Material Safety Data Sheet

UTILITY MANUFACTURING CO., INC.
700 MAIN STREET, WESTBURY, NY 11590
[phone] - FAX # [phone]
PASTE SOLDERING FLUX
Page1 14-205
MATERIAL SAFETY DATA SHEET
FOR CHEMICAL EMERGENCY: Spill, Leak, Fire, Exposure, or Accident - Call CHEMTREC - Day or Night: 1-800-424-9300
THIS MSDS COMPLIES WITH 29 CFR 1910.1200 (HAZARD COMMUNICATION STANDARD) IMPORTANT: Read this MSDS
before handling & disposing of this product. Pass this information on to employees, customers and users of this product.
PRODUCT IDENTIFICATION
DOT Shipping name: CONSUMER COMMODITY, ORM-D CAS NO.: MIXTURE
Chemical Family: CHLORIDE UN/NA #:N/R
DOT Hazard Class: N/R DATE OF ISSUE: 4/08
SECTION I - HAZARDOUS INGREDIENTS/EXPOSURE LIMITS
Hazardous Ingredients: CAS # TLV/PEL AGENCY TYPE SARA-313(% Range)
ZINC CHLORIDE 7646-85-7 1 MG/M3 ACGIH TWA 40-50
SECTION II - EMERGENCY AND FIRST AID PROCEDURES
WARNING: CORROSIVE
EYE CONTACT: If product is splashed into eyes, flush eyes with clean water for at least 15 minutes and seek medical attention.
SKIN CONTACT: Remove contaminated shoes and clothing and cleanse affected areas thoroughly by washing with mild soap and water
and seek medical attention.
INHALATION: (breathing) Not expected to be a hazard under normal operating conditions..
INGESTION: (swallowing) If swallowed, seek emergency medical attention. Do not induce vomiting. Offer victim water or milk. Do
not give dilutents to someone who is unconsious or having trouble swollowing.
SECTION III - HEALTH HAZARDS / ROUTES OF ENTRY
EYE CONTACT: Eye contact with one or more components of this product can lead to conjunctivitus and corneal burns.
SKIN CONTACT: Contact with the skin can lead to severe burns or dermatitis and ulceration depending on duration of exposure.
SKIN ABSORPTION: Components of this product are not known to be skin absorbing agents.
INHALATION: (breathing) Not expected to be a hazard under normal operating conditions.
INGESTION: (swallowing) Ingestion can lead to stomach pains, nausea, vomiting, bloody diarrhea, edema, albuminuria, ad shock.
SECTION IV - SPECIAL PROTECTION INFORMATION
VENTILATION: Use with adequate ventilation to maintain airborne concentrations below established exposure limits (see section I),
Additional ventilation or exhaust systems may be required.
RESPIRATORY PROTECTION: None required under routine conditions of use.The use of respiratory protection is advised when
concentrates exceed the established exposure limits (see Section I).
PROTECTIVE GLOVES: The use of gloves impermeable to the specific material handled is advised to prevent possible irritation.
EYE PROTECTION: Approved eye protection to safeguard against potential eye contact, irritation or injury is recommended.
SECTION V - REACTIVITY DATA
STABILITY: Stable
INCOMPATIBILITY: (materials to avoid)This product is incompatible with: Oxidizing agents, strong acids and bases potassium,
bromine pentaflouoride, nitrogen trioxide, cydrogen cyanide, iodine pentafluoride and potassium chlorate.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition in the presence of air may yield carbon monoxide, carbon
dioxide.
HAZARDOUS POLYMERIZATION: Will not occur
SECTION VI - SPILL OR LEAK PROCEDURES
PRECAUTIONS IN CASE OF LEAK OR SPILL: Keep all sources of ignition and hot metal surfaces away from spill/release. Stay
upwind and away from spill/release. Isolate hazard area and limit entry to emergency crew only. Stop spill/release if it can be done
without risk. Wear appropriate protective equipment including respiratory protection as conditions warrant (see Section IV). Prevent
spilled material from entering sewers, storm drains, and natural waterways. Dike far ahead of spill for later recovery and disposal. Spilled
material may be absorbed by an appropriate absorbent. Notify fire authorities and appropriate federal, state, and local agencies. If
spill/release is excess of EPA reportable quantity, immediately notify the National Response Center. Phone [phone]
WASTE DISPOSAL METHOD: Dispose of product in accordance with local, county, state, and federal regulations.
SECTION VII - STORAGE AND SPECIAL PRECAUTIONS