entire blade due to

the fiber bundle deterioration that results from repeated exposure to disinfection and

sterilization agents. Now the bundle can simply be replaced at a fraction of the cost of a

new blade.

Cleaning Procedure

Immediately after use, blades should be rinsed in clean tap water to remove any residue.

The fiber optic light pipe should be removed from the blade following the procedure

outlined in the Fiber Optic Light Pipe Replacement section. Both the light pipe and blade

should then be gently scrubbed in soapy water, with a soft brush, to provide a thorough

physical cleaning.

All Welch Allyn blades are compatible with enzymatic cleaners. Refer to manufacturer’s

instructions for recommended exposure times and solution strengths.

After cleaning, thoroughly rinse the light pipe and blade, dry, and reassemble (see Fiber

Optic Light Pipe Replacement section) prior to disinfection or sterilization.

Note

If germicidal solutions are required for cleaning, please contact Welch Allyn for

compatibility.

WARNING Ultrasonic cleaning is not recommended.

Summary of content (8 pages)

PAGE 1
Part No. 690048-1 Rev D 4341 State Street Road PO Box 220 Skaneateles Falls, NY 13153-0220 USA Tel: +1 315 685 4560 Fax: +1 315 685 3361 www.welchallyn.com 1 Fiber Optic Laryngoscope Blades and Handles Fiber Optic Laryngoscope Blades Care and Maintenance Welch Allyn laryngoscope blades are crafted from enduring stainless steel. To insure maximum life and performance the following instructions should be strictly adhered to.
PAGE 2
Fiber Optic Laryngoscope Blades and Handles Welch Allyn Disinfection/Sterilization (Minimum High Level Disinfection Required) Sterrad®System: Welch Allyn laryngoscope blades are compatible with Sterrad hydrogen peroxide plasma system. However, only light pipes with recessed area where the light pipe exits the top of the green base are compatible. These may also be identified by black marking for model number and size on rear of blade. See figure 1.
PAGE 3
Directions for Use Fiber Optic Laryngoscope Blades and Handles 3 Fiber Optic Laryngoscope Handle Battery handles consist of two sections: the main handle and the lamp holder cartridge assembly (see Figure). Prior to cleaning and disinfection, disassemble the handle following the procedure outlined in the Repair/Maintenance section. The main handle will withstand the same cold soak solutions and autoclave ranges outlined in the Laryngoscope Blades Section.
PAGE 4
Fiber Optic Laryngoscope Blades and Handles Welch Allyn Lamp Cartridge Lamp cartridge can be wiped with cloth dampened with 70% isopropyl alcohol. DO NOT ALLOW SOLUTION TO ENTER INTO CARTRIDGE. The lamp cartridge CANNOT be SOAKED OR AUTOCLAVED. May be ethylene oxide sterilized (see above). Lamp should be left in. Repair/Maintenance Battery Replacement See figure 4 1. Unscrew bottom cap and remove batteries. Stubby handles: pull on tab to remove battery pack.
PAGE 5
Directions for Use Fiber Optic Laryngoscope Blades and Handles 5 5. Be sure lamp and lamp shroud are sufficiently tightened before replacing lamp holder cartridge in main handle. Caution Halogen lamps are pressurized to provide maximum efficiency and illumination. Protect lamp’s glass against abrasion and scratches. Dispose of lamp with care. 6. To replace lamp holder cartridge in the main handle, invert handle.
PAGE 6
Fiber Optic Laryngoscope Blades and Handles Welch Allyn Fiber Optic Larygnoscope Reference Chart Handles Style Ref Battery Lamp Lamp Cartridge “AA” Cell 60814 “AA” Alkaline 06000 608125-501 “C” Cell 60813 “C” Alkaline 06000 608125-501 2.5V Rechargeable 60713 Welch Allyn 72000 06000 608125-501 Stubby 60815 “AA” Alkaline 06000 608125-501 3.5V Rechargeable 60835 Welch Allyn 72200 00300 608351-501 (3.
PAGE 7
Directions for Use Fiber Optic Laryngoscope Blades and Handles Figure 1 Figure 2 Blade Light Carrier Compatible Not Compatible Figure 3 Locking Screw Assembly Main Handle Figure 4 Cartridge Batteries Figure 5 Outer Outer Shroud Shroud Lamp Lamp Bottom Cap LampLamp Holder Holder Cartridge Cartridge LampLamp Holder Holder Cartridge Cartridge Assembly Assembly The CE mark on this product indicates it has been tested to and conforms with the provisions noted within the 93/42/EEC Medical Device D
PAGE 8
Fiber Optic Laryngoscope Blades and Handles Welch Allyn