® ELEVATED OUTDOOR LIVING PRODUCTS TAILGATER I/II OWNER’S MANUAL TK-1005-T | 7 2802848231 7 TK-1006-T2 | 7 2802848232 4
CONGRATULATIONS ON YOUR TAILGATER™ PURCHASE Take your outing to the next level with the most versatile portable fire pit on the market. The Tailgater comes equipped with a 2.0 audio system and an optional cast-iron cooktop accessory. Connect wirelessly and enjoy the highest quality audio with fire ambiance anywhere you want to be. Upgrade to Ukiah Co.’s “Responsive Flame Technology” and a 2.1 audio system in the Tailgater II.
TABLE OF CONTENTS Page 6 Page 7-8 Page 9-10 Page 11-12 4 SETUP AND OPERATING INSTRUCTIONS SAFETY INFORMATION SETUP INSTRUCTIONS OPERATING INSTRUCTIONS Page 13 LIGHTING SAFETY Page 14 LIGHTING INSTRUCTIONS Page 15 STORAGE INSTRUCTIONS Page 15-17 GENERAL INFORMATION Page 18 AUDIO SYSTEM Page 19 BEAT TO MUSIC MODE Page 19 MAINTENANCE Page 20 OPERATIONAL NOTES Page 20 TROUBLESHOOTING Page 21 WARRANTY
TAILGATER I TAILGATER II 5
SETUP AND OPERATING INSTRUCTIONS FOR GAS FIRE PITS WARNING Please read these setup and operating instructions carefully before setup, operation or service of this gas fire pit. Do not operate if you are uncertain as to the meaning of any instructions or warnings. Improper installation, adjustment, alteration, maintenance, service or use of this product may result in property damage, personal injury or the potential loss of life. Save these instructions for future reference.
SAFETY INFORMATION Failure to follow the DANGERS, WARNINGS, AND CAUTIONS in this owner’s manual may result in serious bodily injury, death, or may result in a fire or an explosion causing damage to property. WARNING: This product is for outdoor use only. WARNING: Do not use this product near vegetation or on, under, or near structures that could catch fire such as wooden decks, vinyl siding, or porches with overhangs. WARNING: This product produces high temperatures that will create hot surfaces.
WARNING: Do NOT store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance. WARNING: Recheck all connections as described in the “Operating Instructions” section of this manual, as shipping can loosen connections. • Check for leaks even if your unit was assembled for you by someone else. • Do NOT operate if a gas leak is present. Gas leaks may cause a fire or explosion. • You must follow all instructions in the “Checking for Leaks” section before operating.
SETUP INSTRUCTIONS 1) Place the fire pit in the desired location. Make sure that it is placed outdoors in a well-ventilated area away from any flammable structures, awnings, vegetation, etc. 2) Connect the battery charger to the charging port in the back of the unit. Make sure battery is fully charged before use. The battery indicator light on the supplied charger will turn green when battery is fully charged. Battery will run for up to 20 hours on a single charge.
5) Place your 20lb LP tank in a location that is not in a walkway or where it can be easily knocked over. For best results use in a tank holder. 6) Connect the supplied regulator hose assembly to the 20lb LP tank by hand-tightening the black QCC1 nut clockwise until firmly seated. Then, connect the opposite end of the regulator hose to the unit by hand-tightening the brass connection fitting until tight. Do not use a wrench or over-tighten.
OPERATING INSTRUCTIONS The LP gas tank is NOT included with the gas fire pit. SAFE HANDLING FOR LP GAS TANK: • Do not use a damaged, dented or rusty LP tank. • Handle empty LP tanks with the same care as you handle full tanks. Even when the LP tank is empty of liquid, there may still be gas pressure inside the cylinder. • LP gas tanks should never be dropped or handled roughly. • Never store or transport the LP tank where temperatures can reach 125 °F (51.7 °C).
REMOVING THE LP TANK: When the LP tank needs to be replaced, follow these instructions to remove it. 1. Make sure gas control knob is turned “OFF” by pushing it in and turning it clockwise to the off position. 2. While holding carrying handle closest to propane cylinder with one hand, unscrew propane cylinder from regulator. LEAK TESTING: All factory-made connections have been thoroughly tested for gas leaks. However, shipping and handling may have loosened a gas fitting.
LIGHTING SAFETY FOR YOUR SAFETY, READ BEFORE LIGHTING • Make sure you are familiar with the owner’s manual and you understand all precautions noted. • Before operating, smell around the appliance and next to the ground for gas odors because some gases are heavier than air and may settle on the ground. • Use only your hand to turn the gas control valve. Never use tools. If the valve will not turn (that is, without the use of a tool), do not try to repair it. Call a qualified service technician.
LIGHTING INSTRUCTIONS 1) Once battery is fully charged turn the unit “On” by pushing the ON/OFF switch. The switch will glow blue when unit is powered on. 2) Ignite the unit by following the directions located on the unit. 3) The gas supply will automatically shut off after approximately 10 seconds (+/- 3 seconds) if a flame does not start or it is extinguished. If this happens, wait 5 minutes for gas fumes to clear, and re-try or refer to the troubleshooting section if the unit does not re-start.
GENERAL INFORMATION STORAGE INSTRUCTIONS 1. Do not move or store this gas fire pit until the fire has been extinguished and the appliance is cool to the touch. 2. Disconnect the gas source and install the valve plug in the 20lb LP tank. 3. Store the fully assembled unit in a ventilated location away from children and pets. 4. Turn power button off when not using the unit. GENERAL INFORMATION • This device can produce carbon monoxide that has no odor.
• Solid fuels such as wood, paper, or trash should not be burned in this gas fire pit. This product is designed for decorative purposes only, and should not be used for heating, cooking, or drying. • Do not attempt to assemble or operate this fire pit while under the influence of any type of alcohol or medication. Use this gas fire pit in accordance with all applicable local, state, and national codes.
WARNING • DO NOT block any ventilation openings. • Install in accordance with the manufacturer’s instructions. • DO NOT defeat the safety purpose of the polarized or grounding-type plug. A polarized plug has two blades with one wider than the other. A grounding type plug has two blades and a third grounding prong. The wider blade or the third prong are provided for your safety. If the provided plug does not fit into your outlet, consult an electrician for replacement of the obsolete outlet.
AUDIO SYSTEM CHARGING THE BATTERY Before using your Ukiah Co. audio system, fully charge the battery by plugging the charging cable provided into the charging port on the unit. • The LED INDICATOR on the charger will turn RED when the battery is charging. • The LED INDICATOR will turn GREEN when the battery is fully charged. PAIRING TO A WIRELESS DEVICE 1. Turn your wireless device OFF entirely and then turn it back ON to refresh the device’s wireless memory. 2.
BEAT TO MUSIC OPERATION 1. Start fire in “Fire Only” mode. a. Turn gas knob to “Fire Only”. b. Push and hold gas knob until fire is lit. (Hold for 5-10 seconds or until fire stays on). c. Release knob after flame stays lit by itself. AFTER FIRE PIT IS LIT: 2. Push the “Beat to Music” button. Button will glow orange when ON. 3. Turn gas control knob to the “Beat to Music” icon. The flame will drop down to low. a. When the two icons are matched, “Beat to Music” mode will be engaged. 4.
OPERATIONAL NOTES 1. DO NOT move the unit for at least 60 minutes after use to allow for cooling. 2. Allow the burner and glass crystals or lava rock to cool completely before touching. 3. Glass crystals or lava rock may be sharp. Before handling, make certain they have cooled completely and handle them wearing protective gloves to prevent injury. TROUBLESHOOTING PROBLEM Burner won’t light. Burner flame is low. Carbon build-up. Thick black smoke.
WARRANTY ONE-YEAR LIMITED WARRANTY • The Limited Warranty described above is extended only to the original end-use purchaser and is non-transferable. It does not include parts or labor to repair damage caused by mishandling, accident, negligence, misuse, normal wear and tear, normal cosmetic deterioration, or damage caused by environmental conditions. While necessary repairs or maintenance on your Ukiah Co.
• Some jurisdictions do not allow the exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you, and in such cases, the provisions of this Limited Warranty are in addition to and not a modification of or subtraction from any statutory warranties and other rights and remedies provided by law. • No distributor, dealer, retailer, reseller, vendor, sales person or other person is authorized by Ukiah Co.
NOTES: 23
IGNITE THE MUSIC™ www.UKIAHCO.com © UKIAH CO. 2019 ALL RIGHTS RESERVED // PATENTED SEE WWW.UKIAHCO.
FCC Warning This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. Any Changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate the equipment.